This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Experimental Measurements and Computations for Clarifying Nearly Complete Air-Insulation Obtained by the Concept of Colliding Pulsed Supermulti-Jets
Technical Paper
2017-01-1030
ISSN: 0148-7191, e-ISSN: 2688-3627
This content contains downloadable datasets
Annotation ability available
Sector:
Language:
English
Abstract
In our previous papers, a new concept of a compressive combustion engine (Fugine) was proposed based on the collision of pulsed supermulti-jets, which can enclose the burned gas around the chamber center leading to an air-insulation effect and also a lower exhaust gas temperature due to high single-point compression. In order to examine the compression level and air-insulation effect as basic data for application to automobiles, aircraft, and rockets, a prototype engine based on the concept, i.e., a piston-less prototype engine with collision of bi-octagonal pulsed multi-jets from fourteen nozzles, was developed. Some combustion results [Naitoh et al. SAE paper, 2016] were recently reported. However, there was only one measurement of wall temperature and pressure in the previous report. Thus, in this paper, more experimental data for pressures and temperatures on chamber walls and exhaust temperatures, are presented for the prototype engine. First, pressure over 0.6MPa was measured on the chamber wall. A nearly complete air insulation effect was presumably obtained based on the experimental data for temperature measured on the chamber wall. The measured exhaust temperature was at an intermediate level around 700K. Experimental data are also presented for the air-insulation effect on a small solid wall located downstream from the collision point of the supermulti-jets. Unsteady three-dimensional computations of compressible flow also indicate that the experimental result of 0.6 MPa at the cylinder wall implies pressure of about 5 MPa at the collision point of the jets. The potential for high thermal efficiency is evaluated on the basis of the data.
Recommended Content
| Technical Paper | Variables Affecting Flame Speed in the Otto-Cycle Engine |
| Technical Paper | Non-classical Orifice Characterization |
Authors
- Remi Konagaya - Waseda University
- Susumu Oyanagi - Waseda University
- Takuto Kanase - Waseda University
- Jumpei Tsuchiya - Waseda University
- Ken Ayukawa - Waseda University
- Kodai Kinoshita - Waseda University
- Junya Mikoda - Waseda University
- Hirotaka Fujita - Waseda University
- Ken Naitoh - Waseda University
Topic
Citation
Konagaya, R., Oyanagi, S., Kanase, T., Tsuchiya, J. et al., "Experimental Measurements and Computations for Clarifying Nearly Complete Air-Insulation Obtained by the Concept of Colliding Pulsed Supermulti-Jets," SAE Technical Paper 2017-01-1030, 2017, https://doi.org/10.4271/2017-01-1030.Data Sets - Support Documents
| Title | Description | Download |
|---|---|---|
| Unnamed Dataset 1 | ||
| Unnamed Dataset 2 | ||
| Unnamed Dataset 3 | ||
| Unnamed Dataset 4 |
Also In
References
- Nakajima , Y. , Muranaka , S. Automobile Gasoline Engines Tokyo Sankaido 1999
- Kerrebrock , JL. Aircraft Engines and Gas Turbines Cambridge, MA MIT Press 1992 1 494
- Takagi , Y. , Itoh , T. , Muranaka , S. , Iiyama , A. et al. Simultaneous Attainment of Low Fuel Consumption High Output Power and Low Exhaust Emissions in Direct Injection SI Engines SAE Technical Paper 980149 1998 10.4271/980149
- Kailasanath , K. Review of Propulsion Applications of Detonation Waves AIAA Journal 39 9 2000 1698 1708
- Jackson , TA. Power for a Space Plane Scientific American 295 2 2006 56 63
- Kuboyama , T. , Moriyoshi , Y. , Hatamura , K. , Takanashi , J. et al. A Study of Newly Developed HCCI Engine With Wide Operating Range Equipped With Blowdown Supercharging System SAE Int. J. Engines 5 2 51 66 2012 10.4271/2011-01-1766
- Kiplimo R , Tomita E , Kawahara N , Yokobe S Combustion and Emission Characteristics of a Premixed Charge Compression Ignition Engine Journal of Sustainable Research in Engineering 1 1 2014 8 16
- Naitoh , K. Engine patents. 2010-2011 and also submitted as another patent 2014
- Naitoh , K. A New Cascade-Less Engine Operated from Subsonic to Hypersonic Conditions J. of Thermal Science 2010 481 485
- Naitoh , K. , Shinimu , D. , Nonaka , S. , Kainuma , Y. , and Emoto , T. The fifth compression strategy for hypersonic aircar AIAA paper 2012-3314 2012
- Naitoh , K. , Shimizu , D. , Nonaka , S. Stability limit of supermulti-jets convergence engine operated from startup to extremely-hypersonic conditions: revealed by shock-tube experiments AIAA paper 2012-5923 2012
- Naitoh , K. , Nakamura , K. , Emoto , T. , and Shimada , T. A Wide-range Single Engine: operated from startup to hypersonic AIAA paper 2011-2316 2011
- Naitoh , K. , Emoto , T. , Nakamura , K. , and Kainuma , Y. An Ultimate Engine: designed by Computational Fluid Dynamics SAE Technical Paper 2011-01-2027 2011 10.4271/2011-01-2027
- Naitoh , K. , Marui , M. , Ishida , K. , Sagara , Y. et al. Simultaneous attainment of light-weight, high efficiency, and low noise: by supermultijets-twister engine working from startup to hypersonic scram mode AIAA paper 2013-3011 2013
- Hashimoto , T. , Naitoh , K. , Tanakna , M. , Nojima , Y. et al. Strongly-asymmetric Double Piston Engine: Assisted by Super Multi-jets Colliding JSAE paper 81-20135740 2013
- Tamura , T. , Naitoh , K. , Nonaka , S. , Sagara , K. et al. Fundamental Combustion Test Based on Supermulti-jets Colliding 24th Nainen-kikan Symposium Kobe 2013
- Tanaka , M. , Naitoh , K. , Nojima , Y. , Kubota , T. et al. Strongly-symmetric Double Piston Engine: Assisted by Super Multi-jets Colliding 24th Nainen-kikan Symposium Kobe 2013
- Naitoh , K. , Ishida , K. , Nonaka , S. , Kubota , T. et al. Fugine: the supermultijet-convergence engine working from startup to hypersonic scram mode and attaining simultaneously lightweight, high-efficiency, and low noise AIAA paper 2014-3960 2014
- Naitoh , K. , Okamoto , T. , Kubota , T. , Yamagishi , K. et al. Design Guidelines of the Single-Point Auto-Ignition Engine based on Supermulti-Jets Colliding for High Thermal Efficiency and Low Noise: Obtained by Computational Experiments for a Small Strongly-Asymmetric Double-Piston Engine SAE Technical Paper 2014-32-0100 2014 10.4271/2014-32-0100
- Naitoh , K. , Yamagishi , K. , Nonaka , S. , Okamoto , T. et al. Unsteady Three-Dimensional Computational Experiments of the Single-Point Auto-Ignition Engine Based on Semispherical Supermulti-Jets Colliding with Pulse for Automobiles SAE Technical Paper 2014-01-2641 2014 10.4271/2014-01-2641
- Naitoh , K. , Kojima , K. , Okamoto , T. , Yamagishi , K. et al. Physical Theory of the Single-Point Auto-Ignition Engine Based on Supermulti-Jets Colliding with Pulse: Leading to Thermal Efficiency over 60% at Various Engine Speeds and Loads of Automobiles SAE Technical Paper 2014-01-2640 2014 10.4271/2014-01-2640
- Naitoh , K. , Tanaka , Y. , Tamura , T. , Okamoto , T. et al. Fugine cycle theory: predicting high efficiency of the supermultijet-convergence engine working from startup to hypersonic scram mode AIAA paper 2015-2968 2015
- Naitoh , K. , Hasegawa , K. , Kubota , T. , Hashimoto , T. et al. Development Of Fugine Based on Supermulti-Jets Colliding with Pulse: Leading to Stable Plug-Less Start and Improvement of HCCI with Satisfactory Strength of Structure SAE Technical Paper 2014-01-2639 2014 10.4271/2014-01-2639
- Naitoh , K. , Ikoma , D. , Sagara , H. , Tamura , T. et al. Two Small Prototype Engines Developed based on Pulsed Supermulti-Jets Colliding: Having a Potential of Thermal Efficiency Over 60% with Satisfactory Strength of Structure SAE Technical Paper 2014-32-0099 2014 10.4271/2014-32-0099
- Naitoh , K. , Shirai , T. , Tanaka , M. , Nojima , Y. et al. Fugine as Single-Point Compression Engine based on Supermulti-Jets Colliding with Pulse: Combustion Test of Second Prototype Engine with Strongly-Asymmetric Double-Piston System SAE Technical Paper 2015-01-1964 2015 10.4271/2015-01-1964
- Landau , ED and Lifshitz , EM Fluid Mechanics 2nd Oxford Butterworth-Heinemann Elsevier 2004
- Shinmura , N. , Kubota , T. , Naitoh , K. Cycle-resolved computations of stratified-charge turbulent combustion in direct injection engine JSME International Journal of Thermal Science and Engineering 8 3 2013
- Naitoh , K. , and Shimiya , H. Stochastic determinism capturing the transition point from laminar flow to turbulence Japan Journal of Industrial and Applied Mathematics 2011
- Kato , A. , Misawa , S. , Yoshimatsu , A. , Nakamura , M. , and Sawada , D. A Study of Rising Thermal Efficiency Using an Argon Circulated Hydrogen Engine (Third Report) JSAE paper 20135721 2013
- Kailasanath , K. Review of Propulsion Applications of Detonation Waves AIAA Journal 39 9 1698 1708 2000
- Naitoh , K. , Kojima , K. , Hasegawa , K. , Shirai , T. et al. An ultimate engine: based on supermulti-jets colliding with pulsation Forth Report JSAE paper 2016
- Kihara , T. , Yamagishi , K. , Naitoh , K. Three-dimensional computations of fuel spray and mixing process in the engine assisted by supermulti-jets colliding Proceedings of 26th Internal Combustion Engine Symposium 2015
- Honda activated radical combustion system http://www.honda.co.jp/news/1996/296102.html
- Yoshizawa , K. , Teraji , A. , Aochi , E. , Kubo , M. et al. Numerical Analysis of Combustion in Gasoline Compression Ignition Engines SAE Technical Paper 2002-01-2865 2002 10.4271/2002-01-2865
- Naitoh , K. , Tsuchiya , J. , Ikoma , D. , Nakai , T. et al. Computations and Experiments for Clarifying Compression Level and Stability of Colliding Pulsed Supermulti-Jets in a Piston-Less Single-Point Autoignition Engine SAE Technical Paper 2016-01-2331 2016 10.4271/2016-01-2331
- Naitoh , K. , Ohara , S. , Onuma , Y. , Shirai , T. et al. COMBUSTION EXPERIMENT OF SILENT SINGLE-POINT AUTO-IGNITION ENGINE: FUGINE FISITA. F2016-ESYB-002 2016
- Naitoh , K. , Ohara , S. , Onuma , S. , Kojima , K. et al. High Thermal Efficiency Obtained with a Single-Point Autoignition Gasoline Engine Prototype Having Pulsed Supermulti-Jets Colliding in an Asymmetric Double Piston Unit SAE Technical Paper 2016-01-2336 2016 10.4271/2016-01-2336
- Yamagishi , K , Onuma , S. , Ohara , S. , Naitoh , K. et al. Computations and Experiments of Single-Point Autoignition Gasoline Engine with Colliding Pulsed Supermulti-Jets, Single Piston and Rotary Valve SAE Technical Paper 2016-01-2334 2016 10.4271/2016-01-2334
- Tsuru , K. , Naitoh , K. et al AIAA paper 2016
- Konagaya , R. , Naitoh , K. et al. Computation of a New Rocket Engine Using a New Compressive Combustion Principle Based on the Supermulti-jets Colliding with Pulse Book of abstracts of APISAT 2016
- Mitani , S. , Sawada , D. , Kosuda , T. , Fujishiro , O. A Study of Rising Thermal Efficiency using an Argon Circulated Hydrogen Engine Transactions of Society of Automotive Engineers of Japan 39 2 195 199 2008
- United Nations Treaty Collection, Paris agreement https://treaties.un.org/pages/ViewDetails.aspx?src=TREATY&mtdsg_no=XXVII-7-d&chapter=27&clang=_en
- Naitoh , K. , and Kuwahara K. Large eddy simulation and direct simulation of compressible turbulence and combusting flows in engines based on the BI-SCALES method Fluid Dynamics Research 10 1992 299 325
- Takewaki , H. , Nishiguchi , A. , and Yabe , T. The Cubic-Interpolated Pseudo-Particle (CIP) Method for Solving Hyperbolic-Type Equations J. Comput. Phys. 61 1985 261 268