This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Coordinating Research Council Trends in Octane Number Requirement Increase
Annotation ability available
Sector:
Language:
English
Abstract
The Coordinating Research Council, Inc. has studied the octane requirement increase (ORI) of cars and light duty trucks since 1971. This paper investigates ORI trends and influencing effects for over 600 1980 through 1988 model-year vehicles. An analysis of these vehicles shows them to have an average ORI of 3.8 (R+M)/2 measured with refinery-like fuels, and suggests the average ORI decreased from 1980 through 1986, followed by a possible, but statistically uncertain, increase starting in 1987 or 1988. A number of factors have contributed to lower ORI, including higher compression ratios, use of aluminum cylinder heads, multiport fuel injection, and three-way catalyst systems.
SPARK KNOCK IS THE NOISE produced by the auto-ignition of the air-fuel mixture in the end gases of the spark-ignition engine. The engine's octane number requirement (ONR) is defined in terms of the highest octane quality reference fuel that produces borderline spark knock under a defined set of operating conditions. In most of today's engines, the ONR increases rapidly when the engine is new, but the ONR eventually reaches a stabilized value at higher mileage (about 15,000 miles in modern engines). This increase in ONR is referred to as octane requirement increase (ORI).
The literature suggests that ORI can be attributed to two major causes. The first is the influence on ORI of combustion-chamber heat-transfer and gas temperatures, as affected by combustion chamber deposits and engine design characteristics. It is suspected to have the largest effect on ORI. The second cause is the mechanical increase in compression ratio caused by the accumulation of deposits in the combustion chamber. This is thought to have a lesser effect on ORI, particularly for engines operated on unleaded gasoline.
The Coordinating Research Council, Inc. (CRC) has cooperatively investigated octane number requirements of vehicles since 1946, and has reported on octane requirement increase since 1971.
The objective of this paper is to conduct a systematic analysis of CRC octane requirement increase data on 1980 through 1988 model-year vehicles in order to establish trends and investigate factors influencing octane requirement increase.
Recommended Content
Topic
Citation
Callison, J., Wusz, T., and Biller, W., "Coordinating Research Council Trends in Octane Number Requirement Increase," SAE Technical Paper 892036, 1989, https://doi.org/10.4271/892036.Also In
References
- Mikita J. J. Bettoney W. E. “Combustion Chamber Deposits and Their Effects on Engine Fuel Requirements” Presented at the Forty-First Annual Meeting of the Western Petroleum Refiners Association San Antonio, Texas March 23-25 1953
- Gibson H. J. Hall C. A. Hirscher D. A. “Combustion Chamber Deposition and Knock” SAE Transactions 61 1953
- McNab J. G. Moody L.S. Hakala N. V. “Effect of Lubricant Composition on Combustion Chamber Deposits” SAE Transactions 62 1954
- Benson J. D. “Some Factors Which Affect Octane Requirement Increase” SAE Paper No. 750933
- Keller B. D. Meguerian G. H. Tracy C. B. Smith J. B. “ORI of Today's Vehicles” SAE Paper No. 760195
- Keller B.D. “ORI of Today's Vehicles - Part 2” SAE Paper 770195
- Coordinating Research Council, Inc. “Influence of Leaded and Unleaded Fuels on Octane Requirement Increase in 1971 Model Cars” CRC Report No. 445 March 1971
- Coordinating Research Council, Inc. “Octane Requirement Increase in 1973 Model Cars,” CRC Report No. 476 Febuary 1975
- Coordinating Research Council, Inc. “Octane Requirement Increase in 1974 Model Cars,” CRC Report No. 485 June 1976
- Coordinating Research Council, Inc. “Octane Number Requirement Increase in 1975 Model Cars,” CRC Report No. 498 July 1978
- Octane Requirement Increase in 1976 Model Cars, CRC Road Test Group Informal Study Rogers J. D. Jr. October 1979
- Coordinating Research Council, Inc. “Octane Requirement Increase of 1977 Model Cars,” CRC Report No. 513 April 1980
- Coordinating Research Council, Inc. “Octane Requirement Increase of 1978 and 1979 Model Cars,” CRC Report No. 526 April 1982
- Coordinating Research Council, Inc. “Octane Requirement Increase of 1980 Model Cars,” CRC Report No. 531 June 1983
- Coordinating Research Council, Inc. “Octane Requirement Increase of 1981 Model Cars,” CRC Report No. 535 November 1983
- Coordinating Research Council, Inc. “Octane Requirement Increase of 1982 Model Cars,” CRC Report No. 540 September 1984
- Coordinating Research Council, Inc. “Octane Requirement Increase of 1983 Model Cars,” CRC Report No. 545 November 1985
- Coordinating Research Council, Inc. “Octane Requirement Increase of 1984 Model Cars CRC Report No. 549 October 1986
- Coordinating Research Council, Inc. Unpublished Summary Letter on “Octane Requirement Increase of 1985/1986 Model Cars,” Circulated April 14 1988 Data included as to SAE Paper Number 892036 )
- Coordinating Research Council, Inc. Unpublished Data on “Octane Requirement Increase of 1987/1988 Model Cars.” Sata included as to SAE Paper Number 892036 )
- Correspondence to Nelson R. K. Gibbs L.M. Chevron Research Company May 16 1983 “1980 CRC Octane Requirement Increase Program.”