This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Influence of Oxygenated Hemp Seed Biodiesel Blends on Performance and Emission Phenomenon at Variable Compression Ratio of Compression Ignition Engine
Technical Paper
2020-01-5069
ISSN: 0148-7191, e-ISSN: 2688-3627
This content contains downloadable datasets
Annotation ability available
Sector:
Event:
Automotive Technical Papers
Language:
English
Abstract
The focus of this study is to assess the performance and emission parameters of the oxygenated blended fuel of hemp seed biodiesel at various compression ratios (17:1, 17.5:1, and 18:1) using a single-cylinder four-stroke direct injection compression ignition engine. Hemp seed bio-oil was extracted using the soxhlet apparatus. Single-stage transesterification process was adopted due to lower free fatty acid content. Methanol and sodium hydroxide was used as reagents. The ternary test fuel blend was prepared by adding the diesel-HSBD with 10% of diethyl ether (DEE). Higher brake thermal efficiency (BTE) of 33.98% was observed for D80HSBD20DEE10 at CR 18:1, whereas CR 17.5:1 and CR 17:1 gave a 3% to 6% lower BTE. The brake-specific fuel consumption (BSFC) for D80HSBD20DEE10 blend showed a marginally lower value at CR 17:1. But, it increased up to 373 g/kWhr upon increasing the CR to 18:1. Exhaust gas temperature increased with increase in compression ratios. UBHC and CO emissions had a similar trend at all loads but with a significant reduction for CR 18:1. Addition of DEE escalated the NOx emissions by 4% to 6% as the compression ratio was increased from 17:1 to 18:1. Smoke emission reduced significantly with oxygenated fuel blends but showcased an increasing trend with the increase in compression ratios. The in-cylinder pressure variation and heat release analysis were also improved for oxygenated diesel-biodiesel blends.
Authors
- Hariram Venkatesan - Hindustan Institute of Technology & Science
- PM Bharadwaj - Hindustan Institute of Technology & Science
- A Viswaksen - Hindustan Institute of Technology & Science
- CH Surya - Hindustan Institute of Technology & Science
- D Ruthvin Maheej - Hindustan Institute of Technology & Science
- S Seralathan - Hindustan Institute of Technology & Science
- T Micha Premkumar - Hindustan Institute of Technology & Science
Topic
Citation
Venkatesan, H., Bharadwaj, P., Viswaksen, A., Surya, C. et al., "Influence of Oxygenated Hemp Seed Biodiesel Blends on Performance and Emission Phenomenon at Variable Compression Ratio of Compression Ignition Engine," SAE Technical Paper 2020-01-5069, 2020, https://doi.org/10.4271/2020-01-5069.Data Sets - Support Documents
Title | Description | Download |
---|---|---|
Unnamed Dataset 1 | ||
Unnamed Dataset 2 | ||
Unnamed Dataset 3 | ||
Unnamed Dataset 4 | ||
Unnamed Dataset 5 |
Also In
References
- Li , S.Y. , Stuart , J.D. , Li , Y. , and Parnas , R.S. The Feasibility of Converting Cannabis sativa L. Oil into Biodiesel Bioresource Technology 101 21 8457 8460 2010
- Santillan-Jimenez , E. , Loe , R. , Garrett , M. , Morgan , T. , and Crocker , M. Effect of Cu Promotion on Cracking and Methanation during the Ni-Catalyzed Deoxygenation of Waste Lipids and Hemp Seed Oil to Fuel-like Hydrocarbons Catalysis Today 302 261 271 2018
- Galasso , I. , Russo , R. , Mapelli , S. , Ponzoni , E. et al. Variability in Seed Traits in a Collection of Cannabis sativa L. Genotypes Frontiers in Plant Science 7 688 2016
- Devan , P.K. and Mahalakshmi , N.V. Performance, Emission and Combustion Characteristics of Poon Oil and Its Diesel Blends in a DI Diesel Engine Fuel 88 5 861 867 2009
- Hariram , V. , Seralathan , S. , Bhutoria , K. , and Vora , H.H. Experimental Study on Combustion and Performance Characteristics in a DI CI Engine Fuelled with Blends of Waste Plastic Oil Alexandria Engineering Journal 57 2257 2263 2018
- Sekhar , S.C. , Karuppasamy , K. , Vedaraman , N. , Kabeel , A.E. et al. Biodiesel Production Process Optimization from Pithecellobiumdulce Seed Oil: Performance, Combustion, and Emission Analysis on Compression Ignition Engine Fuelled with Diesel/Biodiesel Blends Energy Conversion and Management 161 141 154 2018
- Hariram , V. and Vasanthaseelan , S. Optimization of Base Catalysed Transesterification and Characterization of Brassica napus (Canola seed) for the Production of Biodiesel International Journal of ChemTech Research 8 9 418 423 2015
- Su , M. , Yang , R. , and Li , M. Biodiesel Production from Hempseed Oil Using Alkaline Earth Metal Oxides Supporting Copper Oxide as Bi-functional Catalysts for Transesterification and Selective Hydrogenation Fuel 103 398 407 2013
- Gupta , A.R. , Jalan , A.P. , and Rathod , V.K. Solar Energy as a Process Intensification Tool for the Biodiesel Production from Hempseed Oil Energy Conversion and Management 171 126 132 2018
- Stamenković , O.S. , Veličković , A.V. , Kostić , M.D. , Joković , N.M. et al. Optimization of KOH-Catalyzed Methanolysis of Hempseed Oil Energy Conversion and Management 103 235 243 2015
- Kostić , M.D. , Joković , N.M. , Stamenković , O.S. , Rajković , K.M. et al. The Kinetics and Thermodynamics of Hempseed Oil Extraction by n-hexane Industrial Crops and Products 52 679 686 2014
- Kavitha , M.S. and Murugavelh , S. Optimization and Transesterification of Sterculia Oil: Assessment of Engine Performance, Emission and Combustion Analysis Journal of Cleaner Production 234 1192 1209 2019
- Nanthagopal , K. , Ashok , B. , Garnepudi , R.S. , Tarun , K.R. , and Dhinesh , B. Investigation on Diethyl Ether as an Additive with Calophyllum Inophyllum Biodiesel for CI Engine Application Energy Conversion and Management 179 104 113 2019
- Yesilyurt , M.K. and Aydin , M. Experimental Investigation on the Performance, Combustion and Exhaust Emission Characteristics of a Compression-Ignition Engine Fueled with Cottonseed Oil Biodiesel/Diethyl Ether/Diesel Fuel Blends Energy Conversion and Management 205 112355 2020
- Swaminathan , C. and Sarangan , J. Performance and Exhaust Emission Characteristics of a CI Engine Fueled with Biodiesel (fish oil) with DEE as Additive Biomass and Bioenergy 39 168 174 2012
- Huang , J. , Wang , Y. , Li , S. , Roskilly , A.P. et al. Experimental Investigation on the Performance and Emissions of a Diesel Engine Fuelled with Ethanol-Diesel Blends Applied Thermal Engineering 29 11-12 2484 2490 2009
- Chauhan , B.S. , Kumar , N. , and Cho , H.M. A Study on the Performance and Emission of a Diesel Engine Fueled with Jatropha Biodiesel Oil and Its Blends Energy 37 1 616 622 2012
- Sivalakshmi , S. and Balusamy , T. Effect of Biodiesel and Its Blends with Diethyl Ether on the Combustion, Performance and Emissions from a Diesel Engine Fuel 106 106 110 2013
- Ibrahim , A. Investigating the Effect of Using Diethyl Ether as a Fuel Additive on Diesel Engine Performance and Combustion Applied Thermal Engineering 107 853 862 2016
- Venu , H. and Madhavan , V. Influence of Diethyl Ether (DEE) Addition in Ethanol-Biodiesel-Diesel (EBD) and Methanol-Biodiesel-Diesel (MBD) Blends in a Diesel Engine Fuel 189 377 390 2017
- Nabi , M.N. , Rahman , M.M. , and Akhter , M.S. Biodiesel from Cotton Seed Oil and Its Effect on Engine Performance and Exhaust Emissions Applied Thermal Engineering 29 11-12 2265 2270 2009
- Alagu , K. , Venu , H. , Jayaraman , J. , Raju , V.D. et al. Novel Water Hyacinth Biodiesel as a Potential Alternative Fuel for Existing Unmodified Diesel Engine: Performance, Combustion and Emission Characteristics Energy 179 295 305 2019
- Babu , A.R. , Prasad Rao , A. , and Hari Prasad , T. Experimental Investigation on a VCR CIDI Engine with Blends of Methyl Ester Palm Stearin-Diesel for Performance and Emissions International Journal of Ambient Energy 38 4 420 427 2015 https://doi.org/10.1080/1430750.2015.1132768
- Muralidharan , K. and Vasudevan , D. Performance, Emission and Combustion Characteristics of a Variable Compression Ratio Engine Using Methyl Esters of Waste Cooking Oil and Diesel Blends Applied Energy 88 11 3959 3968 2011
- Hariram , V. and Vagesh Shangar , R. Influence of Compression Ratio on Combustion and Performance Characteristics of Direct Injection Compression Ignition Engine Alexandria Engineering Journal 54 807 814 2015
- Nour , M. , Attia , A.M. , and Nada , S.A. Combustion, Performance and Emission Analysis of Diesel Engine Fuelled by Higher Alcohols (butanol, octanol and heptanol)/Diesel Blends Energy Conversion and Management 185 313 329 2019
- Hariram , V. and Bharathwaaj , R. Application of Zero-Dimensional Model for Predicting Combustion Parameters of CI Engine Fuelled with Biodiesel-Diesel Blends Alexandria Engineering Journal 55 3345 3354 2016
- Hasan , M.M. and Rahman , M.M. Performance and Emission Characteristics of Biodiesel-Diesel Blend and Environmental and Economic Impacts of Biodiesel Production: A Review Renewable and Sustainable Energy Reviews 74 938 948 2017
- Shaafi , T. , Sairam , K. , Gopinath , A. , Kumaresan , G. , and Velraj , R. Effect of Dispersion of Various Nanoadditives on the Performance and Emission Characteristics of a CI Engine Fuelled with Diesel, Biodiesel and Blends-A Review Renewable and Sustainable Energy Reviews 49 563 573 2015
- Hariram , V. , Seralathan , S. , Micha , P. , and Penchala , T. Reduction of Exhaust Emission Using a Nano-Metallic Enriched Lemongrass Biodiesel Blend Energy Sources, Part A: Recovery, Utilization and Environmental Effects 39 21 2065 2071 2017
- Krishnamoorthi , M. , Malayalamurthi , R. , and Sakthivel , R. Optimization of Compression Ignition Engine Fuelled with Diesel-Chaulmoogra Oil-Diethyl Ether Blend with Engine Parameters and Exhaust Gas Recirculation Renewable Energy 134 579 602 2019
- Selvaraj , K. and Thangavel , M. The Experimental Study on the Performance, Combustion and Emission Characteristics of a Diesel Engine Using Diesel-Biodiesel-Diethyl Ether Blends Energy Sources, Part A: Recovery, Utilization, and Environmental Effects 1 15 2019 https://doi.org/10.1080/15567036.2019.1623950
- Hariram , V. , Seralathan , S. , Dinesh Kumar , M. , Vasanthaseelan , S. , and Sabareesh , M. Analyzing the Fatty Methyl Ester Profile of Palm Kernel Biodiesel Using GC/MS, NMR and FTIR Techniques Journal of Chemical and Pharmaceutical Sciences 9 4 3122 3128 2016