This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
The Effects of Intake Pressure on In-Cylinder Gas Velocities in an Optically Accessible Single-Cylinder Research Engine
Technical Paper
2020-01-0792
ISSN: 0148-7191, e-ISSN: 2688-3627
This content contains downloadable datasets
Annotation ability available
Sector:
Language:
English
Abstract
Particle image velocimetry measurements of the in-cylinder flow in an optically accessible single-cylinder research engine were taken to better understand the effects of intake pressure variations on the flow field. At a speed of 1500 rpm, the engine was run at six different intake pressure loads from 0.4 to 0.95 bar under motored operation. The average velocity fields show that the tumble center position is located closer to the piston and velocity magnitudes decrease with increasing pressure load. A closer investigation of the intake flow near the valves reveals sharp temporal gradients and differences in maximum and minimum velocity with varying intake pressure load which are attributed to intake pressure oscillations. Despite measures to eliminate acoustic oscillations in the intake system, high-frequency pressure oscillations are shown to be caused by the backflow of air from the exhaust to the intake pipe when the valves open, exciting acoustic modes in the fluid volume. This phenomenon is much stronger in the throttled-load cases because of the high differential between exhaust and intake gases. In addition, 1-D simulations of the engine at varying intake pressures and pipe geometries provide insight into the interactions between the pressure variations, high-frequency oscillations, and intake flow.
Authors
Topic
Citation
Welch, C., Schmidt, M., Keskinen, K., Giannakopoulos, G. et al., "The Effects of Intake Pressure on In-Cylinder Gas Velocities in an Optically Accessible Single-Cylinder Research Engine," SAE Technical Paper 2020-01-0792, 2020, https://doi.org/10.4271/2020-01-0792.Data Sets - Support Documents
Title | Description | Download |
---|---|---|
Unnamed Dataset 1 | ||
Unnamed Dataset 2 |
Also In
References
- Borée , J. and Miles , P.C. In-Cylinder Flow Encyclopedia of Automotive Engineering Chichester John Wiley & Sons, Ltd 2014 1 31 9781118354179
- Geschwindner , C. , Kranz , P. , Welch , C. , Schmidt , M. et al. Analysis of the Interaction of Spray G and in-Cylinder Flow in Two Optical Engines for Late Gasoline Direct Injection Int. J. Engine Res. 2019 10.1177/1468087419881535
- Stiehl , R. , Schorr , J. , Krüger , C. , Dreizler , A. et al. In-Cylinder Flow and Fuel Spray Interactions in a Stratified Spray-Guided Gasoline Engine Investigated by High-Speed Laser Imaging Techniques Flow Turbul. Combust. 91 3 431 450 2013 10.1007/s10494-013-9500-x
- Zhang , M. , Xu , M. , and Hung , D.L.S. Simultaneous Two-Phase Flow Measurement of Spray Mixing Process by Means of High-Speed Two-Color PIV Meas. Sci. Technol. 25 9 95204 2014 10.1088/0957-0233/25/9/095204
- Dahms , R. , Fansler , T.D. , Drake , M.C. , Kuo , T.-W. et al. Modeling Ignition Phenomena in Spray-Guided Spark-Ignited Engines Proc. Combust. Inst. 32 2 2743 2750 2009 10.1016/j.proci.2008.05.052
- Peterson , B. and Sick , V. High-Speed Flow and Fuel Imaging Study of Available Spark Energy in a Spray-Guided Direct-Injection Engine and Implications on Misfires Int. J. Engine Res. 11 5 313 329 2010 10.1243/14680874JER587
- Mounaïm-Rousselle , C. , Landry , L. , Halter , F. , and Foucher , F. Experimental Characteristics of Turbulent Premixed Flame in a Boosted Spark-Ignition Engine Proc. Combust. Inst. 34 2 2941 2949 2013 10.1016/j.proci.2012.09.008
- Peterson , B. , Baum , E. , Böhm , B. , and Dreizler , A. Early Flame Propagation in a Spark-Ignition Engine Measured with Quasi 4D-Diagnostics Proc. Combust. Inst. 35 3 3829 3837 2015 10.1016/j.proci.2014.05.131
- Bode , J. , Schorr , J. , Krüger , C. , Dreizler , A. et al. Influence of the In-Cylinder Flow on Cycle-to-Cycle Variations in Lean Combustion DISI Engines Measured by High-Speed Scanning-PIV Proc. Combust. Inst. 37 4 4929 4936 2019 10.1016/j.proci.2018.07.021
- Freudenhammer , D. , Peterson , B. , Ding , C.-P. , Boehm , B. et al. The Influence of Cylinder Head Geometry Variations on the Volumetric Intake Flow Captured by Magnetic Resonance Velocimetry SAE Int. J. Engines 8 4 1826 1836 2015 10.4271/2015-01-1697
- Stiehl , R. , Bode , J. , Schorr , J. , Krüger , C. et al. Influence of Intake Geometry Variations on In-Cylinder Flow and Flow-Spray Interactions in a Stratified Direct-Injection Spark-Ignition Engine Captured by Time-Resolved Particle Image Velocimetry Int. J. Engine Res. 17 9 983 997 2016 10.1177/1468087416633541
- Winterbone , D.E. and Pearson , R.J. Design Techniques for Engine Manifolds: Wave Action Methods for IC Engines Desmond , E.W. and Richard , J.P. London Professional Engineering Pub 1999 186058179X
- Harrison , M.F. and Stanev , P.T. A Linear Acoustic Model for Intake Wave Dynamics in IC Engines J. Sound Vib. 269 1-2 361 387 2004 10.1016/S0022-460X(03)00196-2
- Margary , R. , Nino , E. , and Vafidis , C. The Effect of Intake Duct Length on the in-Cylinder Air Motion in a Motored Diesel Engine SAE Technical Paper 900057 1990 10.4271/900057
- Justham , T. , Jarvis , S. , Garner , C.P. , Hargrave , G.K. et al. Single Cylinder Motored SI IC Engine Intake Runner Flow Measurement Using Time Resolved Digital Particle Image Velocimetry SAE Technical Paper 2006-01-1043 2006 10.4271/2006-01-1043
- Lee , J. and Farrell , P.V. Intake Valve Flow Measurements of an IC Engine Using Particle Image Velocimetry SAE Technical Paper 930480 1993 10.4271/930480
- Renaud , A. , Ding , C.-P. , Jakirlic , S. , Dreizler , A. et al. Experimental Characterization of the Velocity Boundary Layer in a Motored IC Engine Int. J. Heat Fluid Fl. 71 366 377 2018 10.1016/j.ijheatfluidflow.2018.04.014
- Baum , E. , Peterson , B. , Böhm , B. , and Dreizler , A. On the Validation of LES Applied to Internal Combustion Engine Flows: Part 1: Comprehensive Experimental Database Flow Turbul. Combust. 92 1-2 269 297 2014 10.1007/s10494-013-9468-6
- Buhl , S. , Hain , D. , Hartmann , F. , and Hasse , C. A Comparative Study of Intake and Exhaust Port Modeling Strategies for Scale-Resolving Engine Simulations Int. J. Engine Res. 19 3 282 292 2018 10.1177/1468087417707452
- Laperre , J. and Thys , W. About Standing Waves in an Air Column: Transient Regime and Transfer Function Eur. J. Phys. 13 5 236 244 1992 10.1088/0143-0807/13/5/007
- Engelman , H.W. 1973
- Graftieaux , L. , Michard , M. , and Grosjean , N. Combining PIV, POD and Vortex Identification Algorithms for the Study of Unsteady Turbulent Swirling Flows Meas. Sci. Technol. 12 9 1422 1429 2001 10.1088/0957-0233/12/9/307