This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Optical Investigation of Mixture Formation in a Small Bore DISI Engine by Laser Induced Exciplex Fluorescence (LIEF)
Technical Paper
2019-24-0133
ISSN: 0148-7191, e-ISSN: 2688-3627
This content contains downloadable datasets
Annotation ability available
Sector:
Language:
English
Abstract
Legislative and customer demands in terms of fuel consumption and emissions are an enormous challenge for the development of modern combustion engines. Downsizing in combination with turbocharging and direct injection is one way to increase efficiency and therefore meet the requirements. This results in a reduction of the displacement and thus the bore diameter. The emerging trends towards long-stroke engine design and hybridization make the use of small bore diameters in future gasoline engines a realistic scenario. The application of direct injection with small cylinder dimensions increases the probability of the interaction of liquid fuel with the cylinder walls, which may result in disadvantages concerning especially particulate emissions. This leads to the question which bore diameter is feasible without drawbacks concerning emissions as a result of wall wetting. In the previous project “GDI Boundary Bore” the feasibility of an SI engine with direct injection and small bore diameter (60 mm) was shown by the analysis of two different cylinder head concepts (3V and 4V). For the acquirement of deeper understanding of the mixture formation in such engines the laser induced exciplex fluorescence (LIEF) was applied on a transparent engine in a follow up project for the simultaneous visualization of the vapor and liquid phase. The optical investigation on the transparent single cylinder engine included various operating points with variation of the start of injection. Within the scope of the investigations on the 3V concept, it was possible to determine why a charge movement flap increasingly loses its influence with early injection. The optical investigations on the 4V concept showed that a 7-hole injector with a lower penetration depth has disadvantages compared to a 6-hole injector. Furthermore, it was possible to determine why a charge movement flap can have a negative effect on mixture formation, contrary to common opinion.
Recommended Content
Topic
Citation
Pauls, A. and Eilts, P., "Optical Investigation of Mixture Formation in a Small Bore DISI Engine by Laser Induced Exciplex Fluorescence (LIEF)," SAE Technical Paper 2019-24-0133, 2019, https://doi.org/10.4271/2019-24-0133.Data Sets - Support Documents
| Title | Description | Download |
|---|---|---|
| Unnamed Dataset 1 | ||
| Unnamed Dataset 2 |
Also In
References
- Pauer , T. , Yilmaz , H. , Zumbrägel , J. , and Schünemann , E. Neue Generation Benzin-Direkteinspritzsysteme von Bosch MTZ - Motortechnische Zeitschrift 78 7-8 16 23 Jul. 2017
- Frenzel , H. , Achleitner , E. , Krüger , G. , Rösel , G. , and Wiench , R. Direkteinspritzsysteme für Ottomotoren zur Erfüllung der Real Driving Emission 10. Tagung Diesel- und Benzindirekteinspritzung 2016 Tschöke , H. and Marohn , R. Wiesbaden Springer Fachmedien Wiesbaden 2017 281 299
- Drossinos , Y. et al. Feasibility of Introducing Particulate Filters on Gasoline Direct Injection Vehicles a Cost Benefit Analysis Luxembourg Publications Office 2011
- Pischinger , S. , Mally , M. , Bergmann , D. , Thewes , M. , Seibel , J. , and Geiger , J. Gasoline Engines with Highest Efficiency - What Large and Small Bore Engines Can Learn from Each Other 16th Conference ‘The Working Process of the Internal Combustion Engine’ Graz 2017 23 34
- Nakata , K. , Nogawa , S. , Takahashi , D. , Yoshihara , Y. et al. Engine Technologies for Achieving 45% Thermal Efficiency of S.I. Engine SAE Int. J. Engines 9 1 179 192 Sep. 2015 10.4271/2015-01-1896
- Sens , M. et al. Selecting a Suitable Stroke / Bore Ratio When Combining Variable Compression and Early Intake Valve Closure (EIVC) Internationaler Motorenkongress 2017 Liebl , J. and Beidl C. Wiesbaden Springer Fachmedien Wiesbaden 2017 65 100
- Ikeya , K. , Takazawa , M. , Yamada , T. , Park , S. , and Tagishi , R. Thermal Efficiency Enhancement of a Gasoline Engine SAE Int. J. Engines 8 4 1579 1586 Apr. 2015
- Oh , S. et al. An Experimental Study on the Effect of Stroke-to-Bore Ratio of Atkinson DISI Engines with Variable Valve Timing presented at the WCX World Congress Experience 2018
- Sabathil , D. , Schaffner , P. , and Königstein , A. Efficient Application of Optical Measurements to Reduce the Particle Emission from Direct-Injection Gasoline Engines 10th International Symposium on Combustion Diagnostics Baden-Baden 2012 16
- Kufferath , A. , Berns , S. , Hammer , J. , Busch , R. , Frank , M. , and Storch , A. The EU6 Challange at GDI - Assessment of Feasible System Solutions 33rd International Vienna Motor Symposium Baden-Baden 2012
- Nauwerck , A. , Pfeil , J. , Velji , A. , Spicher , U. , and Richter , B. A Basic Experimental Study of Gasoline Direct Injection at Significantly High Injection Pressures SAE 2005 World Congress & Exhibition 2005
- Befrui , B. , Berndorfer , A. , Hoffmann , G. , Piock , W.F. et al. Enhanced Spray and Combustion Performance of GDi Multi-Hole Injectors by Increased Fuel System Pressure 11th International Symposium on Combustion Diagnostics Baden-Baden 2014 157 167
- Hoffmann , G. , Befrui , B. , Berndorfer , A. , Piock , W.F. , and Varble , D.L. Fuel System Pressure Increase for Enhanced Performance of GDi Multi-Hole Injection Systems SAE Int. J. Engines 7 1 519 527 Apr. 2014 10.4271/2014-01-1209
- Klauer N. , Klüting M. , Schünemann E. , Schwarz C. , and Steinprazer F. BMW TwinPower Turbo Gasoline Engine Technology - Enabling Compliance with Worldwide Exhaust Gas Emissions Requirements 34th International Vienna Motor Symposium Vienna 2013
- Notheis , D. , Bertsch , M. , Velji , A. , and Koch , T. Untersuchung der Partikelemissionen für unterschiedliche Einspritzstrategien an einem aufgeladenen Ottomotor mit Direkteinspritzung Tschöke , H. , Marohn , R. 10. Tagung Diesel- und Benzindirekteinspritzung 2016 Wiesbaden Springer Fachmedien Wiesbaden 2017 403 424
- Berndorfer , A. , Breuer , S. , Piock , W. , and Von Bacho , P. Diffusion Combustion Phenomena in GDi Engines Caused by Injection Process SAE 2013 World Congress & Exhibition 2013
- Schech , J. , Siedentop , A. , Herbst , F. , Wiebe , A. , and Eilts , P. Conceptual Design of Small Direct-Injection Spark-Ignition Engine Concepts with Various Injector Positions by Use of CAE-Tools 2012 Small Engine Technology Conference & Exhibition 2012
- Siedentop , A. , Schech , J. , Bradenstahl , A. , and Eilts , P. Thermodynamic, Optical and Numerical Investigation of a Small Direct Injection Spark Ignition Engine 24th Aachen Colloquium Automobile and Engine Technology 2014 Aachen 1219 1244
- Siedentop , A. , Schech , J. , Bradenstahl , A. , and Eilts , P. Potenziale kleinvolumiger direkteinspritzender Ottomotoren MTZ - Motortechnische Zeitschrift 77 9 74 83 Sep. 2016
- Gawlica , T. , Lippisch , M. , Samenfink , W. , Schünemann , E. , and Koch , T. Untersuchung zum Einfluss des Spray Targetings von Mehrloch-Injektoren für Benzin-Direkteinspritzung auf das Kennfeldverhalten von Spray und Brennverfahren Tschöke , H. , Marohn R. 10. Tagung Diesel- und Benzindirekteinspritzung 2016 Wiesbaden Springer Fachmedien Wiesbaden 2017 325 343
- Drake , M.C. , Fansler , T.D. , Solomon , A.S. , and Szekely , G.A. Piston Fuel Films as a Source of Smoke and Hydrocarbon Emissions from a Wall-Controlled Spark-Ignited Direct-Injection Engine SAE 2003 World Congress & Exhibition 2003
- Catapano , F. , Costa , M. , Marseglia , G. , Sementa , P. et al. An Experimental and Numerical Investigation of GDI Spray Impact over Walls at Different Temperatures SAE 2016 World Congress and Exhibition 2016
- Warey , A. , Huang , Y. , Matthews , R.D. , Hall , M. et al. Effects of Piston Wetting on Size and Mass of Particulate Matter Emissions in a DISI Engine SAE 2002 World Congress & Exhibition 2002
- Ortmann , R. , Arndt , S. , Raimann , J. , Grzeszik , R. et al. Methods and Analysis of Fuel Injection, Mixture Preparation and Charge Stratification in Different Direct Injected SI Engines SAE 2001 World Congress 2001
- Stevens , E. and Steeper , R. Piston Wetting in an Optical DISI Engine: Fuel Films, Pool Fires, and Soot Generation SAE 2001 World Congress 2001
- Sabathil , D. , Koenigstein , A. , Schaffner , P. , Fritzsche , J. et al. The Influence of DISI Engine Operating Parameters on Particle Number Emissions SAE 2011 World Congress & Exhibition 2011
- Peterson , K. , Grover , R. , and Mitcham , C. Application of Optical Diagnostics and Simulation to Fuel Injector Tip Wetting and Soot Production 11th International Symposium on Combustion Diagnostics Baden-Baden 2014 79 84
- Fischer , A. and Thelliez , M. Methodology and Tools to Predict GDI Injector Tip Wetting as Predecessor of Tip Sooting WCX World Congress Experience 2018
- Lehrheuer , B. , Hoppe , P. , Günther , M. , and Pischinger , S. CO2-Reduzierung durch kleinen Hubraum in Kombination mit Biokraftstoffen MTZ - Motortechnische Zeitschrift 75 11 66 73 Oct. 2014
- Jose , J. , Parsi , A. , Shridhara , S. , Mittal , M. et al. Effect of Fuel Injection Timing on the Mixture Preparation in a Small Gasoline Direct-Injection Engine SAE/JSAE Small Engine Technology Conference 2018
- Wieske , P. , Wissel , S. , Grunefeld , G. , Graf , M. , and Pischinger , S. Experimental Investigation of the Origin of Cyclic Fluctuations in a DISI Engine by Means of Advanced Laser Induced Exciplex Fluorescence Measurements Powertrain & Fluid Systems Conference and Exhibition 2006
- Zhang , G. , Xu , M. , Zhang , Y. , and Zeng , W. Quantitative Measurements of Liquid and Vapor Distributions in Flash Boiling Fuel Sprays Using Planar Laser Induced Exciplex Technique SAE International Powertrains, Fuels and Lubricants Meeting 2011
- Zhang , G. , Xu , M. , Zhang , Y. , Zhang , M. , and Cleary , D.J. Macroscopic Characterization of Flash-Boiling Multihole Sprays Using Planar Laser-Induced Exciplex Fluorescence. Part II: Cross-Sectional Spray Structure Atomization and Sprays 23 3 265 278 2013
- Zhang , G. , Xu , M. , Zhang , Y. , Zhang , M. , and Cleary , D.J. Macroscopic Characterization of Flash-Boiling Multi-Hole Sprays Using Planar Laser Induced Exciplex Fluorescence Technique. Part I: On-Axis Spray Structure Atomization and Sprays 22 10 861 878 2012
- Li , T. , Xu , M. , Wu , S. , Xu , Q. et al. Influence of the Injector Configuration on the Spray Evaporation Characteristics under Superheated Conditions JSAE/SAE 2015 International Powertrains, Fuels & Lubricants Meeting 2015
- Ghandhi , J.B. , Felton , P.G. , Gajdeczko , B.F. , and Bracco , F.V. Investigation of the Fuel Distribution in a Two-Stroke Engine with an Air-Assisted Injector International Congress & Exposition 1994
- Bosch , R. GmbH, ‘Spray Targeting Study 3V’ FVV-Project 1047 2012
- Bosch , R. GmbH, ‘Spray Targeting Study 4V’ FVV-Project 1047 2012
- Melton , L.A. Spectrally Separated Fluorescence Emissions for Diesel Fuel Droplets and Vapor Applied Optics 22 14 2224 Jul. 1983
- Alonso , M. , Bowen , P.J. , Kay , P.J. , Crayford , A.P. , Gilchrist , R. , and Sapsford , S. On the Quantitative Analysis of Vapor Fuel Fractions of Spark Ignition di Sprays by Use of LIEF 22nd European Conference on Liquid Atomization and Spray Systems Como 2008
- Andersson , M. , Hemdal , S. , and Ochoterena , R.L. Temperature Measurements Using Exciplex Fluorescence with TMPD and Methylnaphthalene as Tracers European Conference on Liquid Atomization and Spray Systems Como Lake, Italy 2008
- Desantes , J.M. , Pastor , J.V. , Pastor , J.M. , and Juliá , J.E. Limitations on the Use of the Planar Laser Induced Exciplex Fluorescence Technique in Diesel Sprays Fuel 84 18 2301 2315 Dec. 2005
- Düwel , I. , Koban , W. , Zimmermann , F.P. , Dreier , T. , and Schulz , C. Spectroscopic Characterization of the Fluorobenzene/DEMA Tracer System for Laser-Induced Exciplex Fluorescence for the Quantitative Study of Evaporating Fuel Sprays Applied Physics B 97 4 909 918 Dec. 2009
- Zhang , Y. , Zhang , G. , Xu , M. , and Wang , J. Droplet Temperature Measurement Based on 2-Color Laser-Induced Exciplex Fluorescence Exp Fluids 54 8 1583 Aug. 2013
- Spausta , F. 1953
- Schindler , V. 1997
- Wieske , P. Bildgebende Multiparameter-Lasermessungen in komplexen technischen Strömungs- und Verbrennungsprozessen Dissertation, Rheinisch-Westfälischen Technischen Hochschule Aachen, Aachen 2007
- Schech , J. , Siedentop , A. , Bradenstahl , A. , Wiebe , A. , and Eilts , P. 6th Working Group Meeting: “GDI Boundary Bore” Working Group Meeting, Braunschweig 26-Mar-2012
- AVL 2015
- Fansler , T.D. et al. Quantitative Liquid and Vapor Distribution Measurements in Evaporating Fuel Sprays Using Laser-Induced Exciplex Fluorescence Measurement Science and Technology 20 12 125401 Dec. 2009
- Reboux , J. , Puechberty , D. , and Dionnet , F. A New Approach of Planar Laser Induced Fluorescence Applied to Fuel/Air Ratio Measurement in the Compression Stroke of an Optical S.I. Engine International Fuels & Lubricants Meeting & Exposition 1994
- Schech , J. , Siedentop , A. , Bradenstahl , A. , Wiebe , A. , and Eilts , P. 7th Working Group Meeting: “GDI Boundary Bore” Working Group Meeting Braunschweig 26-Mar-2012