This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Experimental Investigation on the Influence of Brake Mean Effective Pressures up to 30 bar on the Behavior of a Large Bore Otto Gas Engine
Technical Paper
2019-01-2224
ISSN: 0148-7191, e-ISSN: 2688-3627
This content contains downloadable datasets
Annotation ability available
Sector:
Language:
English
Abstract
For large bore Otto gas engines a high specific power output and therefore high engine load promises a rise in engine efficiency on one hand and on the other hand a reduction of the performance-related investment. However, this can negatively affect the emissions performance, operating limits especially in regards to knocking, and component life. For this reason at the Chair of Internal Combustion Engines (LVK) of the Technical University of Munich (TUM) experiments with a 4.77 l single-cylinder research engine were carried out to investigate the boundary conditions, potentials and downsides of combustion processes with a brake mean effective pressure beyond current series engines and higher than 30 bar. The objective in this investigations was to achieve BMEP > 30 bar with an engine configuration that widely represents the current series-production status. Hence, an unscavenged prechamber spark plug, a series Piston and Valve timing were used. To shift the knocking limit to more fuel-efficient operating points, different intake air temperatures were used. The engine behavior was measured in engine maps with a variation of the air-fuel equivalence ratio λ at different loads. Therefore the shift of the knocking limit, the misfiring limit and further parameters were evaluated. Moreover, the characteristic of the combustion process is analyzed at distinctive points and lines for example alongside the TA Luft [1] NOx 500 mg/m3 line or at a constant center of combustion, for each, while varying the air-fuel equivalence ratio λ. In addition, a loss analysis showed the benefits of an increase in load and helps to characterize the high load combustion process.
Authors
Citation
Eicheldinger, S., Bartkowski, T., Schröder, A., Prager, D. et al., "Experimental Investigation on the Influence of Brake Mean Effective Pressures up to 30 bar on the Behavior of a Large Bore Otto Gas Engine," SAE Technical Paper 2019-01-2224, 2019, https://doi.org/10.4271/2019-01-2224.Data Sets - Support Documents
| Title | Description | Download |
|---|---|---|
| Unnamed Dataset 1 | ||
| Unnamed Dataset 2 | ||
| Unnamed Dataset 3 | ||
| Unnamed Dataset 4 | ||
| Unnamed Dataset 5 | ||
| Unnamed Dataset 6 | ||
| Unnamed Dataset 7 | ||
| Unnamed Dataset 8 | ||
| Unnamed Dataset 9 | ||
| Unnamed Dataset 10 | ||
| Unnamed Dataset 11 |
Also In
References
- 2002
- 2008 https://www.bveg.de/Erdgas/Rohstoffe/Reserven
- Uhlig , B. ; Wohlgemuth , S. 2012
- Basshuysen , R.v. ; Schäfer , F. 2017
- Merker , G.P. ; Schwarz , C. ; Teichmann , R. 2012
- Eicheldinger , S. ; Nguyen , H. ; Dohrmann , S. ; Kuppa , K. ; Wachtmeister , G. ; Prager , M. et al 2018
- Schröder , A. ; Schedlbauer , T. ; Wachtmeister , G. ; Prager , M. ; Deutschmann , O. ; Grunwaldt , J.-D. et al. 2017
- Wülfert , K. ; Schlatter , S. ; Wright , Y.M. 2013
- Peer , J. ; Korb , B. ; Schlatter , S. 2013
- Korb , Benjamin 2015
- Weber , S. ; Stegmann , R. ; Prager , M. ; Wachtmeister , G. The Effect of Inlet Valve Timing and Engine Speed on Dual Fuel NG-Diesel Combustion in a Large Bore Engine SAE Int. J. Engines 2018 11 2 229 46 10.4271/03-11-02-0015
- Korb , B. ; Kawauchi , S. ; Wachtmeister , G. Influence of hydrogen addition on the operating range, emissions and efficiency in lean burn natural gas engines at high specific loads Fuel 2016 164 410 8 10.1016/j.fuel.2015.09.080
- Nguyen-Schäfer , H. Rotordynamics of Automotive Turbochargers Berlin Springer 2015
- Golloch , R. Downsizing bei Verbrennungsmotoren: Ein wirkungsvolles Konzept zur Kraftstoffverbrauchssenkung Berlin Springer 2005
- Baehr , H.D. and Kabelac , S. Thermodynamik: Grundlagen und technische Anwendungen. 13., neu bearb. und erw. Aufl Berlin Springer 2006
- Auer , M. 2010
- Witt , M. ; Griebel , P. 2000
- Lämmle , C. 2005
- Liao , S.Y. ; Jiang , D.M. ; Cheng , Q. Determination of laminar burning velocities for natural gas Fuel - The Science and Technology of Fuel and Energy 2004 83 10.1016/j.fuel.2003.12.001
- Panzani , G. ; Östman , F. ; Onder , C. Engine knock margin estimation using in-cylinder pressure measurements IEEE/ASME Transactions on Mechatronics 301 11
- Zhen , X. ; Wang , Y. ; Xu , S. ; Zhu , Y. ; Tao , C. ; Xu , T. et al.
- Heywood , J.B. Internal combustion engine fundamentals Columbus McGraw - Hill Book Company 1988
- Gamma Technologies 2016