This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Quasi-Dimensional Simulation of Downsizing and Inverter Application for Efficient Part Load Operation of Spark Ignition Engine Driven Micro-Cogeneration Systems
Technical Paper
2018-32-0061
ISSN: 0148-7191, e-ISSN: 2688-3627
This content contains downloadable datasets
Annotation ability available
Sector:
Language:
English
Abstract
Within the context of distributed power generation, small size systems driven by spark ignition engines represent a valid and user-friendly choice, that ensures good fuel flexibility. One issue is that such applications are run at part load for extensive periods, thus lowering fuel economy. Employing an inverter (fitted between the generator and load) allows engine operation within a wide range of crankshaft rotational velocity, therefore improving efficiency. For the purpose of evaluating the benefits of this technology within a co-generation framework, two configurations were modeled by using the GT-Power simulation software. After model calibration based on measurements on a small size engine for two-wheel applications, the downsized version was compared to a larger power unit operated at constant engine speed for a scenario that featured up to 10 kW rated power. Indeed, the downsizing concept was found to ensure an electrical efficiency improvement of around 10% at 50% load, over 30% at 20% load, and reduced fuel consumption by over 50% at lower load. The co-generation potential was also evaluated, and it resulted practically the same from full to 50% load, while at low load the larger engine featured heat recovery potential up to two times larger compared to the smaller unit.
Authors
Topic
Citation
Irimescu, A., Catapano, F., Di Iorio, S., Merola, S. et al., "Quasi-Dimensional Simulation of Downsizing and Inverter Application for Efficient Part Load Operation of Spark Ignition Engine Driven Micro-Cogeneration Systems," SAE Technical Paper 2018-32-0061, 2018, https://doi.org/10.4271/2018-32-0061.Data Sets - Support Documents
Title | Description | Download |
---|---|---|
Unnamed Dataset 1 |
Also In
References
- Cen , Z. , Kubiak , P. , López , C.M. , and Belharouak , I. Demonstration Study of Hybrid Solar Power Generation/Storage Micro-Grid System under Qatar Climate Conditions Solar Energ. Mat. Solar Cells 180 280 288 2018 10.1016/j.solmat.2017.06.053
- Giostri , A. Preliminary Analysis of Solarized Micro Gas Turbine Application to CSP Parabolic Dish Plants Energ. Proc. 142 768 773 2017 10.1016/j.egypro.2017.12.124
- Ishaq , H. , Dincer , I. , and Naterer , G.F. Performance Investigation of an Integrated Wind Energy System for Co-Generation of Power and Hydrogen Int. J. Hydrogen Energ. 43 19 9153 9164 10.1016/j.ijhydene.2018.03.139
- Pesaran , M.H.A. , Huy , P.D. , and Ramachandaramurthy , V.K. A Review of the Optimal Allocation of Distributed Generation: Objectives, Constraints, Methods, and Algorithms Renew. Sust. Energ. Rev. 75 293 312 2017 10.1016/j.rser.2016.10.071
- Irimescu , A. , Vasiu , G. , and Tordai , G.T. Performance and Emissions of a Small Scale Generator Powered by a Spark Ignition Engine with Adaptive Fuel Injection Control Appl. Energ. 121 196 206 2014 10.1016/j.apenergy.2014.01.078
- Kim , Y. , Kawahara , N. , Tsuboi , K. , and Tomita , E. Combustion Characteristics and NOX Emissions of Biogas Fuels with Various CO2 contents in a Micro CO-Generation Spark-Ignition Engine Appl. Energ. 182 539 547 2016 10.1016/j.apenergy.2016.08.152
- Sáinz , D. , Diéguez , P.M. , Urroz , J.C. , Sopena , C. et al. Conversion of a Gasoline Engine-Generator Set to a Bi-Fuel (Hydrogen/Gasoline) Electronic Fuel-Injected Power Unit Int. J. Hydrogen Energ. 36 13781 13792 2011 10.1016/j.ijhydene.2011.07.114
- Diéguez , P.M. , Urroz , J.C. , Marcelino-Sádaba , S. , Pérez-Ezcurdia , A. et al. Experimental Study of the Performance and Emission Characteristics of an Adapted Commercial Four-Cylinder Spark Ignition Engine Running on Hydrogen-Methane Mixtures Appl. Energ. 113 1068 1076 2014 10.1016/j.apenergy.2013.08.063
- Isa , N.M. , Tan , C.W. , and Yatim , A.H.M. A Comprehensive Review of Cogeneration System in a Microgrid: A Perspective from Architecture and Operating System Renew. Sust. Energ. Rev. 81 2236 2263 2018 10.1016/j.rser.2017.06.034
- Mura , F. , de Doncker , R.W. , Persigehl , B. , Jeschke , P. , et al. 39 44 2011
- Li , D. Dougal , R.A. , Thirunavukarasu , E. and Ouroua , A. Variable Speed Operation of Turbogenerators to Improve Part-Load Efficiency Electric Ship Technologies Symposium (ESTS), 2013 IEEE 2013 Arlington, VA 10.1109/ESTS.2013.6523760
- Caresana , F. , Brandoni , C. , Feliciotti , P. , and Bartolini , C.M. Energy and Economic Analysis of an ICE-Based Variable Speed-Operated Micro-Cogenerator Appl. Energ. 88 3 659 671 2011 10.1016/j.apenergy.2010.08.016
- Zhu , S. , Yu , G. , O , J. , Xu , T. et al. Modeling and Experimental Investigation of a Free-Piston Stirling Engine-Based Micro-Combined Heat and Power System Appl. Energ. 226 522 533 2018 10.1016/j.apenergy.2018.05.122
- Dong , G. , Morgan , R. , and Heikal , M. A Novel Split Cycle Internal Combustion Engine with Integral Waste Heat Recovery Appl. Energ. 157 744 753 2015 10.1016/j.apenergy.2015.02.024
- Tibola , J.R. , Metzka Lanzanova , T.D. , Santos Martins , M.E. , Abílio Gründling , H. et al. Modeling and Speed Control Design of an Ethanol Engine for Variable Speed Gensets Control Eng. Practice 35 54 66 2015 10.1016/j.conengprac.2014.11.002
- Iwanski , G. , Bigorajski , Ł. , and Koczara , W. Speed Control with Incremental Algorithm of Minimum Fuel Consumption Tracking for Variable Speed Diesel Generator Energ. Conver. Manage. 161 182 192 2018 10.1016/j.enconman.2018.01.053
- Bouilly , J. , Lafossas , F. , Mohammadi , A. , and Van Wissen , R. Evaluation of Fuel Economy Potential of an Active Grille Shutter by the Means of Model Based Development Including Vehicle Heat Management SAE Int. J. Engines 8 5 2394 2401 2015 10.4271/2015-24-2536
- Zschutschke , A. , Neumann , J. , Linse , D. , and Hasse , C. A Systematic Study on the Applicability and Limits of Detailed Chemistry Based NOx Models for Simulations of the Entire Engine Operating Map of Spark-Ignition Engines Appl. Therm. Eng. 98 910 923 2016 10.1016/j.applthermaleng.2015.12.093
- Wang , S. , Prucka , R. , Zhu , Q. , Prucka , M. et al. A Real-Time Model for Spark Ignition Engine Combustion Phasing Prediction SAE Int. J. Engines 9 2 1180 1190 2016 10.4271/2016-01-0819
- Kosmadakis , G.M. , Rakopoulos , D.C. , and Rakopoulos , C.D. Methane/Hydrogen Fueling a Spark-Ignition Engine for Studying NO, CO and HC Emissions with a Research CFD Code Fuel 185 903 915 2016 10.1016/j.fuel.2016.08.040
- Sforza , L. , Lucchini , T. , Onorati , A. , Zhu , X. et al. Modeling Ignition and Premixed Combustion Including Flame Stretch Effects SAE Technical Paper 2017-01-0553 2017 10.4271/2017-01-0553
- Millo , F. , Luisi , S. , Borean , F. , and Stroppiana , A. Numerical and Experimental Investigation on Combustion Characteristics of a Spark Ignition Engine with an Early Intake Valve Closing Load Control Fuel 121 298 310 2014 10.1016/j.fuel.2013.12.047
- Bozza , F. , De Bellis , V. , Berni , F. , D'Adamo , A. et al. Refinement of a 0D Turbulence Model to Predict Tumble and Turbulent Intensity in SI Engines. Part I: 3D Analyses SAE Technical Paper 2018-01-0850 2018 10.4271/2018-01-0850
- Bozza , F. , Teodosio , L. , De Bellis , V. , Fontanesi , S. et al. Refinement of a 0D Turbulence Model to Predict Tumble and Turbulent Intensity in SI Engines. Part II: Model Concept, Validation and Discussion SAE Technical Paper 2018-01-0856 2018 10.4271/2018-01-0856
- Sjerić , M. , Kozarac , D. , Schuemie , H. , and Tatschl , R. A New Quasi-Dimensional Flame Tracking Combustion Model for Sparkignition Engines Energ. Convers. Manage. 165 263 275 2018 10.1016/j.enconman.2018.03.008
- Sjerić , M. , Kozarac , D. , and Tatschl , R. Modelling of Early Flame Kernel Growth towards a Better Understanding of Cyclic Combustion Variability in SI Engines Energ. Convers. Manage. 103 895 909 2015 10.1016/j.enconman.2015.07.031
- Heywood , J.B. Internal Combustion Engine Fundamentals New York McGraw Hill 1988
- Gamma Technologies 2013
- Irimescu , A. , Di Iorio , S. , Merola , S.S. , Sementa , P. et al. Evaluation of Compression Ratio and Blow-by Rates for Spark Ignition Engines Based on in-Cylinder Pressure Trace Analysis Energ. Convers. Manage. 162 98 108 2018 10.1016/j.enconman.2018.02.014
- Irimescu , A. , Catapano , F. , Di Iorio , S. , and Sementa , P. Influence of Combustion Efficiency on the Operation of Spark Ignition Engines Fueled with Methane and Hydrogen Investigated in a Quasi-Dimensional Simulation Framework SAE Technical Paper 2018-37-0012 2018 10.4271/2018-37-0012
- Irimescu , A. , Merola , S.S. , Tornatore , C. , and Valentino , G. Development of a Semi-Empirical Convective Heat Transfer Correlation Based on Thermodynamic and Optical Measurements in a Spark Ignition Engine Appl. Energ. 157 777 788 2015 10.1016/j.apenergy.2015.02.050
- Morel , T. and Keribar , R. A Model for Predicting Spatially and Time Resolved Convective Heat Transfer in Bowl-In-Piston Combustion Chambers SAE Technical Paper 850204 1985 10.4271/850204
- Baratta , M. , Misul , D. , Xu , J. , Fuerhapter , A. et al. Development of a High Performance Natural Gas Engine with Direct Gas Injection and Variable Valve Actuation SAE Int. J. Engines 10 5 2535 2551 2017 10.4271/2017-24-0152
- Kaldellis , J.K. An Integrated Model for Performance Simulation of Hybrid Wind-Diesel Systems Renew. Energ. 32 1544 1564 2007 10.1016/j.renene.2006.07.004
- honda.com 2018