This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Experimental Study of Spark-Assisted Auto-Ignition Gasoline Engine with Octagonal Colliding Pulsed Supermulti-Jets and Asymmetric Double Piston Unit
Technical Paper
2018-32-0004
ISSN: 0148-7191, e-ISSN: 2688-3627
This content contains downloadable datasets
Annotation ability available
Sector:
Language:
English
Abstract
Much effort has been devoted to studies on auto-ignition engines of gasoline including homogeneous-charge combustion ignition engines over 30 years, which will lead to lower exhaust energy loss due to high-compression ratio and less dissipation loss due to throttle-less device. However, the big problem underlying gasoline auto-ignition is knocking phenomenon leading to strong noise and vibration. In order to overcome this problem, we propose the principle of colliding pulsed supermulti-jets. In a prototype engine developed by us, octagonal pulsed supermulti-jets collide and compress the air around the center point of combustion chamber, which leads to a hot spot area far from chamber walls. After generating the hot spot area, the mechanical compression of an asymmetric double piston unit is added in four-stroke operation, which brings auto-ignition of gasoline. In our previous report (SAE paper 2016-01-2336) using gasoline, there were only some engine cycles indicating high thermal efficiency comparable to that of diesel engines. In the present report, we show that spark-assisted auto-ignition combustion optimized with the hot spot area generated by octagonal pulsed supermulti-jets indicates potential of high thermal efficiency averaged during many cycles, which is about the same level of diesel engines. Mechanical compression ratio is about from 7.8:1 to 11:1 and engine speed is 2,000 rpm under the part load whose exhaust air-fuel ratio is about from 20 to 30. Moreover, experimental data obtained also show the increasing rate of pressure after combustion is less than the knocking limit of reciprocating engines. And we have made a new prototype engine whose asymmetric double piston unit moves non-sinusoidally. We intend to report progress of this new prototype engine.
Recommended Content
Authors
- Yuuki Isshiki - Waseda University
- Ken Naitoh - Waseda University
- Yuichi Onuma - Waseda University
- Soichi Ohara - Waseda University
- Daisuke Arai - Waseda University
- Yutaka Machida - Waseda University
- Hajime Ito - Waseda University
- Yoshiki Kobayashi - Waseda University
- Takahiro Suzuki - Waseda University
- Yusuke Tada - Waseda University
Topic
Citation
Isshiki, Y., Naitoh, K., Onuma, Y., Ohara, S. et al., "Experimental Study of Spark-Assisted Auto-Ignition Gasoline Engine with Octagonal Colliding Pulsed Supermulti-Jets and Asymmetric Double Piston Unit," SAE Technical Paper 2018-32-0004, 2018, https://doi.org/10.4271/2018-32-0004.Data Sets - Support Documents
Title | Description | Download |
---|---|---|
Unnamed Dataset 1 | ||
Unnamed Dataset 2 | ||
Unnamed Dataset 3 | ||
Unnamed Dataset 4 | ||
Unnamed Dataset 5 | ||
Unnamed Dataset 6 | ||
Unnamed Dataset 7 | ||
Unnamed Dataset 8 | ||
Unnamed Dataset 9 | ||
Unnamed Dataset 10 | ||
Unnamed Dataset 11 |
Also In
References
- Nakajima , Y. , Muranaka , S. , Kamegaya , S. , Kanetoshi , K. , et al. Automobile Gasoline Engines Tokyo Sankaido 1999
- HONDA http://www.honda.co.jp/news/1996/296102.html 2018
- Kawaguchi , A. , Iguma , H. , Yamashita , H. , Takada , N. et al. Thermo-Swing Wall Insulation Technology; − A Novel Heat Loss Reduction Approach on Engine Combustion Chamber SAE Technical Paper 2016-01-2333 2016 10.4271/2016-01-2333
- Naitoh , K. 2012
- Naitoh , K. A New Cascade-Less Engine Operated from Subsonic to Hypersonic Conditions Journal of Thermal Science 19 6 481 485 2010
- Naitoh , K. , Shimizu , D. , Nonaka , S. , Kainuma , Y. et al. The Fifth Compression Strategy for Hypersonic Aircar AIAA Paper 2012-3314 2012
- Naitoh , K. , Shimizu , D. , and Nonaka , S. Stability Limit of Supermulti-Jets Convergence Engine Operated from Startup to Extremely-Hypersonic Conditions: Revealed by Shock-Tube Experiments AIAA Paper 2012-5923 2012
- Naitoh , K. , Emoto , T. , Nakamura , K. , and Kainuma , Y. An Ultimate Engine: Designed by Computational Fluid Dynamics SAE Technical Paper 2011-01-2027 2011 10.4271/2011-01-2027
- Naitoh , K. , Marui , M. , Ishida , K. , Sagara , Y. et al. Simultaneous Attainment of Light-Weight, High Efficiency, and Low Noise: By Supermultijets-Twister Engine Working from Startup to Hypersonic Scram Mode AIAA Paper 2013-3011 2013
- Hashimoto , T. , Naitoh , K. , Tanaka , M. , Nojima , Y. et al. Strongly-Asymmetric Double Piston Engine: Assisted by Super Multi-Jets Colliding JSAE Paper 81-20135740 2013
- Tamura , T. , Naitoh , K. , Nonaka , S. , Sagara , K. , et al. Fundamental Combustion Test Based on Supermulti-Jets Colliding 24th Nainen-Kikan Symposium Kobe, Japan Nov. 26-28, 2013
- Tanaka , M. , Naitoh , K. , Nojima , Y. , Kubota , T. , et al. Strongly-Asymmetric Double Piston Engine: Assisted by Super Multi-Jets Colliding 24th Nainen-Kikan Symposium Kobe, Japan Nov. 26-28, 2013
- Naitoh , K. , Ishida , K. , Nonaka , S. , Kubota , T. et al. Fugine: The Supermultijet-Convergence Engine Working from Startup to Hypersonic Scram Mode and Attaining Simultaneously Light-Weight, High-Efficiency, and Low Noise AIAA Paper 2014-3960 2014
- Naitoh , K. , Okamoto , T. , Kubota , T. , Yamagishi , K. et al. Design Guidelines of the Single-Point Auto-Ignition Engine Based on Supermulti-Jets Colliding for High Thermal Efficiency and Low Noise: Obtained by Computational Experiments for a Small Strongly-Asymmetric Double-Piston Engine SAE Technical Paper 2014-32-0100 2014 10.4271/2014-32-0100
- Naitoh , K. , Yamagishi , K. , Nonaka , S. , Okamoto , T. et al. Unsteady Three-Dimensional Computational Experiments of the Single-Point Auto-Ignition Engine Based on Semispherical Supermulti-Jets Colliding with Pulse for Automobiles SAE Technical Paper 2014-01-2641 2014 10.4271/2014-01-2641
- Naitoh , K. , Kojima , K. , Okamoto , T. , Yamagishi , K. et al. Physical Theory of the Single-Point Auto-Ignition Engine Based on Supermulti-Jets Colliding with Pulse: Leading to Thermal Efficiency over 60% at Various Engine Speeds and Loads of Automobiles SAE Technical Paper 2014-01-2640 2014 10.4271/2014-01-2640
- Naitoh , K. , Tanaka , Y. , Tamura , T. , Okamoto , T. et al. Fugine Cycle Theory: Predicting High Efficiency of the Supermultijet-Convergence Engine Working from Startup to Hypersonic Scram Mode AIAA Paper 2015-2968 2015
- Naitoh , K. , Hasegawa , K. , Kubota , T. , Hashimoto , T. et al. Development of Fugine Based on Supermulti-Jets Colliding with Pulse: Leading to Stable Plug-Less Start and Improvement of HCCI with Satisfactory Strength of Structure SAE Technical Paper 2014-01-2639 2014 10.4271/2014-01-2639
- Naitoh , K. , Ikoma , D. , Sagara , H. , Tamura , Y. et al. Two Small Prototype Engines Developed Based on Pulsed Supermulti-Jets Colliding: Having a Potential of Thermal Efficiency over 60% with Satisfactory Strength of Structure SAE Technical Paper 2014-32-0099 2014 10.4271/2014-32-0099
- Naitoh , K. , Shirai , T. , Tanaka , M. , Nojima , Y. et al. Fugine as Single-Point Compression Engine Based on Supermulti-Jets Colliding with Strongly-Asymmetric Double-Piston System SAE Technical Paper 2015-01-1964 2015 10.4271/2015-01-1964
- Naitoh , K. , Tsuchiya , J. , Ikoma , D. , Nakai , T. et al. Computations and Experiments for Clarifying Compression Level and Stability of Colliding Pulsed Supermulti-Jets in a Piston-Less Single-Point Auto-Ignition Engine SAE Technical Paper 2016-01-2331 2016 10.4271/2016-01-2331
- Naitoh , K. , Ayukawa , K. , Ikoma , D. , Nakai , T. et al. Fundamental Combustion Experiments of a Piston-less Single-Point Auto-Ignition Gasoline Engine Based on Compression Due to Colliding of Pulsed Supermulti-Jets SAE Technical Paper 2016-01-2337 2016 10.4271/2016-01-2337
- Naitoh , K. , Ohara , S. , Onuma , Y. , Shirai , T. , et al. 2016
- Naitoh , K. , Ohara , S. , Onuma , Y. , Kojima , K. et al. High Thermal Efficiency Obtained with a Single-Point Autoignition Gasoline Engine Prototype Having Pulsed Supermulti-Jets Colliding in an Asymmetric Double Piston Unit SAE Technical Paper 2016-01-2336 2016 10.4271/2016-01-2336
- Yamagishi , K. , Onuma , Y. , Ohara , S. , Hasegawa , K. et al. Computations and Experiments of Single-Point Autoignition Gasoline Engine with Colliding Pulsed Supermulti-Jets, Single Piston and Rotary Valve SAE Technical Paper 2016-01-2334 2016 10.4271/2016-01-2334
- Machida , Y. , Naitoh , K. , Arai , D. , Ohara , S. , et al. Combustion Experiments of Engine with Colliding Pulsed Supermulti-Jets with Double-Piston: Fugine AROB Workshop Busan, Korea Sep. 7-9, 2017
- Landau , E.D. and Lifshitz , E.M. Fluid Mechanics Second Oxford Butterworth-Heinemann Elsevier 2004
- Konagaya , R. , Kobayashi , T. , Naitoh , K. , Tanaka , Y. et al. Unsteady Three-Dimensional Computations and Shock Tube Experiments of the Compression Principle of Supermulti-Jets Colliding with Pulse AIAA Paper 2018-4630 2018
- Olesky , L.M. , Martz , J.B. , Lavoie , G.A. , Vavra , J. et al. The Effect of Spark Timing, Unburned Gas Temperature, and Negative Valve Overlap on the Rate of Stoichiometric Spark Assisted Compression Ignition Combustion Applied Energy 105 407 417 2013 10.1016/j.apenergy.2013.01.038
- Yoshizawa , K. , Teraji , A. , Aochi , E. , Kubo , M. et al. Numerical Analysis of Combustion in Gasoline Compression Ignition Engines SAE Technical Paper 2002-01-2865 2002 10.4271/2002-01-2865
- Ito , H. , Naitoh , K. , Arai , D. , Machida , Y. , et al. Fundamental Experiment of Engine with Octagonal Colliding Pulsed Supermulti-Jets and Double Piston Unit for Very High Thermal Efficiency International Symposium on Fuel and Energy 2018 Higashi Hiroshima, Japan July 2-4, 2018
- Inaba , K. Knowledge of Supercharger Tokyo Seizando 1968
- Çeper , B.A. , Yıldız , M. , Orhan Akansu , S. , and Kahraman , N. Performance and Emission Characteristics of an IC Engine under SI, SI-CAI and CAI Combustion Modes Energy 136 72 79 2017 10.1016/j.energy.2016.08.038