This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Portable Emissions Measurement System for Solid Particle Number Including Nanoparticles Smaller than 23 nm
Technical Paper
2017-01-2402
ISSN: 0148-7191, e-ISSN: 2688-3627
This content contains downloadable datasets
Annotation ability available
Sector:
Language:
English
Abstract
Fine particle emissions from engine exhaust have attracted attention because of concern of their higher deposition fraction in alveoli. Since it was observed that sizes of solid particles in exhaust of conventional internal combustion engine technologies are mainly distributed above 30 nm and the mainly irreproducible sensitivity to volatile particles can be reduced, the current solid particle number (PN) measurement methodology was targeted to PN emissions particles larger than 23 nm. The necessity of the measurement of particles smaller than 23 nm is now under discussion. It is also surmised that there is difference between emissions under regulatory defined test cycles and real driving conditions. Currently, implementation of further real driving emission regulations utilizing portable emissions measurement systems (PEMS) is in place for the EU and being actively discussed in other regions. In this study, a commercially available PEMS for PN was modified to extend the detection limit to particles below 23 nm and its feasibility to on-board testing was investigated by performing measurement system performance checks, correlation exercises with a laboratory instrument and on-road tests. The application of condensation particle counter methodology was able to adjust the lower detection efficiency and ideal to determine the PN concentration due to the existence of a plateau region of detection efficiency over a sufficiently large range of particle sizes. A heated catalytic stripper improved volatile particle removal performance and prevented re-nucleation of volatile fractions at the particle counter. One of the technical challenges was higher particle losses below 23 nm.
Recommended Content
Authors
Topic
Citation
Otsuki, Y., Tochino, S., Kondo, K., and Haruta, K., "Portable Emissions Measurement System for Solid Particle Number Including Nanoparticles Smaller than 23 nm," SAE Technical Paper 2017-01-2402, 2017, https://doi.org/10.4271/2017-01-2402.Data Sets - Support Documents
| Title | Description | Download |
|---|---|---|
| Unnamed Dataset 1 | ||
| Unnamed Dataset 2 |
Also In
References
- Weiss , M. , Bonnel , P. , Hummel , R. , Manfredi , U. et al. Analyzing on-road emissions of light-duty vehicles with portable emission measurement systems JRC Scientific and Technical Reports EUR 24697 EN 2011
- Hu , S. , Zhang , S. , Sardar , S. , Chen , S. et al. Evaluation of Gravimetric Method to Measure Light-Duty Vehicle Particulate Matter Emissions at Levels below One Milligram per Mile (1 mg/mile) SAE Technical Paper 2014-01-1571 2014 10.4271/2014-01-1571
- Giechaskiel , B. , Dilara , B. , and Andersson , J. Particle Measurement Programme (PMP) Light-Duty Inter-Laboratory Exercise: Repeatability and Reproducibility of the Particle Number Method Aerosol Sci. Technol. 42 7 528 543 2008 10.1080/02786820802220241
- Otsuki , Y. , Nakamura , H. , Arai , M. , and Xu , M. The methodologies and instruments of vehicle particulate emission measurement for current and future legislative regulations Meas. Sci. Technol. 26 9 092002 2015 10.1088/0957-0233/26/9/092002
- Conclusions on Improving Particulate Mass Measurement Procedures and New Particle Number Measurement Procedures Relative to The Requirements of The 05 Series of The 05 Series of Amendments to Regulation No. 83, GRPE-48-11-Rev.1 2004
- Kittelson , D. , and Franklin , L. Nanoparticle emissions from an ethanol fueled HCCI engine http://www.cambridgeparticlemeeting.org/sites/default/files/Presentations/2010/DKittelson(UMinnesota)_2010_Ethanol_HCCI.pdf
- Kim , S. , Kondo , K. , Otsuki , Y. , and Haruta , K. A New On-Board PN Analyzer for Monitoring the Real-Driving Condition SAE Technical Paper 2017-01-1001 2017 10.4271/2017-01-1001
- EUROPEAN COMMISSION ANNEXES to the Commission Regulation amending Commission Regulation (EU) 2017/xxx and Directive 2007/46/EC of the European Parliament and of the Council as regards real-driving emissions from light passenger and commercial vehicles (Euro 6) 2016
- Otsuki , Y. , Kondo , K. , Takeda , K. , and Nakamura , H. Applicability of Diffusion Charger Sensor to Portable Emission Measurement System SAE Technical Paper 2015-01-1994 2015 10.4271/2015-01-1994
- Wilson W. E. , Stanek J. , Han H. S. , Johnson T. et al. Use of the Electrical Aerosol Detector as an Indicator of the Surface Area of Fine Particles Deposited in the Lung J. Air Waste Manag. Assoc. 57 2 211 220 2007 10.1080/10473289.2007.10465321
- Giechaskiel , B. , Riccobono , F. , and Bonnel , P. Feasibility study on the extension of the Real Driving Emissions (RDE) procedure to Particle Number (PN) - Chassis dynamometer evaluation of portable emission measurement systems (PEMS) to measure particle number (PN) concentration: Phase II - EUR 27451 EN 2015 10.2790/74218
- Abdul-Khalek , I. and Kittelson , D. Real Time Measurement of Volatile and Solid Exhaust Particles Using a Catalytic Stripper SAE Technical Paper 950236 1995 10.4271/950236
- Khalek , I. Sampling System for Solid and Volatile Exhaust Particle Size, Number, and Mass Emissions SAE Technical Paper 2007-01-0307 2007 10.4271/2007-01-0307
- Swanson , J. , and Kittelson , D. Evaluation of thermal denuder and catalytic stripper methods for solid particle measurements J. Aerosol Sci. 41 1113 1122 2010 10.1016/j.jaerosci.2010.09.003
- Otsuki , Y. , Takeda , K. , Haruta , K. , and Mori , N. A Solid Particle Number Measurement System Including Nanoparticles Smaller than 23 Nanometers SAE Technical Paper 2014-01-1604 2014 10.4271/2014-01-1604
- Stolzenburg , M. R. , and McMurry , P. H. An Ultrafine Aerosol Condensation Nucleus Counter Aerosol Science and Technology 14 48 65 1991 10.1080/02786829108959470
- Yamada , H. PN Emissions from Heavy-Duty Diesel Engine with Periodic Regenerating DPF SAE Int. J. Engines 6 2 1178 1189 2013 10.4271/2013-01-1564
- Mamakos , A. , Carriero , M. , Bonnel , P. , Demircioglu , H. et al. EU-PEMS PM EVALUATION PROGRAM - Second Report -Study on Post DPF PM/PN Emissions JRC Scientific and Technical Reports EUR 24793 EN 2011