This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Problems in Assessing Pneumatic Wheel Unbalance of a Passenger Car Determined with Test Road in Normal Conditions
Technical Paper
2017-01-1805
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
The vibrations of the sprung mass of a passenger car, traveling along a road surface, are random. They also form its main source but there are besides other factors to consider. The resulting force ratio is overlapped by other phenomena occurring at the interface of the pneumatic tire with the road surface, such as non-uniformity of tires, shape deformations and imbalances. The resulting additional inertia force acts on the kinematic force that was previously induced on the car body. The vibrations of the sprung mass of the car body at the time can be considered as a potential source of diagnostic information, but getting insight their direct identification is difficult. Moreover, the basic identification is complicated because of the forces induced due to the random interference from road roughness. In such a case, the ratio defined as SNR assumes negative values. Due to the lack of comprehensive studies involving identification of the unbalance of the whole pneumatic wheel in real conditions, these authors decided to undertake experimental research in this area. The main objective of the study was to identify the unbalance of a pneumatic wheel based on the vibration of the sprung mass in a car body. The registered acceleration sensor signal was analyzed in the frequency domain, thus obtaining information about its specific components such as the value of the amplitude and frequency range prevailing in its spectrum. The analysis of the recorded signals applied selected statistical methods (autocorrelation, probability density distribution), as well as the frequency domain (PSD, FFT, STFT). To this purpose, this paper presents the results of both bench and road implemented at selected speeds ranging from 50 to 100 km / h. The results of the study were compared with the results of simulation calculations using the model of quarter car. The application process was based on a one-dimensional Bayes classifier and a designated distribution function for the strengthening of a classifier representing the state of the road surface.
Recommended Content
Authors
Topic
Citation
Prażnowski, K. and Mamala, J., "Problems in Assessing Pneumatic Wheel Unbalance of a Passenger Car Determined with Test Road in Normal Conditions," SAE Technical Paper 2017-01-1805, 2017, https://doi.org/10.4271/2017-01-1805.Also In
References
- Bendat J.S. and Piersol A.G. Random data. Analysis and measurement procedures John Wiley& Sons Inc. New York 2010
- Clark S. K. The pneumatic tire the U.S. Department of Transportation, National Highway Traffic Safety Administration 2006
- Byoung S. K. , Chang H. C. and Tae K. L. A study on radial directional natural frequency and damping ratio in a vehicle tire Elsevier, Applied Acoustics 68 538 556 2007
- Dohrmann C.R. Dynamics of a tire wheel suspension assembly Journal of Sound and Vibration 210 5 627 642 1998
- Genta G. and Morello L. The Automotive Chassis Components Design 1 Springer 2008 https://books.google.pl/books?isbn=1402086768/
- Gobbi M. , Botero J. and Mastinu G. Improving the active safety of road vehicles by sensing forces and moments at the wheels Vehicle System Dynamic 09 2008 46 957 968
- Gobbi M. , Mastinu G. and Rocca G. A Smart Wheel for Improving the Active Safety of Road Vehicles ASME 2010 International Design Engineering Technical Conferences and Computers and Information in Engineering Conference, 12th International Conference on Advanced Vehicle and Tire Technologies Quebec Canada August 15-18, 2010
- Hanley , R. , Crolla , D. , and Hauke , M. Tire Modeling for Misuse Situations SAE Technical Paper 2001-01-0748 2001 10.4271/2001-01-0748
- Johnson T.J. and Adams D.E. Composite indices applied to vibration data in rolling tires to detect bead area damage Mechanical Systems and Signal Processing 21 5 July 2007 2161 2184
- Kamitamari , T. and Sakai , H. A Study on Radial Tire Vibration SAE Technical Paper 852195 1985
- Kido , I. and Ueyama , S. Coupled Vibration Analysis of Tire and Wheel for Road Noise Improvement SAE Technical Paper 2005-01-2525 2005 10.4271/2005-01-2525
- Prażnowski K. , Bieniek A. and Graba M. Analiza drgań masy nieresorowanej oraz resorowanej w aspekcie diagnostyki niewyrównoważenia koła ogumionego Logistyka 6/2014, Poznań 2014
- Prażnowski K. , Brol S. and Augustynowicz A. Identification of static unbalance wheel of passenger car carried out on a road Solid State Phenomena, Trans Tech Publications 214 48 57 2014
- Reimpell J. , Stoll H. and Betzler J.W. The Automotive Chassis: Enginnering Principles SAE International and Edward Arnold Publishing 2001
- Tae K. L. and Byoung S. K. Vibration analysis of automobile tire due to bump impact Applied Acoustics 69 6 473 478 2008
- Andrzejewski R. Dynamika pneumatycznego koła jezdnego Wydawnictwo Naukowo - Techniczne Warszawa 2010
- Mamala J. Kompensacja niedostatku siły napędowej w procesie rozpędzania samochodu osobowego Studia i Monografie, z. 290 Oficyna Wydawnicza Politechniki Opolskiej 2011
- Achtelik H. and Grzelak J. Ćwiczenia laboratoryjne z modelowania i symulacji układów mechanicznych w programie Matlab-simulink Skrypt nr. 269, Wydawnictwo Politechniki Opolskiej 2005
- Hirahara M. Study concentring the effect of wheel center trajectory angle on harshness vibration JSEA Review 23 33 39 2002
- Wong J. Y. Theory of Ground Vehicles John Wiley & Sons New York 20 03 2001
- Mamala J. , Brol S. and Jantos J. Estymacja charakterystyk układu napędowego na podstawie pomiaru przyspieszenia samochodu Studia i Monografie, z. 235 Oficyna Wydawnicza Politechniki Opolskiej Opole 2008
- Prażnowski K. Wykorzystanie metody STFT do identyfikacji stanu niewyrównoważenia koła ogumionego samochodu Badania Pojazdów, opracowanie monograficzne pod redakcją W. Mitiańca, str.117-127 Wydawnictwo Politechniki Krakowskiej Kraków 2014
- Prażnowski K. and Mamala J. Klassification of the road surface condition on the basis of vibrations of the sprung mass in a passenger car Scientific Conference on Automotive Vehicles and Combustion Engines (KONMOT 2016) IOP Publishing IOP Conf. Series: Materials Science and Engineering 148 2016 012022 10.1088/1757-899X/148/1/012022