This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Estimation of the Clutch Characteristic Map for an Automated Wet Friction Clutch Transmission
Technical Paper
2016-01-1113
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
Higher demands on comfort and efficiency require a continuous improvement of the shift process. During the launch and shift process the clutch control is used to get a smooth and efficient behavior. In this short time of acting the shifting behavior can be rated. Many control concepts use a clutch characteristic to calculate the actuator signal based on the clutch torque. Therefore, a high quality of this characteristic is necessary. Because of the dynamic process during clutch engagement the clutch characteristic needs further information to reach a high accuracy for the control algorithm. In this paper an existing clutch torque characteristic is extended to a characteristic map where the clutch torque becomes a function of the current actuator signal of the clutch and the clutch slip. The extension of the torque characteristic describes the slip based dependencies, e.g. the friction coefficient. The model of the characteristic map consists of the multiplication of two separate functions in these two dimensions. The parameters of this model are estimated using different identification algorithms, in this case a non-linear recursive and a non-recursive identification algorithm. Both estimation algorithms result in a characteristic map of the clutch behavior. A further advantage of the presented approach is the normalization during the estimation process of the slip-based function with the cost function. Thus, the original torque characteristic can be used as fallback if the identification of the slip-based part still need reference data to converge or shows an implausible behavior.
Recommended Content
| Technical Paper | CHEVROLET AUTOMATIC TRANSMISSION |
| Ground Vehicle Standard | Spring-Loaded Clutch Spin Test Procedure |
| Technical Paper | Robustness and Variability Prediction of Seat Vibration Caused by All-Wheel Drive System Imbalance in Vehicle Development |
Authors
Citation
Arndt, T., Tarasow, A., Bohn, C., Wachsmuth, G. et al., "Estimation of the Clutch Characteristic Map for an Automated Wet Friction Clutch Transmission," SAE Technical Paper 2016-01-1113, 2016, https://doi.org/10.4271/2016-01-1113.Also In
References
- Arndt , T. , Tarasow , A. , Bohn , C. , Wachsmuth , G. et al. 2013 Concepts for control of automated clutches in theory and practice Proceedings of the International VDI Congress 2013 Friedrichshafen. Germany 653 65
- Garofalo , F. , Glielmo , L. , Iannelli , L. and Vasca , F. 2002 Optimal tracking for automotive dry clutch engagement Proceedings of the 15th IFAC World Congress Barcelona 367 72
- van der Heijden , A. , Serrarens , A. , Camlibel , M. K. and Nijmeijer , H. 2007 Hybrid optimal control of dry clutch engagement International Journal of Control 2007 November 2007 80 11 1717 28
- Kim , J. , Kwanghyun C. and Choi . S. B. 2011 Gear shift control of Dual Clutch Transmissions with a torque rate limitation trajectory Proceedings of the American Control Conference San Francisco 3338 43
- Vasca , F. , Iannelli , L. , Senatore , A. and Scafati ., M. T. 2008 Modeling torque transmissibility for automotive dry clutch engagement Proceedings of the American Control Conference Seattle 306 11
- Tarasow . A , Arndt , T. , Bohn , C. , Wachsmuth , G. et al. 2013 Challenges and Approaches of Adaptation of Friction Clutches Proceedings of the CTI Symposium ‘Automotive Transmissions, HEV and EV Drives’ Shanghai 1 12
- Tarasow , A. 2015 Analysis and identification of the quasi-stationary behavior of torque transmission for automated friction clutches in vehicles („Analyse und Identifikation des quasistationären Verhaltens der Drehmomentübertragung von automatisierten Reibungskupplungen in Kraftfahrzeugen PhD-Thesis Clausthal University of Technology Clausthal
- Dolcini , P. J. 2007 Contribution to the clutch comfort PhDThesis Grenoble Institute Technology Grenoble
- Beinecke , S. 2000 Online estimation of mechanical parameters, characteristics and states of controlled electrical drives (“Online-Schätzung von mechanischen Parametern, Kennlinien und Zustandsgrößen geregelter elektrischer Antriebe PhD-Thesis University of Paderborn Paderborn
- Kiessner-Haiden , M. , Lebring , A. T. 2009 Approach to control a clutch unit (“Verfahren zum Steuern einer Kupplungseinheit Patent: WO002007148203A2
- Nouailletas , R. , Mendes , E. , Koenig , D. 2010 Control Engineering Practice 18 8 904 17
- Olsson , H. , Åström , K. J. , De Wit , C. C. , Gäfvert , M. et al. 1998 Friction models and friction compensation European journal of control 4 3 176 95
- De Wit , C. C. , Olsson , H. , Astrom , K. J. and Lischinsky , P. 1995 A new model for control of systems with friction IEEE Transactions on Automatic Control 40 3 419 25
- Chu , H. , Tang , N. , Gao , B. and Chen , H. 2014 Friction coefficient identification of dry clutch in automated manual transmissions Proceedings of International Conference on Mechatronics and Control (ICMC) 2014 IEEE Jinzhou 1115 19
- Verge , M. 2005 Friction identification with genetic algorithms Proceedings of IFAC World Congress Prague 1 6
- Parlitz , U. , Hornstein , A. , Engster , D. , Al-Bender , F. et al. 2004 Identification of pre-sliding friction dynamics Chaos: An Interdisciplinary Journal of Nonlinear Science 14 2 420 30
- Rizos , D. D. and Fassois , S. D. 2009 Friction identification based upon the LuGre and Maxwell slip models IEEE Transactions on Control Systems Technology. 17 1 153 60
- Glielmo , L. , Iannelli , L. , Vacca , V. and Vasca , F. 2004 December Speed control for automated manual transmission with dry clutch Proceedings of the 43rd IEEE Conference on Decision and Control, 2004. CDC. 2 Nassau 1709 14
- Mäki , R. 2005 Wet clutch tribology PhD-Thesis Lulea University of Technology Sweden
- Madsen , K. , Nielsen , H. B. and Tingleff , O. 1999 Methods for non-linear least squares problems 2 nd April 2004 Technical University Denmark
- Levenberg , K. 1944 A method for the solution of certain non- linear problems in least squares Quarterly of Applied Mathematics 2 164 68
- Marquardt , D. W. 1963 An algorithm for least-squares estimation of nonlinear parameters Journal of the Society for Industrial & Applied Mathematics 11 2 431 41
- Ljung , L. and Soderstrom , T. 1983 Theory and practice of recursive system identification Cambridge MIT press