This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
2D Residual Gas Visualization in an Optical Direct Injection Spark Ignition Engine with IR Laser Absorption
Technical Paper
2015-01-1648
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
The spatial distribution of internal exhaust gas recirculation (EGR) is evaluated in an optically accessible direct injection spark ignition engine using near infrared laser absorption to visualize the distribution of the H2O molecule. The obtained overall internal exhaust gas recirculation compares well to gas-exchange cycle calculations and the spatial distributions are consistent with those measured with inverse LIF. The experimental procedures described in this report are designed to be simple and rapidly implemented without the need to resort to unusual optical components. The necessary spectral data of the selected absorption line is obtained from the HITEMP database and is validated with prior experiments carried out in a reference cell. Laser speckle in the images is effectively reduced using a ballistic diffuser. An exact quantification of the water concentration of each pixel is not yet possible for all of the investigated operating conditions because of the limited power of the employed laser. However, strong inhomogeneities of EGR distributions during the intake stroke such as the tumble motion can be recognized and general trends are reproduced as expected.
Recommended Content
Authors
Citation
Golzke, H., Holler, H., Friedrich, W., Leick, P. et al., "2D Residual Gas Visualization in an Optical Direct Injection Spark Ignition Engine with IR Laser Absorption," SAE Technical Paper 2015-01-1648, 2015, https://doi.org/10.4271/2015-01-1648.Also In
References
- Berg , T. , Thiele , O. , Seefeldt , S. , and Vanhaelst , R. Measurement of in-cylinder mixture formation by optical indication MTZ Worldwide 74 6 26 30 2013 10.1007/s38313-013-0060-1
- Witzel , O. , Klein , A. , Wagner , S. , Meffert , C. et al. High-speed tunable diode laser absorption spectroscopy for sampling-free in-cylinder water vapor concentration measurements in an optical IC engine Applied Physics B 109 3 521 532 2012 10.1007/s00340-012-5225-0
- Moos , R. , Reetmeyer , B. , Hürland , A. , and Plog , C. Sensor for directly determining the exhaust gas recirculation rate-EGR sensor Sensors and Actuators B: Chemical 119 1 57 63 2006 10.1016/j.snb.2005.11.055
- Galliot , F. , Cheng , W. , Cheng , C. , Sztenderowicz , M. et al. In-Cylinder Measurements of Residual Gas Concentration in a Spark Ignition Engine SAE Technical Paper 900485 1990 10.4271/900485
- Chalmers , J.M. and Griffiths , P.R. Handbook of vibrational spectroscopy New York J. Wiley 2002 0471988472
- Ebert , V. and Wolfrum , J. Absorption Mayinger , F. and Feldmann , O. Optical Measurements Springer Berlin Heidelberg 231 270 2001 10.1007/978-3-642-56443-7_13
- Fischer , J. , Gamache , R.R. , Goldman , A. , Rothman , L.S. et al. Total internal partition sums for molecular species in the 2000 edition of the HITRAN database Journal of Quantitative Spectroscopy and Radiative Transfer 82 1-4 401 412 2003 10.1016/S0022-4073(03)00166-3
- Rothman , L.S. , Gordon , I.E. , Barber , R.J. , Dothe , H. et al. HITEMP, the high-temperature molecular spectroscopic database Journal of Quantitative Spectroscopy and Radiative Transfer 111 15 2139 2150 2010 10.1016/j.jqsrt.2010.05.001
- Rothman , L.S. , Gordon , I.E. , Babikov , Y. , Barbe , A. et al. The HITRAN2012 molecular spectroscopic database Journal of Quantitative Spectroscopy and Radiative Transfer 130 4 50 2013 10.1016/j.jqsrt.2013.07.002
- Kitamura , R. , Pilon , L. , and Jonasz , M. Optical constants of silica glass from extreme ultraviolet to far infrared at near room temperature Applied Optics 46 33 8118 8133 2007 10.1364/AO.46.008118
- Witzel , O. In-situ-Laserabsorptionsspektroskopie zur μs-schnellen Bestimmung von Spezieskonzentrationen und Temperaturen in Verbrennungsmotoren Ph.D. Thesis TU Darmstadt 2013
- Hunsmann , S. , Wunderle , K. , Wagner , S. , Rascher , U. et al. Absolute, high resolution water transpiration rate measurements on single plant leaves via tunable diode laser absorption spectroscopy (TDLAS) at 1.37 μm Applied Physics B 92 3 393 401 2008 10.1007/s00340-008-3095-2
- Imai , Y. and Ohtsuka , Y. Laser speckle reduction by ultrasonic modulation Optics Communications 27 1 18 22 1978 10.1016/0030-4018(78)90165-7
- Tu , S.-Y. , Lin , H.Y. , and Lin , M.-C. Efficient speckle reduction for a laser illuminating on a micro-vibrated paper screen Applied Optics 53 22 E38 E46 2014 10.1364/AO.53.000E38
- Hanson , R.K. , Seitzman , J.M. , and Paul , P.H. Planar laser-fluorescence imaging of combustion gases Applied Physics B 50 6 441 454 1990 10.1007/BF00408770
- Buschbeck , M. Laseroptische Analyse der zyklischen Schwankungen in einem Tranparentmotor Ph.D. Thesis TU Darmstadt Darmstadt 2013
- Schulz , C. and Sick , V. Tracer-LIF diagnostics: quantitative measurement of fuel concentration, temperature and fuel/air ratio in practical combustion systems Progress in Energy and Combustion Science 31 1 75 121 2005 10.1016/j.pecs.2004.08.002
- Müller , H. and Bertling , H. Programmierte Auswertung von Druckverläufen in Ottomotoren VDI-Verlag 1971
- Lejsek , D. Berechnung des instationären Wandwärmeübergangs im Hochlauf von Ottomotoren mit Benzin-Direkteinspritzung Ph.D. Thesis TU Darmstadt Darmstadt 2009
- Allan , D.W. Should the classical variance be used as a basic measure in standards metrology? Instrumentation and Measurement, IEEE Transactions on 1001 2 646 654 1987 10.1109/TIM.1987.6312761
- Ossler , F. and Aldén , M. Measurements of picosecond laser induced fluorescence from gas phase 3-pentanone and acetone: implications to combustion diagnostics Applied Physics B 64 4 493 502 1997 10.1007/s003400050205