This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
A Study of Combustion Phasing Control and Emissions in Jet Controlled Compression Ignition Engines
Technical Paper
2014-01-2671
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
To directly control the premixed combustion phasing, a novel method called Jet Controlled Compression Ignition (JCCI) is investigated. Experiments were conducted on a single cylinder natural aspirated diesel engine at 3000 r/min without EGR. Numerical model was validated by pressure and heat release rate curves at a fixed spark timing. The simulation results showed that the reacting active radical species with high temperature issued from ignition chamber played an important role on the onset of combustion in JCCI system. The combustion of diesel pre-mixtures was initiated rapidly by the combustion products issued from ignition chamber. Consequently, the experiments of spark timing sweep were conducted to verify the above deduction. The results showed a good linear relationship between spark timing and CA10 and CA50, which validated the ability for direct combustion phasing control in diesel premixed combustion. The NOx and Soot emissions gradually changed with decrease of spark advance angle. The maximum reduction of NOx and Soot were both over 90%.
Authors
Citation
Long, W., Zhang, Q., Tian, J., Wang, Y. et al., "A Study of Combustion Phasing Control and Emissions in Jet Controlled Compression Ignition Engines," SAE Technical Paper 2014-01-2671, 2014, https://doi.org/10.4271/2014-01-2671.Also In
References
- Hu G. Prospect on Diesel Combustion Research [J]. Journal of Dalian Institute of Technology 1982 04 71 80
- Guodong , H. New Strategy on Diesel Combustion Development SAE Technical Paper 900442 1990 10.4271/900442
- Long W , Ohtsuka H , Obokata T. Characterization of Conical Spray Flow for Diesel Engine by Means of Laser Doppler methods: PDA measurement of droplet size distribution [J]. JSME international journal. Series B, fluids and thermal engineering 1996 39 3 554 561
- Leng X , Feng L , Long W et al. A Study of the Mixture Formation Process for a Third-Generation Conical Spray Applied in HCCI Diesel Combustion [J]. Fuel 2010 89 1 392 398
- Dumitrescu E , Neill S , Guo H et al. Fuel Property Effects on PCCI Combustion in a Heavy-Duty Diesel Engine [J]. American Society of Mechanical Engineers 2012 134 52801 52808
- Stanglmaier H. , Roberts Charles E. Homogeneous Charge Compression Ignition (HCCI): Benefits, Compromises, and Future Engine Applications [J]. Progress in technology 2003 100 477 484
- Luszcz P , Xu H , Wyzsnski M et al. Imaging studies of in-cylinder HCCI combustion [J]. Frontiers in Energy 2011 5 3 313 321
- Kuboyama , T. , Moriyoshi , Y. , Hatamura , K. , Suzuki , M. et al. Effect of Fuel and Thermal Stratifications on the Operational Range of an HCCI Gasoline Engine Using the Blow-Down Super Charge System SAE Int. J. Engines 3 1 666 680 2010 10.4271/2010-01-0845
- Hanson , R. , Kokjohn , S. , Splitter , D. , and Reitz , R. An Experimental Investigation of Fuel Reactivity Controlled PCCI Combustion in a Heavy-Duty Engine SAE Int. J. Engines 3 1 700 716 2010 10.4271/2010-01-0864
- Splitter , D. , Wissink , M. , Kokjohn , S. , and Reitz , R. Effect of Compression Ratio and Piston Geometry on RCCI Load Limits and Efficiency SAE Technical Paper 2012-01-0383 2012 10.4271/2012-01-0383
- Reitz R D. Directions in internal combustion engine research [J]. Combustion and flame 2013 160 1 1 8
- Kokjohn , S. , Hanson , R. , Splitter , D. , and Reitz , R. Experiments and Modeling of Dual-Fuel HCCI and PCCI Combustion Using In-Cylinder Fuel Blending SAE Int. J. Engines 2 2 24 39 2009 10.4271/2009-01-2647
- Benajes , J. , Novella , R. , Garcia , A. , Domenech , V. et al. An Investigation on Mixing and Auto-ignition using Diesel and Gasoline in a Direct-Injection Compression-Ignition Engine Operating in PCCI Combustion Conditions SAE Int. J. Engines 4 2 2590 2602 2011 10.4271/2011-37-0008
- Eichmeier , Johannes , Wagner Uwe , and Spicher Ulrich Controlling gasoline low temperature combustion by diesel micro pilot injection [J] Journal of Engineering for Gas Turbines and Power 134.7 2012 072802
- Flowers , D. , Aceves , S. , Martinez-Frias , J. , Smith , J. et al. Operation of a Four-Cylinder 1.9L Propane Fueled Homogeneous Charge Compression Ignition Engine: Basic Operating Characteristics and Cylinder-to-Cylinder Effects SAE Technical Paper 2001-01-1895 2001 10.4271/2001-01-1895
- Jia M , Xie M , Wang T et al. The effect of injection timing and intake valve close timing on performance and emissions of diesel PCCI engine with a full engine cycle CFD simulation [J]. Applied Energy 2011 88 9 2967 2975
- Kim , D.S. ; Lee , C.S. Improved emission characteristics of HCCI engine by various premixed fuels and cooled EGR [J] Fuel 2006 85 695 704
- Park , Y. and Bae , C. Influence of EGR and Pilot Injection on PCCI Combustion in a Single-Cylinder Diesel Engine SAE Technical Paper 2011-01-1823 2011 10.4271/2011-01-1823
- Hanjalić , K. ; Popovac , M. ; Hadžiabdić , M. A robust near-wall elliptic-relaxation eddy-viscosity turbulence model for CFD [J]. Int. J. Heat Fluid Flow 2004 25 1047 1051
- Huh , K. Y. , and Gosman A. D. A phenomenological model of diesel spray atomization Proceedings of the international conference on multiphase flows 91 1991
- Colin , O. ; Benkenida , A. The 3-Zones extended coherent flame model (Ecfm3z) for computing premixed/diffusion combustion [J]. Oil Gas Sci. Technol. 2004 59 593 609