This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
A Preliminary Investigation of the Performance and Emissions of a Port-Fuel Injected SI Engine Fueled with Acetone-Butanol-Ethanol (ABE) and Gasoline
Technical Paper
2014-01-1459
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
Alcohols, because of their potential to be produced from renewable sources and their characteristics suitable for clean combustion, are considered potential fuels which can be blended with fossil-based gasoline for use in internal combustion engines. As such, n-butanol has received a lot of attention in this regard and has shown to be a possible alternative to pure gasoline. The main issue preventing butanol's use in modern engines is its relatively high cost of production. Acetone-Butanol-Ethanol (ABE) fermentation is one of the major methods to produce bio-butanol. The goal of this study is to investigate the combustion characteristics of the intermediate product in butanol production, namely ABE, and hence evaluate its potential as an alternative fuel. Acetone, n-butanol and ethanol were blended in a 3:6:1 volume ratio and then splash blended with pure ethanol-free gasoline with volumetric ratios of 0%, 20%, 40% to create various fuel blends. These blends were tested in a port-fuel injected spark-ignited (SI) engine and their performance was evaluated through measurements of in-cylinder pressure, and various exhaust emissions. In addition, pure gasoline was also tested as a baseline for comparison of ABE fuels. The tests were conducted at an engine speed of 1500 RPM and a load of 350 kPa brake mean effective pressure (BMEP). On the basis of the experimental data, combustion characteristics for these fuels have been determined as follows: mass fraction burned (MFB) profile, rate of MFB, combustion duration and location of 50% MFB.
Authors
Topic
Citation
Nithyanandan, K., Wu, H., Huo, M., and Lee, C., "A Preliminary Investigation of the Performance and Emissions of a Port-Fuel Injected SI Engine Fueled with Acetone-Butanol-Ethanol (ABE) and Gasoline," SAE Technical Paper 2014-01-1459, 2014, https://doi.org/10.4271/2014-01-1459.Also In
References
- Song , K. , Nag , P. , Litzinger , T.A. , Haworth , D.C. Effects of oxygenated additives on aromatic species in fuel-rich, premixed ethane combustion: a modeling study Combustion and Flame 135 3 341 349 2008 10.1016/S0010-2180(03)00180-9
- Kumar , S. , Cho , J.H. , Park , J. , Moon , I. Advances in Diesel-Alcohol Blends and their Effects on the Performance and Emissions of Diesel Engines Renewable and Sustainable Energy Reviews 22 46 72 2013 10.1016/j.rser.2013.01.017
- Kumar , M. , Goyal , Y. , Sarkar , A. , Gayen , K. Comparative economic assessment of ABE fermentation based on cellulosic and non-cellulosic feedstocks Applied Energy 93 193 204 2012 10.1016/j.apenergy.2011.12.079
- Rajasekar , E. , Murugesan , A. , Subramanian , R. , Nedunchezhian , N. Review of NOx reduction technologies in CI engines fuelled with oxygenated biomass fuels Renewable and Sustainable Energy Reviews 14 7 2113 2121 2010 10.1016/j.rser.2010.03.005
- Qureshi , N. , Ezeji , T.C. Butanol, ‘a Superior Biofuel’ Production from Agricultural Residues (Renewable Biomass): Recent Progress in Technology Biofuels, Bioproducts and Biorefining 2 4 319 330 2008 10.1002/bbb.85
- He , B.-Q. , Liu , M.-B. , Yuan , J. , Zhao , H. Combustion and emission's characteristics of a HCCI engine fuelled with n-butanol-gasoline blends Fuel 108 668 674 2013 10.1016/j.fuel.2013.02.026
- Jones , D.T. , Woods , D.R. Acetone-Butanol Fermentation revisited Microbiological Reviews 50 4 484 524 1986
- Chang , Y.-C. , Lee , W.-J. , Lin , S.-L. , Wang , L.-C. Green Energy: Water Containing Acetone-Butanol-Ethanol Diesel Blends Fueled in Diesel Engines Applied Energy 109 182 191 2013 10.1016/j.apenergy.2013.03.086
- Dusséaux , S. , Croux , C. , Soucaille , P. , Meynial-Salles , I. Metabolic Engineering of Clostridium Acetobutylicum ATCC 824 for Isopropanol-Butanol-Ethanol Fermentation Metabolic Engineering 18 1 8 2013 10.1016/j.ymben.2013.03.003
- Jang , Y.-S. , Malaviya , A. , Cho , C. , Lee , J. et al. Butanol Production from Renewable Biomass by Clostridia Bioresource Technology 123 653 663 2012 10.1016/j.biortech.2012.07.104
- Kraemer , K. , Harwardt , A. , Bronneberg , R. , Marquardt , W. Separation of Butanol from Acetone-Butanol_Ethanol Fermentation by a Hybrid Extraction-Distillation Process Computers and Chemical Engineering 35 5 949 963 2012 10.1016/j.compchemeng.2011.01.028
- Qureshi , N. , Hughes , S. , Maddox , I.S. , Cotta , M.A. Energy-Efficient Recovery of Butanol From Model Solutions and Fermentation Broth by Adsorption Bioprocess and Biosystems Engineering 27 4 215 222 2005 10.1007/s00449-005-0402-8
- Crabbe , E. , Nolasco-Hipolito , C. , Kobayashi , G. , Sonomoto , K. et al. Biodiesel Production from Crude Palm Oil and Evaluation of Butanol Extraction and Fuel Properties Process Biochemistry 37 1 65 71 2001 10.1016/S0032-9592(01)00178-9
- Qureshi , N. Application of Continuous Substrate Feeding to the ABE Fermentation: Relief of Product Inhibition Using Extraction, Perstraction, Stripping, and Pervaporation Biotechnology Progress 8 5 382 390 1992 10.1021/bp00017a002
- Afschar , A.S. , Biebl , H. , Schaller , K. , Schugerl , K. Production of Acetone and Butanol by Clostridium Acetobutylicum in a Continuous Culture with Cell Recycle Applied Microbiology and Biotechnology 22 6 394 398 1985 10.1007/BF00257026
- Liu , F. , Liu , L. , Feng , X. Separation of Acetone-Butanol-Ethanol (ABE) From Dilute Aqueous Solutions by Pervaporation Separation and Purification Technology 42 3 273 282 2005 10.1016/j.seppur.2004.08.005
- García , V. , Päkkilä , J. , Ojamo , H. , Muurinen , E. et al. Challenges in Biobutanol Production: How to improve Efficiency Renewable and Sustainable Energy Reviews 15 2 964 980 2011 10.1016/j.rser.2010.11.008
- Alasfour , F.N. Butanol - a single-cylinder engine study: availability analysis Appl Therm Eng 17 6 537 49 1997 10.1016/S1359-4311(96)00069-5
- Alasfour , F.N. Effect of using 30% iso-butanol-gasoline blend on hydrocarbon emissions from a spark-ignition engine Energy Sources 21 5 379 94 1999 10.1080/00908319950014704
- Williams , J. , Goodfellow , C. , Lance , D. , Ota , A. et al. Impact of Butanol and Other Bio-Components on the Thermal Efficiency of Prototype and Conventional Engines SAE Technical Paper 2009-01-1908 2009 10.4271/2009-01-1908
- Dernotte , J. , Mounaim-Rousselle , C. , Halter , F. , Seers , P. Evaluation of butanol-gasoline blends in a port fuel-injection, spark-ignition engine Oil Gas Sci Technol - Rev IFP 65 2 345 51 2010 10.2516/ogst/2009034
- Wigg , B. , Coverdill , R. , Lee , C. , and Kyritsis , D. Emissions Characteristics of Neat Butanol Fuel Using a Port Fuel-Injected, Spark-Ignition Engine SAE Technical Paper 2011-01-0902 2011 10.4271/2011-01-0902
- Niass , T. , Amer , A. , Xu , W. , Vogel , S. et al. Butanol Blending - a Promising Approach to Enhance the Thermodynamic Potential of Gasoline - Part 1 SAE Int. J. Fuels Lubr. 5 1 265 273 2011 10.4271/2011-01-1990
- Gu , X. , Huang , Z. , Cai , J. , Gong , J. , Wu , X. , Lee , C.F. Emission characteristics of a spark-ignition engine fuelled with gasoline-n-butanol blends in combination with EGR Fuel 93 611 7 2012 10.1016/j.fuel.2011.11.040
- Yacoub , Y. , Bara , R. , Gautam , M. The performance and emission characteristics of C1-C5 alcohol-gasoline blends with matched oxygen content in a single cylinder spark ignition engine Proceedings of the Institution of Mechanical Engineers, Part A: Journal of Power and Energy 212 5 363 79 1998 10.1243/0957650981536934
- Szwaja , S. , Naber , J.D. Combustion of n-butanol in a spark-ignition IC engine Fuel 89 1573 82 2010 10.1016/j.fuel.2009.08.043
- Wallner , T. and Frazee , R. Study of Regulated and Non-Regulated Emissions from Combustion of Gasoline, Alcohol Fuels and their Blends in a DI-SI Engine SAE Technical Paper 2010-01-1571 2010 10.4271/2010-01-1571
- Cairns , A. , Stansfield , P. , Fraser , N. , Blaxill , H. et al. A Study of Gasoline-Alcohol Blended Fuels in an Advanced Turbocharged DISI Engine SAE Int. J. Fuels Lubr. 2 1 41 57 2009 10.4271/2009-01-0138
- Zuehl , J. R. Fuel Effects on Homogeneous Charge Compression Ignition Combustion M.S. thesis Department of Mechanical Engineering, University of Wisconsin Madison, Madison 2009
- Van Geem , K.M. , Cuoci , A. , Frassoldati , A. , Pyl , S.P. et al. An Experimental and Kinetic Modeling Study of Pyrolysis and Combustion of Acetone-Butanol-Ethanol (ABE) Mixtures Combust. Sci. Technol. 184 942 955 10.1080/00102202.2012.663987
- Andrae , J.C.G. Development of a detailed kinetic model for gasoline surrogate fuels Fuel 87 2013 2022 2008 10.1016/j.fuel.2007.09.010