This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Comparative Study of Ignition Systems for Lean Burn Gas Engines in an Optically Accessible Rapid Compression Expansion Machine
Technical Paper
2013-24-0112
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
Ignition systems for large lean burn gas engines are challenged by large energy deposition requirements to ensure stable and reliable inflammation of the premixed charge. In this study, two different ignition systems are investigated experimentally: ignition by means of injecting a small amount of diesel spray and its subsequent autoignition is compared to the ignition with an un-scavenged pre-chamber spark plug over a wide range of engine relevant conditions such as methane equivalence ratios and thermomechanical states. The ignition behavior as well as the combustion phase of the two systems is investigated using an optically accessible Rapid Compression Expansion Machine (RCEM). Filtered OH-chemiluminescence images of the ignition and combustion were taken with a UV intensified high speed camera through the piston window. Pressure signals along with filtered photomultiplier signals of the total emitted light for three different radicals (OH, CH, C2) were recorded to study the effects of ignition system and operating conditions on the early combustion phase.
Ignition with a pre-chamber spark plug was seen to accelerate the early combustion phase in the main chamber due to the turbulence generated by the flame jets, but following the dissipation of this initial turbulence slower flame propagation was observed. Higher temperatures and equivalence ratios (Φ) lead to increased turbulence generation of the flame jets as well as shorter delays between spark timing and entrance of the jets into the main combustion chamber. Similar trends with respect to temperature and pressure conditions were observed in the case of Diesel pilot ignition. However, the ignition delays of the pilot spray increased at higher levels of methane in the ambient gas. Generally, the flame/ignition jets generated by pilot injection provide a more stable and stronger ignition source than those achieved by means of pre-chamber spark plug ignition.
Recommended Content
| Technical Paper | Experimental and Numerical Analysis of a Pre-Chamber Turbulent Jet Ignition Combustion System |
| Technical Paper | Lean Mixture Operation of Hydrogen-Fueled Spark Ignition Engines |
Authors
Citation
Schlatter, S., Schneider, B., Wright, Y., and Boulouchos, K., "Comparative Study of Ignition Systems for Lean Burn Gas Engines in an Optically Accessible Rapid Compression Expansion Machine," SAE Technical Paper 2013-24-0112, 2013, https://doi.org/10.4271/2013-24-0112.Also In
References
- Toulson , E. , Schock , H. , and Attard , W. A Review of Pre-Chamber Initiated Jet Ignition Combustion Systems SAE Technical Paper 2010-01-2263 2010 10.4271/2010-01-2263
- Borges , L. , Hollnagel , C. , and Muraro , W. Development of a Mercedes-Benz Natural Gas Engine M 366 LAG, with a Lean Burn Combustion System SAE Technical Paper 962378 1996 10.4271/962378
- Cho , H.M. and He , B.-Q. Spark ignition natural gas engines - A review Energy Conversion and Management 48 608 618 2007
- Fukuzawa , Y. , Shimoda , H. , Kakuhama , Y. , Endo , H. et al. Development of High Efficiency Miller Cycle Gas Engine Mitsubishi Heavy Industries, Ltd., Technical Review 38 3 146 150 2001
- Karim , G.A. Combustion in Gas-fueled Compression Ignition Engines of the Dual Fuel Type Handbook of Combustion 3 213 235 2010
- Shah , A. , Tunestal , P. , and Johansson , B. Investigation of Performance and Emission Characteristics of a Heavy Duty Natural Gas Engine Operated with Pre-Chamber Spark Plug and Dilution with Excess Air and EGR SAE Int. J. Engines 5 4 1790 1801 2012 10.4271/2012-01-1980
- Kawabata , Y. and Mori , D. Combustion Diagnostics & Improvement of a Prechamber Lean-Burn Natural Gas Engine SAE Technical Paper 2004-01-0979 2004 10.4271/2004-01-0979
- Toulson , E. , Huisjen , A. , Chen , X. , Squibb , C. et al. Visualization of Propane and Natural Gas Spark Ignition and Turbulent Jet Ignition Combustion SAE Int. J. Engines 5 4 1821 1835 2012 10.4271/2012-32-0002
- Abd Alla , G.H. , Badr , O.A. , Soliman , H.A. and Abd Rabbo , M.F. Exhaust emissions from an indirect injection dual-fuel engine Proc. Inst. Mech. Eng. 214 3 333 340 2000
- Papagiannakis , R.G. and Hountalas , D.T. Experimental Investigation of Natural Gas Percentage on Performance and Emissions of a D.I. Dual Fuel Engine Appl. Therm. Eng. 23 3 353 365 2003
- Krishnan , S.R. , Srinivasan , K.K. , Singh , S. Bell , S.R. and Midkiff , K.C. Strategies for Reduced NOx Emissions in Pilot-Ignited Natural Gas Engines Journal of Engineering for Gas Turbines and Power 126 3 665 671 2004
- Abd Alla , G.H. , Soliman , H.A. , Badr , O.A. and Abd Rabbo , M.F. Effect of pilot quantity on the performance of a dual fuel engine Energy Conversion & Management 41 6 559 572 2000
- Zhang , Y. , Kong , S. , and Reitz , R. Modeling and Simulation of a Dual Fuel (Diesel/Natural Gas) Engine With Multidimensional CFD SAE Technical Paper 2003-01-0755 2003 10.4271/2003-01-0755
- lida , N. , Nakamura , M. , and Ohashi , H. Study of Diesel Spray Combustion in An Ambient Gas Containing Hydrocarbon Using a Rapid Compression Machine SAE Technical Paper 970899 1997 10.4271/970899
- Lee , J.H. and Iida , N. Combustion of diesel spray injected into reacting atmosphere of propane-air homogenous mixture Int. J. Engine Research 2 1 69 80 2001
- Saito , H. , Sakurai , T. , Sakonji , T. , Hirashima , T. et al. Study on Lean Burn Gas Engine Using Pilot Oil as the Ignition Source SAE Technical Paper 2001-01-0143 2001 10.4271/2001-01-0143
- Carlucci , A. , Laforgia , D. , Saracino , R. , and Toto , G. Study of Combustion Development in Methane-Diesel Dual Fuel Engines, Based on the Analysis of In-Cylinder Luminance SAE Technical Paper 2010-01-1297 2010 10.4271/2010-01-1297
- Schlatter , S. , Schneider , B. , Wright , Y. , and Boulouchos , K. Experimental Study of Ignition and Combustion Characteristics of a Diesel Pilot Spray in a Lean Premixed Methane/Air Charge using a Rapid Compression Expansion Machine SAE Technical Paper 2012-01-0825 2012 10.4271/2012-01-0825
- Pickett , L. , Siebers , D. , and Idicheria , C. Relationship Between Ignition Processes and the Lift-Off Length of Diesel Fuel Jets SAE Technical Paper 2005-01-3843 2005 10.4271/2005-01-3843
- Ishida , M. , Tagai , T. and Ueki , H. Effect of EGR and Preheating on Natural Gas Combustion Assisted with Gas-Oil in a Diesel Engine JSME International Journal Series B (Fluids and Thermal Engineering No. 1 Special Issue on Recent Combustion Technology in Internal Combustion Engines) 40 124 130 2003
- Escher , A. , Kirchen , P. , and Boulouchos , K. Experimental investigations using a transparent single shot compression machine for HCCI - combustion SAE Technical Paper 2007-24-0009 2007 10.4271/2007-24-0009
- Gerke , U. Numerical Analysis of Mixture Formation and Combustion in a Hydrogen Direct-Injection Internal Combustion Engine Ph.D. thesis 17477 Department of Mechanical and Process Engineering, Federal Institute of Technology Zurich Zurich 2007
- Hardalupas , Y. and Orain , M. Local measurements of the time-dependent heat release rate and equivalence ratio using chemiluminescent emission from a flame Combustion and Flame 139 188 207 2004
- Lauer , M. and Sattelmayer , T. On the Adequacy of Chemiluminescence as a Measure for Heat Release in Turbulent Flames With Mixture Gradients Journal of Engineering for Gas Turbines and Power 132 2010
- Wülfert , K. , Schlatter , S. , Wachtmeister , G. and Boulouchos , K. Erstellung eines phänomenologischen Modells zur Vorausberechnung des Brennverlaufes von Gasmotoren bei extremen Miller/Atkinson-Betrieb Final report FVV Project no. 1017, Heft R962/R563 2013
- Peer , J. , Korb , P. , Schlatter , S. , Wachtmeister , G. et al. Einfluss der Abgasrückführung bei Magerkonzept-Gasmotoren mit extremen Steuerzeiten auf Brennverlauf und Schadstoffemissionen unter Berücksichtigung der Gasqualität Final report FVV Project no. 6010741, Heft R962 2013
- Khalil , E. , Samuel , P. , and Karim , G. An Analytical Examination of the Chemical Kinetics of the Combustion of N-Heptane-Methane Air Mixtures SAE Technical Paper 961932 1996 10.4271/961932
- Mancaruso , E. , Merola , S. , and Vaglieco , B. Extinction and Chemiluminescence Measurements in CR DI Diesel Engine Operating in HCCI Mode SAE Technical Paper 2007-01-0192 2007 10.4271/2007-01-0192
- Boston , P.M. , Bradley , D. , Lung , F.K-K. , Vince , I.M. et al. Flame Initiation in Lean, Quiescent and Turbulent Mixtures with Various Igniters Twentieth Symposium (International) on Combustion/The Combustion Institute 141 149 1984