This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Effects of Air Conditioner Use on Real-World Fuel Economy
Technical Paper
2013-01-0551
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
On-road and laboratory experiments with a 2009 Ford Explorer and a 2009 Toyota Corolla were conducted to assess the fuel consumption penalty associated with air conditioner (A/C) use at idle and highway cruise conditions. Vehicle data were acquired on-road and on a chassis dynamometer. Data were gathered for various A/C settings and with the A/C off and the windows open. At steady speeds between 64.4 and 113 kph (40 and 70 mph), both vehicles consumed more fuel with the A/C on at maximum cooling load (compressor at 100% duty cycle) than when driving with the windows down. The Explorer maintained this trend beyond 113 kph (70 mph), while the Corolla fuel consumption with the windows down matched that of running the A/C at 121 kph (75 mph), and exceeded it at 129 kph (80 mph). The incremental fuel consumption rate penalty due to air conditioner use was nearly constant with a slight trend of increasing consumption with increasing vehicle (and compressor) speed. A lower fuel penalty due to A/C operation is observed at idle for both vehicles, likely due to the low compressor speed at this operating point, although the percentage increase due to A/C use is highest at idle.
Recommended Content
Technical Paper | Developing the AC17 Efficiency Test for Mobile Air Conditioners |
Technical Paper | Cold Storage Air Conditioning System for Idle Stop Vehicle |
Technical Paper | Development of High Efficient Radiator Cooling Fan for Automotive Application |
Authors
Topic
Citation
Huff, S., West, B., and Thomas, J., "Effects of Air Conditioner Use on Real-World Fuel Economy," SAE Technical Paper 2013-01-0551, 2013, https://doi.org/10.4271/2013-01-0551.Also In
References
- Thomas , J. , West , B. , Huff , S. , and Norman , K. Effect of Intake Air Filter Condition on Light-Duty Gasoline Vehicles SAE Technical Paper 2012-01-1717 2012 10.4271/2012-01-1717
- Federal Register 61 205 October 22 1996 Final Regulations for Revisions to the Federal Test Procedure for Emissions From Motor Vehicles
- U.S. Environmental Protection Agency Final Technical Support Document Fuel Economy Labeling of Motor Vehicle Revisions to Improve Calculations of Fuel Economy Estimates, EPA420-R-06-017 December 2006
- U.S. Department of Energy Office of Energy Efficiency and Renewable Energy/U.S. Environmental Protection Agency Fuel Economy Guide , DOE/EE-0603 November 2012 http://www.fueleconomy.gov/feg/pdfs/guides/feg2012.pdf
- Nadamoto , H. and Kubota , A. Power Saving with the Use of Variable Displacement Compressors SAE Technical Paper 1999-01-0875 1999 10.4271/1999-01-0875
- Nam , E. Understanding and Modeling NOx Emissions from Air Conditioned Automobiles SAE Technical Paper 2000-01-0858 2000 10.4271/2000-01-0858
- Zhai , K. Could Automotive HVAC Become An EPA/DOE Energy Star? SAE Technical Paper 2001-01-2480 2001 10.4271/2001-01-2480
- Rugh , J. , Hendricks , T. , and Koram , K. Effect of Solar Reflective Glazing on Ford Explorer Climate Control, Fuel Economy, and Emissions SAE Technical Paper 2001-01-3077 2001 10.4271/2001-01-3077
- Johnson , V. Fuel Used for Vehicle Air Conditioning: A State-by-State Thermal Comfort-Based Approach SAE Technical Paper 2002-01-1957 2002 10.4271/2002-01-1957
- Welstand , J. , Haskew , H. , Gunst , R. , and Bevilacqua , O. Evaluation of the Effects of Air Conditioning Operation and Associated Environmental Conditions on Vehicle Emissions and Fuel Economy SAE Technical Paper 2003-01-2247 2003 10.4271/2003-01-2247
- Nam , E. and Colvin , A. An Experimental Procedure for Simulating an SC03 Emissions Test with Air Conditioner On SAE Technical Paper 2004-01-0594 2004 10.4271/2004-01-0594
- Tian , Changqing , and Li Xianting Transient behavior evaluation of an automotive air conditioning system with a variable displacement compressor Applied Thermal Engineering 25 2005 1922 1948
- Han , T. and Chen , K. Assessment of Various Environmental Thermal Loads on Passenger Compartment Soak and Cool-down Analyses SAE Technical Paper 2009-01-1148 2009 10.4271/2009-01-1148
- Rugh , J. Proposal for a Vehicle Level Test Procedure to Measure Air Conditioning Fuel Use SAE Technical Paper 2010-01-0799 2010 10.4271/2010-01-0799
- Kaushik , S. , Chen , K. , Han , T. , and Khalighi , B. Micro-Cooling/Heating Strategy for Energy Efficient HVAC System SAE Int. J. Mater. Manuf. 4 1 853 863 2011 10.4271/2011-01-0644
- Ghosh , D. , Wang , M. , Wolfe , E. , Chen , K. et al. Energy Efficient HVAC System with Spot Cooling in an Automobile - Design and CFD Analysis SAE Int. J. Passeng. Cars - Mech. Syst. 5 2 885 903 2012 10.4271/2012-01-0641
- Makino , M. , Ogawa , N. , Abe , Y. , and Fujiwara , Y. Automotive Air-conditioning Electrically Driven Compressor SAE Technical Paper 2003-01-0734 2003 10.4271/2003-01-0734
- Qi , Zhao-gang , Chen Jiang-ping , Chen Zhi-jui , Hu Wei , and He Bin Experimental study of an auto-controlled automobile air conditioning system with an externally-controlled variable displacement compressor Applied Thermal Engineering 27 2007 927 933
- Yokoyama , A. , Osaka , T. , Imanishi , Y. , and sekiya , S. Thermal Management System for Electric Vehicles SAE Int. J. Mater. Manuf. 4 1 1277 1285 2011 10.4271/2011-01-1336
- Chen , K. , Kaushik , S. , Han , T. , Ghosh , D. et al. Thermal Comfort Prediction and Validation in a Realistic Vehicle Thermal Environment SAE Technical Paper 2012-01-0645 2012 10.4271/2012-01-0645
- Desai , A. , Sapali , S. , and Parthasarathi , G. Experimental Optimization of Charge Level in an Automotive Air Conditioning system under Steady State Conditions SAE Technical Paper 2010-36-0018 2010 10.4271/2010-36-0018
- Federal Register 77 199 October 15 2012 2017 and Later Model Year Light-Duty Vehicle Greenhouse Gas Emissions and Corporate Average Fuel Economy Standards
- Wang , D. , Crane , D. , and LaGrandeur , J. Design and Analysis of a Thermoelectric HVAC System for Passenger Vehicles SAE Technical Paper 2010-01-0807 2010 10.4271/2010-01-0807
- Adhikari , V. , Nassar , A. , and Nagpurwala , Q. Numerical Studies on the Effect of Cooling Vent Setting and Solar Radiation on Air Flow and Temperature Distribution in a Passenger Car SAE Technical Paper 2009-28-0048 2009 10.4271/2009-28-0048
- Patidar , A. Simulation and Validation of Passenger Compartment Soaking and Cooling under Solar Load SAE Technical Paper 2009-28-0050 2009 10.4271/2009-28-0050
- Sluder , C. and West , B. NMOG Emissions Characterizations and Estimation for Vehicles Using Ethanol-Blended Fuels SAE Int. J. Fuels Lubr. 5 2 721 732 2012 10.4271/2012-01-0883