This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Combustion Control Using Two-Stage Diesel Fuel Injection in a Single-Cylinder PCCI Engine
Technical Paper
2004-01-0938
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
A diesel-fueled premixed charged compression ignition (PCCI) combustion technique using a two-stage injection strategy has been investigated in a single cylinder optical engine equipped with a common-rail fuel system. Although PCCI combustion has the advantages of reducing NOx and PM emissions, difficulties in vaporization of a diesel fuel and control of the combustion phase hinder the development of the PCCI engine. A two-stage injection strategy was applied to relieve these problems. The first injection, named as main injection, was an early direct injection of diesel fuel into the cylinder to achieve premixing with air. The second injection was a diesel injection of a small quantity (1.5 mm3) as an ignition promoter and combustion phase controller near TDC. Effects of injection pressure, injected fuel quantity and compression ratio were studied with variation of an intake air temperature. The experimental results showed that the two-stage injection could be used as a combustion phase controller only in the case of a low intake air temperature but maintained the effect of ignition promotion while the ignition timing was advanced by the high intake air temperature. The main injection timing should be advanced earlier than BTDC 100°CA for the homogeneous and non-luminous combustion. Results of the PCCI combustion showed reduced NOx by more than 90% but increased fuel consumption and HC, CO emissions compared to direct injection (DI) diesel engine. The base injection angle 150° was modified to 100° for the reduction of smoke and unburned fuel made from the over-penetration of fuel spray, which implies the way of optimized injector selection to achieve the successful early injection strategy.
Recommended Content
Authors
Topic
Citation
Kook, S. and Bae, C., "Combustion Control Using Two-Stage Diesel Fuel Injection in a Single-Cylinder PCCI Engine," SAE Technical Paper 2004-01-0938, 2004, https://doi.org/10.4271/2004-01-0938.Also In
Homogeneous Charge Compression Ignition (Hcci) Combustion 2004
Number: SP-1819; Published: 2004-03-08
Number: SP-1819; Published: 2004-03-08
References
- Akagawa Hisashi Miyamoto Takeshi Harada Akira Sasaki Satoru Shimazaki Naoki Hashizume Takeshi Tsujimura Kinji “Approaches to Solve Problems of the Premixed Lean Diesel Combustion” SAE Paper 1999-01-0183 1999
- Yokota Haruyuki Kudo Yugo Nakajima Hiroshi Kakegawa Toshiaki Suzuki Takashi “A New Concept for Low Emission Diesel Combustion” SAE Paper 970891 1997
- Iwabuchi Yoshinori Kawai Kenji Shoji Takeshi Takeda Yoshinaka “Trial of New Concept Diesel Combustion System - Premixed Compression-Ignited Combustion-” SAE Paper 1999-01-0185 1999
- Walter Bruno Gaterllier Bertrand “Development of the High Power NADITM Concept Using Dual Mode Diesel Combustion to Achieve Zero NOx and Particulate Emissions” SAE Paper 2002-01-1744 2002
- Hasegawa Ryo Yanagihara Hiromichi “HCCI Combustion in DI Diesel Engine” SAE Paper 2003-01-0745 2003
- Christensen Magnus Hultqvist Anders Johansson Bengt “Demonstrating the Multi Fuel Capability of a Homogeneous Charge Compression Ignition Engine with Variable Compression Ratio” SAE Paper 1999-01-3679 1999
- Koyanagi K. Őing H. Renner G. Maly R. “Optimising common rail-injection by optical diagnostics in a transparent production type diesel engine” SAE Paper 1999-01-3646 1999
- Shimazaki Naoki Tsurushima Tadashi Nishimura Terukazu “Dual Mode Combustion Concept With Premixed Diesel Combustion by Direct Injection Near Top Dead Center” SAE Paper 2003-01-0742 2003
- Bae Choongsik Yu Jun Kang Jinsuk Kong Jangsik Lee Kyeong Ook “Effect of Nozzle Geometry on the Common-Rail Diesel Spray” SAE Paper 2002-01-1625 2002
- Thomas W. Ryan III Callanhan Timothy J. “Homogeneous Charge Compression Ignition of Diesel Fuel” SAE Paper 961160 1996
- Gray Allen W. (Bill) III Ryan, Thomas W. III “Homogeneous Charge Compression Ignition (HCCI) of Diesel Fuel” SAE Paper 971676 1997
- Hultqvist Anders Christensen Magnus Johansson Bengt Franke Axel Richter Mattias Aldĕn Marcus “A Study of the Homogeneous Charge Compression Inition Combustion Process by Chemiluminescence Imaging” SAE Paper 1999-01-3680 1999
- Gong Weidong Bell Stuart R. Micklow Gerald J. Fiveland Scott B. Willi Martin L. “Using Pilot Diesel Injection in a Natural Gas Fueled HCCI Engine” SAE Paper 2002-01-2866 2002
- Kimura Shuji Aoki Osamu Kitahara Yasuhisa Aiyoshizawa Eiji “Ultra-clean combustion technology combining a low-temperature and premixed combustion concept for meeting future emission standards” SAE Paper 2001-01-0200
- Groenendijk A. Műller E. “Mixture Formation and Combustion Control for Low Emission DI Diesel Combustion with HCCI-Chracteristics” Proc. Of Thiesel 2002 Conference on Thermo- and Fluid Dynamic Processes in Diesel Engines, Homogeneous Charge C. I. 146 157 2002
- Hyvonen Jari Haraldsson Goran Johansson Bengt “Operating Range in a Multi Cylinder HCCI Engine Using Variable Compression Ratio” SAE Paper 2003-01-1829 2003