This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Evaluation of the Effects of Air Conditioning Operation and Associated Environmental Conditions on Vehicle Emissions and Fuel Economy
Technical Paper
2003-01-2247
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
The Coordinating Research Council (CRC), California Air Resources Board (ARB), and Texas Commission on Environmental Quality sponsored a program to evaluate the effects of air conditioning (AC) operation on vehicle emissions and fuel economy.
Phase 1 of this work measured the effect of AC use with vehicles operated over several standard driving cycles and verified results previously obtained by other investigators. Phase 2 provided a better understanding of the effects of the interactions between ambient conditions (solar load, temperature, and humidity) and AC operation on emissions and fuel economy. The Phase 2 program also verified results of Phase 1 by using a different population of vehicles.
The program results demonstrated that AC operation had a substantial impact on emissions and fuel consumption. Operation of the vehicle AC system over a range of environmental conditions resulted in consistent increases in vehicle emissions of nitrogen oxides (NOx) and carbon monoxide (CO). NOx increased from 0.1 to 0.6 g/mile, depending on the severity of the test cycle and ambient conditions. CO increased from 0.5 to 12 g/mile. However, analyses indicated that increases in CO were actually due to the increases in ambient temperatures that were employed in the experiments.
The application of solar load to the vehicle increased the impact of AC operation. The application of solar load increased NOx emissions from 0.10 to 0.14 g/mile.
Although this experiment was not designed to specifically address fuel economy, operation of the vehicle AC system caused substantial decreases in vehicle fuel economy, ranging from 2.5 to 4.5 miles/gallon. The addition of solar load increased the effect on fuel economy, primarily at less severe ambient conditions. Solar load caused a decrease of 1.3 miles/gallon at 80°F and moderate humidity.
The results of the program were intended to aid in the improvement of vehicle emissions inventory models. NOx emission increases due to the use of AC ranged from 15% to 100% of baseline values. This level of effect indicates that AC use should be well accounted for in these models.
Recommended Content
Authors
Citation
Welstand, J., Haskew, H., Gunst, R., and Bevilacqua, O., "Evaluation of the Effects of Air Conditioning Operation and Associated Environmental Conditions on Vehicle Emissions and Fuel Economy," SAE Technical Paper 2003-01-2247, 2003, https://doi.org/10.4271/2003-01-2247.Also In
References
- Haskew, H. M. et. al. “The Execution of a Cooperative Industry/Government Exhaust Emission Test Program,” Society of Automotive Engineering Technical Paper Series, Paper No. 94C016 Oct 17 - 19 1994
- July 1 1986
- 61 205 54851 54906 Oct. 22 1996 Part II - Environmental Protection Agency - Title 40 of the Code of Federal Regulations Part 86 - Motor Vehicle Federal Emissions Test Procedure Revisions: Final Regulations
- http://www.epa.gov/otaq/mobile.htm November 5 2002 U.S. Environmental Protection Agency
- Mobile Source Emissions Inventory Program http://www.arb.ca.gov/msei/msei.htm October 15 2002 California Air Resources Board 9528 Telstar Avenue El Monte, CA 91731
- EMFAC2002 Release http://www.arb.ca.gov/msei/on-road/latestversion.htm January 7 2002 California Air Resources Board 9528 Telstar Avenue El Monte, CA 91731
- ARB Memorandum - Development of Air Conditioning Emissions Factors August 26 1998 California Air Resources Board 9528 Telstar Avenue, El Monte, CA 91731
- Gammeriello, R. T. Long, J. R. “An Emissions Comparison between the Unified Cycle and the Federal Test Procedure,” October 18 - 20 1993 Specialty Conference on the Emission Inventory: Perception and Reality AWMA Pasadena, CA
- Final Report - CRC Project E-37 “Effect of AC on Regulated Emissions for In-Use Vehicles - Phase I,” October 29 1999 Coordinating Research Council, Inc. 219 Perimeter Center Parkway, Suite 400, Atlanta, GA 30346-1301
- Final Report - CRC Project E-37 “Effect of Air Conditioning on Regulated Emissions for In-Use Vehicles - Phase II,” January 10 2001 Coordinating Research Council, Inc. 219 Perimeter Center Parkway, Suite 400, Atlanta, GA 30346-1301
- Test Results Databases, Summary Charts, Individual Test Reports - CRC Project E-37 “Effect of Air Conditioning on Regulated Emissions for In-Use Vehicles,” March 8 1999 Coordinating Research Council, Inc. 219 Perimeter Center Parkway, Suite 400, Atlanta, GA 30346-1301
- Test Results Databases, Summary Charts, Individual Test - CRC Project E-37 Phase 2 “Effect of AC on Regulated Emissions for In-Use Vehicles,” September 6 2001 Coordinating Research Council, Inc. 219 Perimeter Center Parkway, Suite 400, Atlanta, GA 30346-1301
- Pidgeon, W. M. Dobie, N. “The IM240 I/M Dynamometer Driving Schedule and the Composite I/M Test Procedure,” January 1991 Emissions Control Technology Division, Office of Mobile Sources, Environmental Protection Agency
- Gunst, R. F. “CRC Project No. E-37, The Effects of Air Conditioning on Regulated Emissions from In-Use Vehicles: Mean Emissions and Fuel Economy Comparisons, 7 reports” May 17 1999 June 28 1999 Southern Methodist University, Department of Statistical Science 3225 Daniel Avenue, Dallas, TX 75275-0332
- Gunst, R. F. “Project E-37 - Phase 2 Statistical Analysis Reports - Environmental Influences on the Effects of Vehicle Air Conditioning Operation on Vehicle Emissions and Fuel Economy” April 27 2000 September 12 2002 Southern Methodist University, Department of Statistical Science 3225 Daniel Avenue, Dallas, TX 75275-0332
- Title 40-Protection of the Environment, Part 86, Control Of Air Pollution From Motor Vehicles And Motor Vehicle Engines: Certification And Test Procedures December 23 1998