This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
The Effect of Cooled EGR on Emissions and Performance of a Turbocharged HCCI Engine
Technical Paper
2003-01-0743
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
This paper discusses the effects of cooled EGR on a turbo charged multi cylinder HCCI engine. A six cylinder, 12 liter, Scania D12 truck engine is modified for HCCI operation. It is fitted with port fuel injection of ethanol and n-heptane and cylinder pressure sensors for closed loop combustion control. The effects of EGR are studied in different operating regimes of the engine. During idle, low speed and no load, the focus is on the effects on combustion efficiency, emissions of unburned hydrocarbons and CO. At intermediate load, run without turbocharging to achieve a well defined experiment, combustion efficiency and emissions from incomplete combustion are still of interest. However the effect on NOx and the thermodynamic effect on thermal efficiency, from a different gas composition, are studied as well. At high load and boost pressure the main focus is NOx emissions and the ability to run high mean effective pressure without exceeding the physical constraints of the engine. In this case the effects of EGR on boost and combustion duration and phasing are of primary interest. It is shown that CO, HC and NOx emissions in most cases all improve with EGR compared to lean burn. Combustion efficiency, which is computed based on exhaust gas analysis, increases with EGR due to lower emissions of CO and HC.
Recommended Content
Authors
Topic
Citation
Olsson, J., Tunestål, P., Ulfvik, J., and Johansson, B., "The Effect of Cooled EGR on Emissions and Performance of a Turbocharged HCCI Engine," SAE Technical Paper 2003-01-0743, 2003, https://doi.org/10.4271/2003-01-0743.Also In
Homogeneous Charge Compression Ignition (Hcci) Combustion 2003
Number: SP-1742; Published: 2003-03-03
Number: SP-1742; Published: 2003-03-03
References
- Onishi S: Jo S. Hong Shoda K. Jo P Do Kato S. “Active Thermo-Atmosphere Combustion (ATAC) - A New Combustion Process for Internal Combustion Engines” SAE 790501
- Duret P. Venturi S. “Automotive Calibration of the IAPAC Fluid Dynamically Controlled Two-Stroke Combustion Process” SAE 960363
- Noguchi M. Tanaka Y. Tanaka T. Takeuchi Y. “A Study on Gasoline Engine Combustion by Observation of Intermediate Reactive Products during Combustion” SAE 790840
- Iida N. “Combustion Analysis of Methanol-Fueled Active Thermo-Atmosphere Combustion (ATAC) Engine Using a Spectroscopic Observation” SAE 940684
- Ishibashi Y. Asai M. “Improving the Exhaust Emissions of Two-Stroke Engines by Applying the Activated Radical Combustion” SAE 960742
- Gentili R. Frigo S. Tognotti L. Hapert P. Lavy J. “Experimental study of ATAC (Active Thermo-Atmosphere Combustion) in a Two-Stroke Gasoline Engine” SAE 970363
- Hultqvist A. Christensen M. Johansson B. Franke A. Richter M. Aldén M. “A Study of the Homogeneous Charge Compression Ignition Combustion Process by Chemiluminescence Imaging” SAE 1999-01-3680
- Najt P. Foster D.E. “Compression-Ignited Homogeneous Charge Combustion” SAE 830264
- Thring R.H. “Homogeneous-Charge Compression Ignition (HCCI) Engines” SAE 892068
- Aoyama T. Hattori Y. Mizuta J. Sato Y. “An Experimental Study on Premixed-Charge Compression Ignition Gasoline Engine” SAE 960081
- Ryan T.W. Callahan T.J. “Homogeneous Charge Compression Ignition of Diesel Fuel” SAE 961160
- Suzuki H. Koike N. Ishii H. Odaka M. “Exhaust Purification of Diesel Engines by Homogeneous Charge with Compression Ignition” SAE 970313 , SAE 970315
- Gray A. W. III Ryan T. W. III “Homogeneous Charge Compression Ignition (HCCI) of Diesel Fuel” SAE 971676
- Suzuki H. Koike N. Odaka M. “Combustion Control Method of Homogeneous Charge Diesel Engines” SAE 980509
- Seko T. Kuroda E. “Methanol Lean Burn in an Auto-Ignition Engine” SAE 980531
- Harada A. Shimazaki N. Sasaki S. Miyamoto T. Akagawa H. Tsujimura K. “The Effects of Mixture Formation on Premixed Lean Diesel Combustion” SAE 980533
- Christensen M. Einewall P. Johansson B. “Homogeneous Charge Compression Ignition (HCCI) Using Isooctane, Ethanol and Natural Gas - A Comparison to Spark Ignition Operation” SAE 972874
- Christensen M. Johansson B. Amnéus P. Mauss F. “Supercharged Homogeneous Charge Compression Ignition” SAE 980787
- Christensen M. Johansson B. “Influence of Mixture Quality on Homogeneous Charge Compression Ignition” SAE 982454
- Christensen, M. Hultqvist, A. Johansson, B. “Demonstrating the Multi Fuel Capability of a Homogeneous Charge Compression Ignition Engine with Variable Compression Ratio,” SAE 1999-01-3679
- Christensen M. Johansson B. “Homogeneous Charge Compression Ignition with Water Injection” SAE 1999-01-0182
- Christensen M Hultqvist A Johansson B “The Effect of Piston Topland Geometry on Emissions of Unburned Hydrocarbons From a Homogeneous Charge Compression Ignition (HCCI) Engine” SAE 2001-01-1893
- Stockinger M. Schäpertöns H. Kuhlmann P. Versuche an einem gemischansaugenden mit Selbszündung MTZ 53 1992
- Amneus P Nilsson D Christensen M Johansson B “Homogeneous Charge Compression Ignition Engine: Experiments and Detailed Kinetic Calculations” The Fourth Symposium on Diagnostics and Modeling of Combustion in Internal Combustion Engines, Comodia 98 567 572 1998
- Olsson J-O Erlandsson O. Johansson B. “Experiments and Simulations of a Six-Cylinder Homogeneous Charge Compression Ignition (HCCI) Engine” SAE 2000-01-2867
- Olsson J-O Tunestål P. Johansson B. “Closed-Loop Control of an HCCI Engine” SAE 2001-01-1031
- Christensen M. Johansson B. “Supercharged Homogeneous Charge Compression Ignition (HCCI) with Exhaust Gas Recirculation and Pilot Fuel” SAE 2000-01-1835
- Olsson J-O Tunestål P Haraldsson G Johansson B “A Turbo Charged Dual Fuel HCCI Engine” SAE 2001-01-1896
- Olsson J-O Tunestål P Johansson B Fiveland S Agama R Willi M Assanis D “Compression Ratio Influence on Maximum Load of a Natural Gas Fueled HCCI Engine” SAE 2002-01-0111
- Dec J “A Computational Study of the Effects of Low Fuel Loading and EGR on Heat Release Rates and Combustion Limits of HCCI Engines” SAE 2002-01-1309
- Aceves S Martinez-Frias J Flowers D Smith J Dibble R Wright J Hessel R “A Decoupled Model of Detailed Fluid Mechanics Followed by Detailed Chemical Kinetics for Prediction of Iso-Octane HCCI Combustion” SAE 2001-01-3612
- Hiltner J Fiveland S Agama R Willi M “System Efficiency Issues for Natural Gas Fueled HCCI Engines in Heavy-Duty Stationary Applications” SAE 2002-01-0417
- Heywood John B. Internal Combustion Engine Fundamentals 0-07-100499-8
- Meß- & Analysentechnik GmbH “Servicemenu Flame-Ionization-Detector Thermo-FID”