This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Understanding and Modeling NOx Emissions from Air Conditioned Automobiles
Technical Paper
2000-01-0858
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Event:
SAE 2000 World Congress
Language:
English
Abstract
The emission of excessive quantities of NOx when the automobile air conditioner is turned on has received a fair amount of attention in recent years. Since NOx is a smog precursor, it is important to understand the reasons for this jump in emissions especially on hot sunny days when air conditioner usage is at a maximum. A simple thermodynamic model is used to demonstrate how the torque from a typical air conditioner compressor is mainly related to the ambient temperature. The compressor's on-off cycling patterns are also characterized. Since the compressor significantly loads the engine, it affects fuel economy and emissions. The key independent variable that we employ to represent engine load is fuel rate. The correlations between engine-out NOx emissions and fuel rate are shown for a number of light duty vehicles and trucks. From these, a physical model for engine-out NOx emissions (with and without air conditioning) is presented. The non-linear relationship between engine-out NOx and load does not by itself explain how a 25% increase in fuel rate results in an observed 70% increase in NOx emissions. It is likely that the significant idle and low load excess emissions are due to the added air (and fuel) to the combustion without a corresponding increase in engine speed when the air conditioner is engaged. With slight modifications, the model is simple enough to be used in conjunction with other modal emissions models. Comparisons are made with other modeling efforts such as MOBILE6. Finally, suggestions are offered to vehicle designers which may decrease emissions and improve fuel economy by employing existing automobile air conditioner technology in a more efficient manner.
Recommended Content
Authors
Citation
Nam, E., "Understanding and Modeling NOx Emissions from Air Conditioned Automobiles," SAE Technical Paper 2000-01-0858, 2000, https://doi.org/10.4271/2000-01-0858.Also In
References
- AAMA “Motor Vehicle Facts and Figures,” American Automobile Manufacturers Association 1998
- An, Feng Ross Marc “The Use of Fuel by Spark Ignition Engines,” SAE 930329 1993
- An, F. Barth M. Norbeck J. “A Comparison Between Emission Speed Correction Factors and Vehicle Fuel Consumption,” Proceedings of the 6th CRC On-Road Vehicle Emissions Workshop 2 23 1996
- ASHRAE 1997 ASHRAE Handbook Fundamentals American Society of Heating Refrigeration and Air-Conditioning Engineers Atlanta 1997
- Barth, M. Tadi R.R. Asce M. Norbeck J. “The Development of an Integrated Transportation/Emissions Model for Estimating Emissions Inventories,” Proc. 1995 American Society of Civil Engineers Annual Conference San Diego, CA 1225 1236 1995
- Bevilacqua, O.M. “Effect of Air Conditioning on Regulated Emissions for in-use Vehicles,” CRC Draft Report, CRC Project E-37 1999
- Bhatti, M.S. “Enhancement of R-134a Automotive Air Conditioning System,” SAE paper 1999-01-0870 1999
- Bhatti, M.S. “A Critical Look at R-744 and R-134a Mobile Air Conditioning Systems,” SAE paper 9970527 1997
- Bosch Automotive Electric/Electronic Systems Robert Bosch GmbH Stuttgart 1995
- Duleep, K.G. Meszler, D. “Emission Control Technology to Comply with FTP Revisions,” SAE paper 961115 1996
- Environmental Protection Agency “Final Regulations for Revisions to the Federal Test Procedure for Emissions from Motor Vehicles,” 40 CFR 1996
- Galliot, F. Cheng W.K. Cheng C.O. Sztenderowicz M. Heywood J.B. Collings N. “In-Cylinder Measurements of Residual Gas Concentration in a Spark Ignition Engine,” SAE paper 900485 1990
- Goodwin, Robert “A Model of Automobile Exhaust Emissions During High Power Driving Episodes and Related Issues,” University of Michigan Doctoral Dissertation 1996
- Harte, S. Private communication at the Ford Motor Company 1999
- Haskew, Harold M. Cullen Kevin Liberty Thomas Langhorst William “The Execution of a Cooperative Industry/Government Exhaust Emissions Test Program,” SAE paper 94C016 1994
- Heywood, J.B. Internal Combustion Engine Fundamentals McGraw Hill, Inc. New York 1988
- Hoard, J. Rehagen L. “Relating Subjective Idle Quality to Engine Combustion,” SAE paper 970035 1997
- Koupal, J. “Air Conditioning Effects in MOBILE6,” EPA Report Number M6.ACE.001 1998
- Koupal, J. “Air Conditioning Correction Factors in MOBILE6,” EPA Report Number M6.ACE.002 1998
- Levine, C. Younglove T. Barth M. “Interaction of Temperature, Humidity, Driver Preferences, and Refrigerant Type on AC Compressor Usage,” Journal of Air and Waste Management 1999
- Miller, J.M. Private communication at the Ford Motor Company 1999
- Nam, E. Ross M. “A Fuel Rate Based Catalyst Pass Fraction Model for Predicting Tailpipe NOx Emissions from a Composite Car,” SAE paper 1999-01-0455 1999
- Nam, E. “Understanding and Modeling NOx Emissions From Light Driving Vehicles During Hot Operation” University of Michigan Doctoral Dissertation 1999
- Sankaran, A. Private communication at the Ford Motor Company 1999
- Thomas, Martin Marc Ross “Development of Second-by-Second Fuel Use and Emission Models Based on an Early 1990s Composite Car,” SAE Paper 971010 1997
- Toda, T. Nohira H. Kobashi K. “Evaluation of Burned Gas Ratio (BGR) as a Predominant Factor to NOx,” SAE paper 760765 1976