This content is not included in your SAE MOBILUS subscription, or you are not logged in.

Cycle-to-Cycle Variation Analysis of Two-Colour PLIF Temperature Measurements Calibrated with Laser Induced Grating Spectroscopy in a Firing GDI Engine

Journal Article
2019-01-0722
ISSN: 2641-9637, e-ISSN: 2641-9645
Published April 02, 2019 by SAE International in United States
Cycle-to-Cycle Variation Analysis of Two-Colour PLIF Temperature Measurements Calibrated with Laser Induced Grating Spectroscopy in a Firing GDI Engine
Sector:
Citation: Willman, C., Stone, R., Davy, M., Williams, B. et al., "Cycle-to-Cycle Variation Analysis of Two-Colour PLIF Temperature Measurements Calibrated with Laser Induced Grating Spectroscopy in a Firing GDI Engine," SAE Int. J. Adv. & Curr. Prac. in Mobility 1(4):1404-1419, 2019, https://doi.org/10.4271/2019-01-0722.
Language: English

References

  1. Johnson , T. and Joshi , A. Review of Vehicle Engine Efficiency and Emissions SAE Technical Paper 2018-01-0329 2018 10.4271/2018-01-0329
  2. Stone , R. Introduction to Internal Combustion Engines Fourth London Palgrave Macmillan 2012
  3. Wang , Z. , Liu , H. , and Reitz , R. Knocking Combustion in Spark-Ignition Engines Prog. Energy Combust. Sci. 61 78 112 2017
  4. Zhen , X. , Wang , Y. , Xu , S. , Zhu , Y. et al. The Engine Knock Analysis-An Overview Appl. Energy 92 628 636 2012
  5. Kalghatgi , G. Developments in Internal Combustion Engines and Implications for Combustion Science and Future Transport Fuels Proc. Combust. Inst. 35 1 101 115 2015
  6. Heywood , J. Internal Combustion Engine Fundamentals second New York McGraw-Hill Education 2018
  7. Kasseris , E. and Heywood , J. Charge Cooling Effects on Knock Limits in SI DI Engines Using Gasoline/Ethanol Blends: Part 1-Quantifying Charge Cooling SAE Technical Paper 2012-01-1275 2012 10.4271/2012-01-1275
  8. Li , T. , Gao , Y. , Wang , J. , and Chen , Z. The Miller Cycle Effects on Improvement of Fuel Economy in a Highly Boosted, High Compression Ratio, Direct-Injection Gasoline Engine: EIVC vs. LIVC Energy Convers. Manag. 79 59 65 2014
  9. Wei , H. , Zhu , T. , Shu , G. , Tan , L. et al. Gasoline Engine Exhaust Gas Recirculation-A Review Appl. Energy 99 534 544 2012
  10. Eckbreth , A. Laser Diagnostics for Combustion Temperature and Species second Amsterdam Gordon and Breach Publishers 1996
  11. Ladommatos , N. and Zhao , H. Engine Combustion Instrumentation and Diagnostics SAE International Warrendale 2001
  12. Kohse-Höinghaus , K. and Jeffries , J. Applied Combustion Diagnostics first New York Taylor & Francis 2002
  13. Schulz , C. , Dreizler , A. , Ebert , V. , and Wolfrum , J. Combustion Diagnostics Tropea C. , Yarin A. , and Foss J. Springer Handbook of Experimental Fluid Mechanics Berlin Springer-Verlag 2007 1241 1315
  14. Pischinger , S. , Günther , M. , and Budak , O. Abnormal Combustion Phenomena with Different Fuels in a Spark Ignition Engine with Direct Fuel Injection Combust. Flame 175 123 137 2017
  15. Goyal , G. , Warnatz , J. , and Maas , U. Numerical Studies of Hot Spot Ignition in H2-O2 and CH4-Air Mixtures Int. Symp. Combust. 23 1 1767 1773 1990
  16. Bauerle , B. , Hoffmann , F. , Behrendt , F. , and Warnatz , J. Detection of Hotspots in the End Gas of an Internal Combustion Engine Using Two-Dimensional LIF of Formaldehyde Int. Symp. Combust. 25 1 135 141 1994
  17. Scott , B. , Willman , C. , Williams , B. , Ewart , P. et al. In-Cylinder Temperature Measurements Using Laser Induced Grating Spectroscopy and Two-Colour PLIF SAE Int. J. Engines 10 4 2191 2201 2017 10.4271/2017-24-0045
  18. Schulz , C. and Sick , V. Tracer-LIF Diagnostics: Quantitative Measurement of Fuel Concentration, Temperature and Fuel/Air Ratio in Practical Combustion Systems Prog. Energy Combust. Sci. 31 1 75 121 2005
  19. Peterson , B. , Baum , E. , Böhm , B. , Sick , V. et al. Evaluation of Toluene LIF Thermometry Detection Strategies Applied in an Internal Combustion Engine Appl. Phys. B-Lasers Opt. 117 1 151 175 2014
  20. Kaiser , S. , Schild , M. , and Schulz , C. Thermal Stratification in an Internal Combustion Engine due to Wall Heat Transfer Measured by Laser-Induced Fluorescence Proc. Combust. Inst. 34 2 2911 2919 2013
  21. Luong , M. , Zhang , R. , Schulz , C. , and Sick , V. Toluene Laser-Induced Fluorescence for In-Cylinder Temperature Imaging in Internal Combustion Engines Appl. Phys. B-Lasers Opt. 91 669 675 2008
  22. Luong , M. , Koban , W. , and Schulz , C. Novel Strategies for Imaging Temperature Distribution Using Toluene LIF J. Phys.: Conf. Ser. 45 133 139 2006
  23. Peterson , B. , Baum , E. , Böhm , B. , Sick , V. et al. High-Speed PIV and LIF Imaging of Temperature Stratification in an Internal Combustion Engine Proc. Combust. Inst. 34 2 3653 3660 2013
  24. Thurber , M. and Hanson , R. Simultaneous Imaging of Temperature and Mole Fraction Using Acetone Planar Laser-Induced Fluorescence Exp. Fluids 30 1 93 101 2001
  25. Einecke , S. , Schulz , C. , and Sick , V. Measurement of Temperature, Fuel Concentration and Equivalence Ratio Fields Using Tracer LIF in IC Engine Combustion Appl. Phys. B-Lasers Opt. 71 5 717 723 2000
  26. Rothamer , D. , Snyder , J. , Hanson , R. , and Steeper , R. Optimization of a Tracer-Based PLIF Diagnostic for Simultaneous Imaging of EGR and Temperature in IC Engines Appl. Phys. B-Lasers Opt. 99 1-2 371 384 2009
  27. Thurber , M. and Hanson , R. Pressure and Composition Dependences of Acetone Laser-Induced Fluorescence with Excitation at 248, 266, and 308 nm Appl. Phys. B-Lasers Opt. 69 3 229 240 1999
  28. Grossmann , J. , Monkhouse , P. , Ridder , M. , Sick , V. et al. Temperature and Pressure Dependences of the Laser-Induced Fluorescence of Gas Phase Acetone and 3-Pentanone Appl. Phys. B-Lasers Opt. 62 3 249 253 1996
  29. Koban , W. , Koch , J. , Sick , V. , Wermuth , N. et al. Predicting LIF Signal Strength for Toluene and 3-Pentanone under Engine-Related Temperature and Pressure Conditions Proc. Combust. Inst. 30 1 1545 1553 2005
  30. Faust , S. , Tea , G. , Dreier , T. , and Schulz , C. Temperature, Pressure, and Bath Gas Composition Dependence of Fluorescence Spectra and Fluorescence Lifetimes of Toluene and Naphthalene Appl. Phys. B-Lasers Opt. 110 1 81 93 2013
  31. Devillers , R. , Bruneaux , G. , and Schulz , C. Investigation of Toluene LIF at High Pressure and High Temperature in an Optical Engine Appl. Phys. B-Lasers Opt. 96 4 735 739 2009
  32. Cundy , M. , Trunk , P. , Dreizler , A. , and Sick , V. Gas-Phase Toluene LIF Temperature Imaging Near Surfaces at 10 kHz Exp. Fluids 51 5 1169 1176 2011
  33. Löffler , M. , Beyrau , F. , and Leipertz , A. Acetone Laser-Induced Fluorescence Behavior for the Simultaneous Quantification of Temperature and Residual Gas Distribution in Fired Spark-Ignition Engines Appl. Opt. 49 1 37 49 2010
  34. Bolshov , M. , Kuritsyn , Y. , and Romanovskii , Y. Tunable Diode Laser Spectroscopy as a Technique for Combustion Diagnostics Spectroc. Acta Pt. B-Atom. Spectr. 106 45 66 2015
  35. Bürkle , S. , Biondo , L. , Ding , C. , Honza , R. et al. In-Cylinder Temperature Measurements in a Motored IC Engine Using TDLAS Flow Turbul. Combust. 101 1 139 159 2018
  36. Roy , S. , Gord , J. , and Patnaik , A. Recent Advances in Coherent Anti-Stokes Raman Scattering Spectroscopy: Fundamental Developments and Applications in Reacting Flows Prog. Energy Combust. Sci. 36 2 280 306 2010
  37. Brackmann , C. , Bood , J. , Afzelius , M. , and Bengtsson , P.-E. Thermometry in Internal Combustion Engines via Dual-Broadband Rotational Coherent Anti-Stokes Raman Spectroscopy Meas. Sci. Technol. 15 3 R13 R25 2004
  38. Weikl , M. , Beyrau , F. , and Leipertz , A. Simultaneous Temperature and Exhaust-Gas Recirculation-Measurements in a Homogeneous Charge-Compression Ignition Engine by Use of Pure Rotational Coherent Anti-Stokes Raman Spectroscopy Appl. Opt. 45 15 3646 3651 2006
  39. Beyrau , F. , Bräuer , A. , Seeger , T. , and Leipertz , A. Gas-Phase Temperature Measurement in the Vaporizing Spray of a Gasoline Direct-Injection Injector by Use of Pure Rotational Coherent Anti-Stokes Raman Scattering Opt. Lett. 29 3 247 249 2004
  40. Seeger , T. and Leipertz , A. Experimental Comparison of Single-Shot Broadband Vibrational and Dual-Broadband Pure Rotational Coherent Anti-Stokes Raman Scattering in Hot Air Appl. Opt. 35 15 2665 2671 1996
  41. Hildenbrand , S. , Staudacher , S. , Brüggemann , D. , Beyrau , F. et al. Numerical and Experimental Study of the Vaporization Cooling in Gasoline Direct Injection Sprays Proc. Combust. Inst. 31 2 3067 3073 2007
  42. Birkigt , A. , Michels , K. , Theobald , J. , Seeger , T. et al. Investigation of Compression Temperature in Highly Charged Spark-Ignition Engines Int. J. Engine Res. 12 3 282 292 2011
  43. Kiefer , J. and Ewart , P. Laser Diagnostics and Minor Species Detection in Combustion Using Resonant Four-Wave Mixing Prog. Energy Combust. Sci. 37 5 525 564 2011
  44. Williams , B. , Edwards , M. , Stone , R. , Williams , J. et al. High Precision In-Cylinder Gas Thermometry Using Laser Induced Gratings: Quantitative Measurement of Evaporative Cooling with Gasoline/Alcohol Blends in a GDI Optical Engine Combust. Flame 161 1 270 279 2014
  45. Stampanoni-Panariello , A. , Kozlov , D. , Radi , P. , and Hemmerling , B. Gas Phase Diagnostics by Laser-Induced Gratings I. Theory Appl. Phys. B-Lasers Opt. 81 1 101 111 2005
  46. Stampanoni-Panariello , A. , Kozlov , D. , Radi , P. , and Hemmerling , B. Gas Phase Diagnostics by Laser-Induced Gratings II. Experiments Appl. Phys. B-Lasers Opt. 81 1 113 129 2005
  47. Hart , R. , Balla , R. , and Herring , G. Nonresonant Referenced Laser-Induced Thermal Acoustics Thermometry in Air Appl. Opt. 38 3 577 584 1999
  48. Schlamp , S. , Hornung , H. , Sobota , T. , and Cummings , E. Accuracy and Uncertainty of Single-Shot, Nonresonant Laser-Induced Thermal Acoustics Appl. Opt. 39 30 5477 5481 2000
  49. Cummings , E. Laser-Induced Thermal Acoustics: Simple Accurate Gas Measurements Opt. Lett. 19 17 1361 1363 1994
  50. Cummings , E. , Leyva , I. , and Hornung , H. Laser-Induced Thermal Acoustics (LITA) Signals from Finite Beams Appl. Opt. 34 18 3290 3302 1995
  51. Paul , P. , Farrow , R. , and Danehy , P. Gas-Phase Thermal-Grating Contributions to Four-Wave Mixing J. Opt. Soc. Am. B-Opt. Phys. 12 3 384 392 1995
  52. Williams , S. , Rahn , L. , Paul , P. , Forsman , J. et al. Laser-Induced Thermal Grating Effects in Flames Opt. Lett. 19 21 1681 1683 1994
  53. Stevens , R. and Ewart , P. Single-Shot Measurement of Temperature and Pressure Using Laser-Induced Thermal Gratings with a Long Probe Pulse Appl. Phys. B-Lasers Opt. 78 1 111 117 2004
  54. Kychakoff , G. , Howe , R. , and Hanson , R. Quantitative Flow Visualization Technique for Measurements in Combustion Gases Appl. Opt. 23 5 704 712 1984
  55. Pfadler , S. , Beyrau , F. , Löffler , M. , and Leipertz , A. Application of a Beam Homogenizer to Planar Laser Diagnostics Opt. Express 14 22 10171 10180 2006
  56. Latzel , H. , Dreizler , A. , Dreier , T. , Heinze , J. et al. Thermal Grating and Broadband Degenerate Four-Wave Mixing Spectroscopy of OH in High-Pressure Flames Appl. Phys. B-Lasers Opt. 67 5 667 673 1998
  57. Brown , M. and Roberts , W. Single-Point Thermometry in High-Pressure, Sooting, Premixed Combustion Environments J. Propul. Power 15 1 119 127 1999
  58. Sahlberg , A.-L. , Hot , D. , Kiefer , J. , Aldén , M. , and Li , Z. Mid-Infrared Laser-Induced Thermal Grating Spectroscopy in Flames Proc. Combust. Inst. 36 3 4515 4523 2017
  59. Luers , A. , Sahlberg , A.-L. , Hochgreb , S. , and Ewart , P. Flame Thermometry Using Laser-Induced-Grating Spectroscopy of Nitric Oxide Appl. Phys. B-Lasers Opt. 124 3 1 13 2018
  60. Luers , A. , Sahlberg , A-L. , Förster , F. , Willman , C. et al. 2017
  61. Roshani , B. , Flügel , A. , Schmitz , I. , Kozlov , D. et al. Simultaneous Measurements of Fuel Vapor Concentration and Temperature in a Flash-Boiling Propane Jet Using Laser-Induced Gratings J. Raman Spectrosc. 44 10 1356 1362 2013
  62. Selcan , C. , Sander , T. , Altenhöfer , P. , Koroll , F. et al. Stagnation Temperature Measurements in a Shock-Tunnel Facility Using Laser-Induced Grating Spectroscopy J. Thermophys. Heat Transf. 32 1 226 236 2017
  63. Förster , F. , Crua , C. , Davy , M. , and Ewart , P. Temperature Measurements under Diesel Engine Conditions Using Laser Induced Grating Spectroscopy Combust. Flame 199 249 257 2019
  64. Williams , B. , Ewart , P. , Wang , X. , Stone , R. et al. Quantitative Planar Laser-Induced Fluorescence Imaging of Multi-Component Fuel/Air Mixing in a Firing Gasoline-Direct-Injection Engine: Effects of Residual Exhaust Gas on Quantitative PLIF Combust. Flame 157 10 1866 1878 2010
  65. Lumley , J. The Structure of Inhomogeneous Turbulent Flows Yaglom A. , Tatarsky A. Atmospheric Turbulence and Radio Wave Propagation Moscow Nauka 1967 166 178
  66. Moin , P. and Moser , R. Characteristic-Eddy Decomposition of Turbulence in a Channel J. Fluid. Mech. 200 471 509 1989
  67. Rempfer , D. and Fasel , H. Evolution of Three-Dimensional Coherent Structures in a Flat-Plate Boundary Layer J. Fluid. Mech. 260 351 375 1994
  68. Erdil , A. , Kodal , A. , and Aydin , K. Decomposition of Turbulent Velocity Fields in an SI Engine Flow Turbul. Combust. 68 91 110 2002
  69. Buhl , S. , Hartmann , F. , and Hasse , C. Identification of Large-Scale Structure Fluctuations in Engines using POD-Based Conditional Averaging Oil Gas Sci. Technol. - Rev. IFP Energies nouvelles 71 1 2016
  70. Roudnitzky , S. , Druault , P. , and Guibert , P. Proper Orthogonal Decomposition of In-Cylinder Engine Flow into Mean Component, Coherent Structures and Random Gaussian Fluctuations J. Turbul. 7 N70 2006
  71. Zhuang , H. and Hung , D. Characterization of the Effect of Intake Air Swirl Motion on Time-Resolved In-Cylinder Flow Field Using Quadruple Proper Orthogonal Decomposition Energy Conv. Manag. 108 366 376 2015
  72. Epps , B. and Techet , A. An Error Threshold Criterion for Singular Value Decomposition Modes Extracted from PIV Data Exp Fluids 48 2 355 367 2010
  73. Bizon , K. , Continillo , G. , Leistner , K. , Mancaruso , E. et al. POD-Based Analysis of Cycle-to-Cycle Variations in an Optically Accessible Diesel Engine P. Combust. Inst. 32 2 2809 2816 2009
  74. Chen , H. , Hung , D. , Xu , M. , Zhuang , H. et al. Proper Orthogonal Decomposition Analysis of Fuel Spray Structure Variation in a Spark-Ignition Direct-Injection Optical Engine Exp Fluids 55 1703 2014
  75. Sirovich , L. Turbulence and Dynamics of Coherent Structures Part I: Coherent Structures Q. Appl. Math. 45 3 561 571 1987
  76. Sandford , M. , Page , G. and Crawford , P. The All New AJV8 SAE Technical Paper 2009-01-1060 2009 10.4271/2009-01-1060
  77. Hollander , M. , Wolfe , D. , and Chicken , E. Nonparametric Statistical Methods third New Jersey John Wiley & Sons 2014
  78. Liu , K. and Haworth , D. Development and Assessment of POD for Analysis of Turbulent Flow in Piston Engines SAE Technical Paper 2011-01-0830 2011 10.4271/2011-01-0830
  79. Stone , R. , Zhao , H. , and Zhou , L. Analysis of Combustion and Particulate Emissions when Hydrogen is Aspirated into a Gasoline Direct Injection Engine SAE Technical Paper 2010-01-0580 2010 10.4271/2010-01-0580
  80. Ball , J. , Stone , R. , and Raine , R. A Technique for Estimating Completeness of Combustion and its Use in Modeling Cycle-By-Cycle Variations in Combustion SAE Technical Paper 2000-01-0953 2000 10.4271/2000-01-0953
  81. Shen , L. , Teh , K. , Ge , P. , Wang , Y. et al. Detecting Outliers in Crank Angle Resolved Engine Flow Field Datasets for Proper Orthogonal Decomposition SAE Technical Paper 2017-01-0612 2017 10.4271/2017-01-0612
  82. Gao , R. , Shen , L. , Teh , K. , Ge , P. et al. 2018

Cited By