This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Initial Evaluations of Injector Compatibility with an Alternative SCR Reductant Carrier - Guanidinium Formate
Technical Paper
2014-01-1532
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
The implementation of stringent nitrogen oxides (NOx) emissions reduction legislation in Europe and North America is driving the introduction of new exhaust aftertreatment systems, including those that treat NOx under the high-oxygen conditions typical of lean-burn engines.
One increasingly common solution, referred to as Selective Catalytic Reduction (SCR), comprises a catalyst that facilitates the reactions of ammonia (NH3) with the exhaust nitrogen oxides (NOx) to produce nitrogen (N2) and water (H2O). It is customary with these systems to use a liquid aqueous urea solution, typically at a 32% concentration of urea (CO(NH2)2). The solution is referred to as AUS-32, and is also known under its commercial name of AdBlue® in Europe, and DEF - Diesel Exhaust Fluid - in the USA. The urea solution is injected into the exhaust and transformed to NH3 by various mechanisms for the SCR reactions.
Urea injection systems using AUS-32 are now in production and becoming a widespread mature technology on many on-road automotive and off-road vehicle applications. However, during the development phase of these systems, several drawbacks to the use of AUS-32 as the SCR reductant carrier were encountered, including component damage due to corrosion and freezing, as well as the unwanted spread of urea crystals which can be troublesome for vehicle electrical systems.
Aqueous guanidinium formate (GuFo) solutions have been identified as an alternative reductant carrier for SCR systems. In addition to potentially addressing these drawbacks of AUS-32, GuFo also could provide advantages in reductant carrier density and in certain configurations, overall SCR deNOx efficiency.
Testing was conducted to evaluate the compatibility of injection component technologies to guanidinium formate solutions. This paper presents the results of tests investigating corrosion resistance, freezing behavior, and injection spray quality performance with respect to AUS-32. A significant reduction in risk of corrosive attack was documented. Also, the freezing behavior of GuFo was shown to theoretically eliminate the risk of damage to system components due to expansion at phase change. Room temperature spray quality with certain sprays was reduced with GuFo. However, the spray structure improvements associated with flash boiling were documented and the concept of heated tip injection with GuFo solutions was introduced and its initial feasibility was demonstrated.
Recommended Content
Authors
Topic
Citation
van Vuuren, N., "Initial Evaluations of Injector Compatibility with an Alternative SCR Reductant Carrier - Guanidinium Formate," SAE Technical Paper 2014-01-1532, 2014, https://doi.org/10.4271/2014-01-1532.Also In
References
- Koebel , M. , Elsener , M. , and Kleemann , M. Urea-SCR: A promising technique to reduce NOx emissions from automotive diesel engines Catalysis Today 335 345 2000
- Kroecher , O. , Elsener , M. , Jacob , E. Neue Reduktionsmittel fuer die Low NOx-SCR-Technik 5th International Exhaust Gas and Particulate Emissions Forum 19 20 February 2008 Ludwigsburg (Germany)
- Toshev , P. Sattelmayer , T. Reactor for the Conversion of Aqueous Guanidinium Formate (GuFo) to Ammonia MinNOx 3 rd International Conference June 29 30 2010 Berlin (Germany)
- Gerhart , C. , Krimmer , H. , Hammer , B. , Schulz , B. et al. Development of a 3rd Generation SCR NH3-Direct Dosing System for Highly Efficient DeNOx SAE Int. J. Engines 5 3 938 946 2012 10.4271/2012-01-1078
- Schaber , P. , Colson , J. , Higgins , S. , Dietz , E. , Thielen , D. , Anspach , B. , and Brauer , J. Study of the urea thermal decomposition (pyrolysis) reaction and importance to cyanuric acid production American Laboratory August 1999 13 21
- Schaber , P. , Colson , J. , Higgins , S. , Thielen , D. , Anspach , B. , Brauer , J. Thermal Decomposition (Pyrolysis) of Urea in an Open Reactor Vessel Thermochimica Acta 424 131 142 2004
- Lefebvre , A. Atomization and Sprays USA Taylor and Francis 1989
- van Vuuren , N. and Qin , J. High Speed Video Measurements with Water of a Planar Laser Illuminated Heated Tip Urea Injector Spray SAE Technical Paper 2013-01-1073 2013 10.4271/2013-01-1073
- van Vuuren , N. High Speed Video Measurements of a High Temperature Urea Injector Spray - Comparison of Spray Evolution in Water and AUS-32 SAE Technical Paper 2013-01-2527 2013 10.4271/2013-01-2527