This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Improved Distribution of Temperature inside Semitransparent Heat-Insulating Coatings of Combustion Chamber
Technical Paper
2009-24-0003
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
The paper considers the radiative heat exchange under intensive short (radiant flux of red-hot soot particles) and long (radiation of“hot" hydrocarbonic atmosphere) IR components of total thermal flux in the combustion chamber (CC) of high-speed diesel engines. The analysis is conducted for only one spectral band in the ceramic coating and is assumed to be without any soot layer on it for this preliminary investigation. Temperature distributions are calculated for two layer coating. It consists of a top layer based on the semitransparent heat-insulating coating (SHIC) with varios thickness and a bottom one (semitransparent or opaque which could be metal substrate) with variation of reflection for transient (one complete cycle of piston movement) and steady state (cyclic heating). The improved distributions of temperature due to volumetric radiant heat losses inside semitransparent and opaque heat-insulating coatings are discussed. Subsurface temperature maximum under cycle radiant-convectional heat fluxes in CC of diesel analyzed. It is shown that semitransparent coatings can accumulate penetrating radiant heat of the total thermal flux during the “hot” phase (the combustion of fuel blend) and then act as a heat source in the rest of the cycle.
Recommended Content
Authors
Topic
Citation
Sidorov, O., Merzlikin, V., Cheranev, S., and Koegler, H., "Improved Distribution of Temperature inside Semitransparent Heat-Insulating Coatings of Combustion Chamber," SAE Technical Paper 2009-24-0003, 2009, https://doi.org/10.4271/2009-24-0003.Also In
References
- Kavtaradze R.Z. Local Heat Transfer in the Piston Engines Bauman MGTU 2001
- Rakopoulos C. D. Giakoumis E. G. Diesel Engine Transient Operation. Principles of Operation and Simulation Analysis 978-1-84882-375-4 Springer-Verlag London Limited 2009
- Novitski L. A. Optical Properties of Materials in Low Temperatures Mashinostroyenye 1980
- Makino, T. Kunitomo, T. Sakai I. Kinoshita, H. Heat Transfer. Jpn. Res. 1984 No 13 33
- Merzlikin, V. Sidorov O. Gutierrez Ojeda M. Study of Optical Parameters of Semitransparent Materials for Heat-Insulating Coatings of Combustion Chamber 8th Int. Conference on Engines for Automobile - ICE2007 16 September 2007 Capri, Napoly
- Manara J. Arduini-Schuster M. Rätzer-Scheibe H.-J. Schulz U. Infrared-optical properties and heat transfer coefficients of semitransparent thermal barrier coatings Surface and Coatings Technology 2009 Vol. 203 Issue 8 15 January 1059 1068
- Whahiduzaman S. Morel T. Effects of Ceramics Translucence on Heat Barrier Effectiveness in Diesel Engines SAE Tech. Pap. Ser. 1989
- Siegel. R. Internal Radiation Effects in Zirconia Thermal Barrier Coatings AIAA J. Thermophysics Heat Trans. 1996 Vol. 10 no. 4 707 709
- Merzlikin V. Gutierrez Ojeda M. Sidorov O. Timonin V. New Selectively Absorbing and Scattering Heat-Insulating Coatings of the Combustion Chamber for the Low-Heat-Rejection Diesel SAE. Techn. Pap. Ser 2007
- Boeringer J. C Spindler R. J. Radiant heating of semitransparent materials AAIA Journal 1963 Vol. 1 No 1 84 88
- Tovstonog V.A. Merzlikin V.G. Mosolov F.F. Problem Statement and Solution Radiative Conductive Heat Exchange for Multilayered Scattering Media Russia. Vestnik Baumana. Mashinostroyenye 2008 No 2 12 27
- Merzlikin V. Timonin V. Tovstonog V. Multilayered Semitransparent and Opaque Heat-Insulating Coatings for Diesel Combustion Chamber 9th International Conference on Engines and Vehicles. -ICE2009 14–19 September 2009 Capri, Napoly