This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Development of a Control Strategy for Complex Light-Duty Diesel-Hybrid Powertrains
Technical Paper
2011-24-0076
ISSN: 0148-7191, e-ISSN: 2688-3627
This content contains downloadable datasets
Annotation ability available
Sector:
Language:
English
Abstract
Hybrid Electric Vehicles (HEVs) represent a powerful technology
to save fuel and reduce CO₂ emissions, through the synergic use of
a conventional internal combustion engine and one or more electric
machines. However their performance strongly depends on the control
strategy that shares the power demand among the engine and the
electric motors at each time instant, with the objective of
minimizing a pre-defined cost function over an entire driving
cycle, and satisfying, at the same time, any additional
constraints.
The aim of this work is therefore the definition of a
methodology to develop, through numerical simulation, a sub-optimal
hybrid powertrain controller: starting from the problem definition,
the ideal performance for a case study hybrid architecture was
analyzed through a global optimization algorithm in order to point
out information which can be used to define new control laws.
Coupling this information with an approach based on the
instantaneous minimization of a cost function, a sub-optimal energy
management system was then developed trying to merge the strength
of global optimization algorithm with the low computational
requirements of heuristic strategies.
Finally, the powertrain controller previously developed was
implemented in a detailed vehicle model and tested through
numerical simulations over different driving cycles in order to
compare its performance with the upper bound set by the results
achieved by the global optimization algorithm.
Authors
Topic
Citation
Millo, F., Rolando, L., and Servetto, E., "Development of a Control Strategy for Complex Light-Duty Diesel-Hybrid Powertrains," SAE Technical Paper 2011-24-0076, 2011, https://doi.org/10.4271/2011-24-0076.Data Sets - Support Documents
Title | Description | Download |
---|---|---|
Unnamed Dataset 1 | ||
Unnamed Dataset 2 |
Also In
References
- Cisternino, M. Paladini, V. Cipolla, G. Millo, F. Badami, M. Mafrici, G. Rizzoni, G. Miotti, G. “From Micro to Full, exploiting the benefits of different degrees of hybridization in a flexible hybrid architecture” International AVL Engine & Environment Conference Graz, Austria 2007
- Blumenroder, K. Bunar, F. Buschmann, G. Nietschke, W. Predelli, O. “Diesel and Hybrid: Contradiction or Appropriate Alternative?” 28 th Internationales Wiener Motoren-Symposium Wien, Austria 2007
- European Parliament “Reducing CO 2 emissions from new cars” 2006 Progress report on the car industry's voluntary commitment September 2007
- Guzzella, L. Sciarretta, A. “Vehicle Propulsion System: Introduction to Modeling and Optimization” Springer 3-540-25195-2 2005
- Cooper, B. Bar, F. Beasly, M. Penny, I. “The Challenge of CO 2 and Emissions Targets for Diesel Engines: Can Both Be Combined?” 9 th Stuttgart International Symposium Automotive and Engine Technology Stuttgart, Germany March 24 25 2007
- Millo, F. Badami, M. Ferraro, C. Lavarino, G. et al. “A Comparison Between Different Hybrid Powertrain Solutions for an European Mid-Size Passenger Car,” SAE Technical Paper 2010-01-0818 2010 10.4271/2010-01-0818
- European Parliament “Dir. 1970-220” 2007
- Lin, C.C. Peng, H. Grizzle, J.W. Kang, J. “Power Management Strategy for a Parallel Hybrid Electric Truck” IEEE Transactions on Control Systems Technology 11 6 2003
- Bianchi, D. Rolando, L. Serrao, L. Onori, S. Rizzoni, G. Al-Khayat, N. Hsieh, T. Kang, P. “A rule-based strategies for a series-parallel hybrid electric vehicle: an approach based on Dynamic Programming” ASME Dynamic Systems and Control Conference Cambridge, Massachusetts September 13 15 2010
- Bianchi, D. Rolando, L. Serrao, L. Onori, S. Rizzoni, G. Al-Khayat, N. Hsieh, T. Kang, P. “Layered Control Strategies for Hybrid Electric Vehicles Based on Optimal Control,” International Journal of Electric and Hybrid Vehicles 2011
- Morbitzer, J. “High-level modeling, supervisory control strategy development and validation for a proposed power-split hybrid-electric vehicle design” Master Thesis The Ohio State University Columbus, Ohio, United States 2005
- Serrao, L. “A Comparative Analysis of Energy Management Strategies for Hybrid Electric Vehicle” PhD thesis The Ohio State University Columbus, Ohio, United States 2009
- Lewis, F.L. Syrmos, V.L. “Optimal Control” Wiley-Interscience 1995
- Sundström, O. Guzzella, L. “A Generic Dynamic Programming Matlab Function” Proceedings of the 18 th IEEE International Conference on Control Applications 1625 1630 2009
- Paganelli, G. Ercole, G. Brahma, A. Guezennec, Y. Rizzoni, G. “General supervisory control policy for the energy optimization of charge-sustaining hybrid electric vehicle” JSAE Review 22 4 511 518 2001
- Paganelli, G. Delprat, S. Guerra, T.M. Rimaux, J. Santin, J.J. “Equivalent consumption minimization strategy for parallel hybrid” IEEE Veh. Technol. Conf 4 2076 2081 2002
- Sciarretta, A. Guzzella, L. “Control of hybrid electric vehicles” IEEE Control Systems Magazine 60 70 April 2007
- Serrao, L. Onori, S. Rizzoni, G. “ECMS as a Realization of Pontryagin's Minimum Principle for HEV Control,” Proceedings of the 2009 American Control Conference 2009
- Musardo, C. Rizzoni, G. Guezennec, Y. Staccia, B. “A-ECMS: An adaptive algorithm for hybrid electric vehicle energy management.” European Journal of Control 11 509 524 2005
- Sciarretta, A. Back, M. Guzzella, L. “Optimal control of parallel hybrid electric vehicle.” IEEE Transactions on Control Systems Technology 12 352 363 2004
- Staccia, B. Musardo, C. “Energy management strategies for hybrid electric vehicle” Master Thesis Politecnico di Milano Milano Italy 2003
- Musardo, C. Staccia, B. Midlam-Mohler, S. Guezennec, Y. Rizzoni, G. “Supervisory Control for NOx Reduction of an HEV with a Mixed-Mode HCCI/CIDI Engine” American Control Conference Portland, Oregon, United States June 8 10 2005
- Sagha, H. Shahrokh, F. Behzad, A. “Modeling and Design of a NOx Emission Reduction.” the 35th Annual Conference of IEEE November 3 5 Porto, Portugal 2009
- Peugeot “3008 H4 Press Review” http://www.peugeot.com/en/products/cars/3008hybrid4.aspx 2011
- Millo, F. Badami, M. Ferraro, C. Rolando, L. “Different Hybrid Powertrain Solutions for European Diesel passenger cars,” SAE Int. J. Engines 2 2 493 504 2010 10.4271/2009-24-0064
- Suckow, S. “Status and Trends for Li-Ion Battery Technologies for Automotive Applications,” 2009 SAE Symposium Facing the Challenge of CO2 targets Turin, Italy June 2009
- GAMMA TECHNOLOGY 2009 GT-Suite User Manuals Chicago, United States
- Ciesla, C. Keribar, R. Morel, T. “Engine/Powertrain/Vehicle Modeling Tool Applicable to All Stages of the Design Process,” SAE Technical Paper 2000-01-0934 2000 10.4271/2000-01-0934
- Morel, T. Keribar, R. Leonard, A. “Virtual Engine/Powertrain/Vehicle Simulation Tool Solves Complex Interacting System Issues” 2006
- Cipolla, G. Mallamo, F. Paladini, V. Vassallo, A. Millo, F. Mafrici, G. “Transient Correction of Diesel Engine Steady-State Emissions and Fuel Consumption Maps for Vehicle Performance Simulation” 16 th Aachener Kolloquium Fahrzeug und Motorentechnik Aachen, Germany 2007
- INRETS - Institut National de Recherche sur les Transports et leur Securite “Real-world driving cycles for measuring cars pollutant missions - Part A: The ARTEMIS European driving cycles” Report INRETS-LTE 0411 June 2004