This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Hydraulic Hybrid Powertrain-In-the-Loop Integration for Analyzing Real-World Fuel Economy and Emissions Improvements
Technical Paper
2011-01-2275
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
The paper describes the approach, addresses integration challenges and discusses capabilities of the Hybrid Powertrain-in-the-Loop (H-PIL) facility for the series/hydrostatic hydraulic hybrid system. We describe the simulation of the open-loop and closed-loop hydraulic hybrid systems in H-PIL and its use for concurrent engineering and development of advanced supervisory strategies. The configuration of the hydraulic-hybrid system and details of the hydraulic circuit developed for the H-PIL integration are presented. Next, software and hardware interfaces between the real components and virtual systems are developed, and special attention is given to linking component-level controllers and system-level supervisory control. The H-PIL setup allows imposing realistic dynamic loads on hydraulic pump/motors and accumulator based on vehicle driving schedule. Application of fast analyzers allows characterization of the impact of dynamic interactions in the propulsion system on engine-out emissions. Therefore, the H-PIL facility allows optimization of the hybrid system for both high-efficiency and low emissions. The impetus is provided by previous work showing that more than half of the soot emissions from a conventional diesel powertrain over the urban driving schedule can be attributed to transients. The setup includes a 6.4L V-8 International diesel engine, highly dynamic dynamometer, Radial piston pump/motors supplied by Bosch-Rexroth and dSPACE real-time environment with in-house developed simulation of the virtual vehicle.
Recommended Content
Authors
Topic
Citation
Tavares, F., Johri, R., Salvi, A., Baseley, S. et al., "Hydraulic Hybrid Powertrain-In-the-Loop Integration for Analyzing Real-World Fuel Economy and Emissions Improvements," SAE Technical Paper 2011-01-2275, 2011, https://doi.org/10.4271/2011-01-2275.Also In
References
- Kim, Y. Filipi, Z. “Series Hydraulic Hybrid Propulsion for a Light Truck - Optimizing the Thermostatic Power Management,” SAE Technical Paper 2007-24-0080 SAE Transactions, Journal of Engines 116 2007
- Kim, Y. Filipi, Z. “Simulation Study of a Series Hydraulic Hybrid Propulsion System for a Light Truck,” SAE Technical Paper 2007-01-4151 SAE Transactions, Journal of Commercial Vehicles 116 2007
- Filipi, Z Kim, Y J “Hydraulic Hybrid Propulsion for Heavy Vehicles: Combining the Simulation and Engine-In-the-Loop Techniques to Maximize the Fuel Economy and Emission Benefits,” Oil & Gas Science & Technology 65 1 155 178 2010
- Wu, B. Lin, C. C. Filipi, Z. Peng, H. Assanis, D. “Optimal power management for a hydraulic hybrid delivery truck,” Vehicle System Dynamics 42 1-2 23 40 2004
- Filipi, Z. Louca, L. Daran, B. Lin, C.-C. Yildir, U. Wu, B. Kokkolaras, M. Assanis, D. Peng, H. Papalambros, P. Stein, J. Szkubiel, D. Chapp, R. “Combined optimisation of design and power management of the hydraulic hybrid propulsion system for the 6 × 6 medium truck,” International Journal of Heavy Vehicle Systems 11 3-4 372 402 2004
- Lin, C. C. Peng, H. Grizzle, J.W. Kang, J. “Power management strategy for a parallel hybrid electric truck,” IEEE Transactions on Control Systems Technology 11 6 839 49 2003
- Samulski, M. Jackson, C. “Effects of Steady-State and Transient Operation on Exhaust Emissions from Nonroad and Highway Diesel Engines,” SAE Technical Paper 982044 1998 10.4271/982044
- Filipi, Z Hagena, J Fathy, H “Investigating the impact of in-vehicle transients on diesel soot emissions,” Thermal Science 12 53 72 2008
- Hagena, J. Filipi, Z. Assanis, D. “Transient Diesel Emissions: Analysis of Engine Operation During a Tip-In,” SAE Technical Paper 2006-01-1151 2006 10.4271/2006-01-1151
- Kirchen, P. Obrecht, P. Boulouchos, K. “Soot Emission Measurements and Validation of a Mean Value Soot Model for Common-Rail Diesel Engines during Transient Operation,” SAE Technical Paper 2009-01-1904 SAE Int. J. Engines 2 2009
- Rakopoulos, C.D. Dimaratos, A.M. Giakoumis, E.G. Rakopoulos, D.C. “Evaluation of the effect of engine, load and turbocharger parameters on transient emissions of diesel engine,” Energy Conversion & Management 50 9 2381 2393 2009
- Filipi, Z. Hagena, J. Fathy, H. “Investigating the impact of in-vehicle transients on diesel soot emissions,” Thermal Science 12 1 53 72 2008
- Assanis, D. Filipi, Z. Gravante, S. Grohnke, D. et al. “Validation and Use of SIMULINK Integrated, High Fidelity, Engine-In-Vehicle Simulation of the International Class VI Truck,” SAE Technical Paper 2000-01-0288 SAE Transactions: Journal of Engines 109 2000
- Lin, C. Filipi, Z. Wang, Y. Louca, L. et al. “Integrated, Feed-Forward Hybrid Electric Vehicle Simulation in SIMULINK and its Use for Power Management Studies,” SAE Technical Paper 2001-01-1334 2001 10.4271/2001-01-1334
- Kong, S. C. Rutland, C. J. Reitz, R. D. “Development of an Integrated Spray and Combustion Model for Diesel Simulations,” Thermo- and Fluid-Dynamic Processes in Diesel Engines Whitelaw, J. H. Payri, F. Desantes, J. M. 319 334 Springer New York 2002
- Hong, S. Assanis, D. Wooldridge, M. “Multi-Dimensional Modeling of NO and Soot Emissions with Detailed Chemistry and Mixing in a Direct Injection Natural Gas Engine,” SAE Technical Paper 2002-01-1112 2002 10.4271/2002-01-1112
- Filipi, Z. Fathy, H. Hagena, J. Knafl, A. et al. “Engine-in-the-Loop Testing for Evaluating Hybrid Propulsion Concepts and Transient Emissions - HMMWV Case Study,” SAE Technical Paper 2006-01-0443 SAE Transactions, Journal of Commercial Vehicles 115 2006
- Fathy, H. K. Ahlawat, R. Stein, J. L. “Proper powertrain modeling for engine-in-the-loop simulation,” American Society of Mechanical Engineers, Dynamic Systems and Control Division 74 1195 1201 2005
- Louca, L. S. Yildir, B. U. “Modelling and reduction techniques for studies of integrated hybrid vehicle systems,” Mathematical and Computer Modelling of Dynamical Systems 12 203 218 2006
- Johri, R. Salvi, A. Filipi, Z. “Optimal Energy Management for a Hybrid Vehicle Using Neuro-Dynamic Programming to Consider Transient Engine Operation,” Proc. of 4th Annual Dynamic Systems and Control Conference 2011
- Johri, R. Filipi, Z. “Self-Learning Neural controller for Hybrid Power Management using Neuro-Dynamic Programming,” SAE Technical Paper 2011-24-0081 2011
- Reavell, K. Hands, T. Collings, N. “A Fast Response Particulate Spectrometer for Combustion Aerosols,” SAE Technical Paper 2002-01-2714 2002 10.4271/2002-01-2714