This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
The Influence of Block Heaters on the Emissions from Gasoline Fueled Cars with Varying Emission Control Technology at Low Ambient Temperatures
Annotation ability available
Sector:
Language:
English
Abstract
The introduction of the three way catalyst (TWC) has considerably reduced emissions from gasoline fueled cars. Most of the pollutants from these cars are emitted during the cold start period. At lower ambient temperatures (below +20°C), as in the Northern part of Europe, these emissions increase considerably. In Sweden engine block heaters, mostly in combination with compartment heaters, are often used to increase the driver's comfort. The increased engine temperature also reduces emissions. Block heaters are also suitable for after-market installations, and can thus reduce emissions from in-use cars. This paper reports the investigations of the effects of a block heater on emissions and fuel consumption. It was decided to conduct tests on three types of light duty vehicles: cars with TWC, cars without TWC, and one car with very low emissions (i.e. TLEV). The cars were tested according to the FTP-75 test procedure at +22, +5 and -15°C ambient temperature.
The test results showed substantial reductions of emissions for all cars with a block heater, at low ambient temperature. The reduction of CO and HC emissions in FTP-75 can be more than 80% for some cars. The relative reduction was less for older cars without a catalyst, but the absolute reduction was about the same as for TWC cars. NOx emissions were less affected and even increased marginally in some cases. The results also showed considerable reductions in particulate emissions at the lowest ambient temperature. The fuel consumption for the vehicle and the energy consumed by the block heater was measured and it was found that the preheat time for the heater could be optimized to minimize the total energy consumption. Some further optimizations and future development of this technology were also discussed.
Recommended Content
Authors
Topic
Citation
Ahlvik, P., Erlandsson, L., and Laveskog, A., "The Influence of Block Heaters on the Emissions from Gasoline Fueled Cars with Varying Emission Control Technology at Low Ambient Temperatures," SAE Technical Paper 970747, 1997, https://doi.org/10.4271/970747.Also In
References
- The Swedish Environmental Protection Agency (SEPA) 1993
- Banverket Luftfartsverket Sjöfartsverket Vägverket 1994
- Banverket Luftfartsverket Sjöfartsverket Vägverket 1995
- Luftfartsverket 1994
- Vägverket 1995
- Vagverket 1995
- Laveskog A. Emissions from Catalyst Cars Outside Regulated Test Cycles MTC Report MTC 9001 1990
- Laveskog A Hedbom A. Kutscher E. Emissions at Regulated and Non Regulated Test Conditions MTC Report MTC 9227 1992
- Ahlvik P. Influence of Engine Block Heaters on Cold Start Emissions and Fuel Consumption MTC Report MTC 9618 1996
- Laurikko J. Erlandsson L. Abrahamsson R. Exhaust Emissions in Cold Ambient Conditions: Considerations for a European Test Procedure SAE paper 950929 1995
- Kutscher E. Light Duty Trucks and City Vehicles MTC Report MTC 9503 1996
- Abrahamsson R. Blomroos M. Laveskog A. Cold Climate Emissions MTC Report MTC 9320 1993
- Organisation for Economic Cooperation and Development (OECD) Choosing an Alternative Transportation Fuel OECD Paris 1993
- Hedbom A MTC Report MTC 9217 1992
- Almén J. Scrutinizing of Standardized Testing Conditions MTC Report MTC 9310 1996
- Laveskog A. Sander O. Comparison of Emissions and Fuel Consumption from 1.2 and 1.4 I Opel Corsa at Different Temperatures, Test Cycles and Load Conditions MTC Report MTC 9401
- International Energy Agency (IEA) Cars and Climate Change OECD Paris 1993