This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Rapid Deactivation of Lean-Burn Natural Gas Engine Exhaust Oxidation Catalysts
Annotation ability available
Sector:
Language:
English
Abstract
Methane emissions from lean-burn natural gas engines can be relatively high. As natural gas fueled vehicles become more prevalent, future regulations may restrict these emissions. Preliminary reports indicated that conventional, precious metal oxidation catalysts rapidly deactivate (in less than 50 hours) in lean-burn natural gas engine exhaust. This investigation is directed at quantifying this catalyst deactivation and understanding its cause. The results may also be relevant to oxidation of lean-burn propane and gasoline engine exhaust. A platinum/palladium on alumina catalyst and a palladium on alumina catalyst were aged in the exhaust of a lean-burn natural gas engine (Cummins B5.9G). The engine was fueled with compressed natural gas. Catalyst aging was accomplished through a series of steady state cycles and heavy-duty transient tests (CFR 40 Part 86 Subpart N) lasting 10 hours. Hydrocarbons in the exhaust were speciated by gas chromatography. Catalysts were compared on the basis of conversion and first order rate constants for conversion of specific hydrocarbon species. CO and ethylene conversions were nearly 100% at all conditions and did not decrease over time. Steady state and transient data show significant catalyst deactivation for methane oxidation over both catalysts tested. The global rate constant for methane conversions declined by more than 60% over the 10 hour experiment. Rate constants for ethane and propane oxidation declined by roughly 40 and 20%, respectively. No decrease in activity was observed for heavier hydrocarbons but their concentration in the fuel and in the exhaust was very low. Preliminary characterization of both the fresh and used catalysts was performed by x-ray diffraction, Auger electron spectroscopy, and x-ray photoelectron spectroscopy. XRD indicated no bulk structural changes in the catalysts. Auger electron spectra indicate the presence of only PdO in the fresh catalyst but two distinct chemical forms of Pd in the used catalyst samples. Auger also indicated the presence of a phosphate coating on the monolith external surface. XPS confirmed the presence of reduced pd in the aged samples.
Recommended Content
Authors
Citation
McCormick, R., Newlin, A., Mowery, D., Graboski, M. et al., "Rapid Deactivation of Lean-Burn Natural Gas Engine Exhaust Oxidation Catalysts," SAE Technical Paper 961976, 1996, https://doi.org/10.4271/961976.Also In
References
- Graboski, M.S. McCormick, R.L. “Effect of Fuel Composition on Regulated Emissions From A Lean-Burn, Closed Loop Controlled Natural Gas Engine at High Altitude” Final Report, Report No. GRI-96/0095 March 1996
- Daniels, T.L. McCormick, R.L. Graboski, M.S. Carlson, P. Rao, V. Rice, G. W. “The Effect of Diesel Sulfur Content and Oxidation Catalysts on Transient Emissions at High Altitude from a 1995 Detroit Diesel Series 50 Urban Bus Engine” SAE Technical Paper No. 961974 1996
- Cullis, C.F. Willat, B.M. “Oxidation of Methane over Supported Precious Metal Catalysts” J. Catal. 83 267 285 1983
- Oh, S.H. Mitchell, P.J. Siewert, R.M. “Methane Oxidation over Alumina-Supported Noble Metal Catalysts with and without Cerium Additives” J. Catal. 132 287 301 1991
- Otto, K. “Methane Oxidation over Pt on γ-Alumina: Kinetics and Structure Sensitivity” Langmuir 5 1364 1369 1989
- Subramanian, S. Kudla, R.J. Chattha, M. S. “Removal of Methane from Compressed Natural Gas Fueled Vehicle Exhaust” Ind. Eng. Chem. Res. 31 2460 2465 1992
- McCabe, R. W. McCready, D.F. Chem. Phys. Lett. 111 89 1984
- Sharp, C.A. others SAE Technical Paper No. 932819 1993
- Hicks, R.F. Qi, H. Young, M.L. Lee, R. G. “Structure Sensitivity of Methane Oxidation over Platinum and Palladium” J. Catal. 122 280 294 1990
- Hicks, R.F. Qi, H. Young, M.L. Lee, R. G. “Effect of Catalyst Structure on Methane Oxidation over Palladium on Alumina” J. Catal. 122 295 306 1990
- Farrauto, R.J. Hobson, M.C. Kennelly, T. Waterman, E.M. “Catalytic Chemistry of Supported Palladium for Combustion of Methane” Appl. Catal. A: General 81 227 237 1992
- Farrauto, R.J. April 12 1994
- Graboski, M.S. Ross J.D. McCormick R.L. “Transient Emissions From No. 2 Diesel and Biodiesel Blends in a DDC Series 60 Engine” SAE Technical Paper No. 961166 1996
- Heck, R.M. Farrauto, R.J. Catalytic Air Pollution Control Van Nostrand Reinhold New York 1995
- Anderson, R.B. Stein, K.C. Feenan, J.J. Hofer, L.J.E. “Catalytic Oxidation of Methane” Ind. Eng. Chem. 53 809 812 1961
- Ribeiro, F.H. Chow, M. Dalla Betta, R.A. “Kinetics of the Complete Oxidation of Methane over Supported Palladium Catalysts” J. Catal. 146 537 544 1994
- Burch, R. Urbano, F.J. Loader, P.K. “Methane Combustion Over Palladium Catalysts: The effect of carbon dioxide and water on activity” Appl. Catal. A: General 123 173 184 1995
- Burch, R Loader, P.K. “Investigation of Methane Oxidation on Pt/AI2O3 Catalysts under Transient Reaction Conditions” Appl. Catalysis B: Environmental 5 169 90 1995
- Lampert, J.K. Kazi, M.S. Farrauto, R.J. “Methane Emissions Abatement From Lean Burn Natural Gas Engine Exhaust: Sulfur's Impact on Catalyst Performance” SAE Technical paper No. 961971 1996
- Mowery, D. McCormick, R.L. Graboski, M.S.