This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Seat Belt Buckle Release Force: Cause for Entrapment?
Annotation ability available
Sector:
Language:
English
Abstract
This study was concerned with buckle release resistance under full load. Although the incidence of entrpament among restrained occupants in rollover accidents is extremely low, there is concern that inability to release the buckle contributes to entrapment in the vehicle. The purpose of the present study was to assess the adequacy of current safety regulations in this regard. Human strength measurements were obtained from male and female driver volunteers using top-release and side-release buckles. The strength data obtained in this study indicate that about 80% of drivers are not capable of exerting a force on the buckle equivalent to the mandated limit of 133N (30 lb). Taking into account the influence of loop load on buckle resistance, over 90% of drivers would be expected not to be able to release a buckle which marginally meets current regulations. While it would appear that existing buckles release at lower forces than specified in the standard, still about 40% of drivers would not be able to release their own belts. Strength was influenced primarily by gender - driver age and weight had negligible effects. Contrary to a priori expectations, no significant differences were observed between side-release and top-release type buckles.
Recommended Content
| Technical Paper | The Influence of Belt tension on Buckle Response During Car Crash |
| Technical Paper | NHTSA's Frontal Offset Research Program |
| Technical Paper | Automobile Crash Research |
Authors
Citation
Noy, Y., "Seat Belt Buckle Release Force: Cause for Entrapment?," SAE Technical Paper 930342, 1993, https://doi.org/10.4271/930342.Also In
References
- Arnber, P.W. 1976 Child Restraint Systems: Measurement of Opening Force Requirements of Buckles Exposed to Loads of 60-200 N National Swedish Road and Traffic Research Institute (VTI) VTI Rapport 89A
- Dalmotas, D. Krzyzewski, J. Restraint System Effectiveness as a Function of Seating Position Paper 870489 Restraint Technologies: Rear Seat Occupant Protection SAE SP-691 1987 75 95
- Dance, M. 1991 personal communication
- Farr, G. Seat Belt Buckle Release Force: An Update August 1983
- Ontario Ministry of Transportation 1989 Ontario Road Safety Annual Report
- Stoudt, H.W. Damon, A. McFarland, R.A. Roberts, J. Weight. Height and Selected Body Dimensions of Adults. United States. 1960-1962 Report No. 8 11 June 1965 National Center for Health Statistics U.S. Dept. of Health, Education and Welfare Washington, D.C.
- Transport Canada, Motor Vehicle Safety Act and Regulations, Section 209, subsection 20(a) April 1989
- Van Cott, H.P. Kinkade, R.G. 1972 Human Engineering Guide to Equipment Design U.S. Government Printing Office Washington D.C. 549