This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Technology Demonstration of U.S. Army Methanol-Fueled Administrative Vehicles
Annotation ability available
Sector:
Language:
English
Abstract
A technology demonstration program using modified administrative-type vehicles was conducted by the Army to determine the feasibility of using methanol as an alternative fuel. Over 1,026,000 miles (1,651,190 km) were accumulated using 64 sedan and pickup vehicles. Approximately 750,000 of these miles (1,207,010 km) were accumulated using M85 methanol fuel. Using M85 increases the fuel cost by a factor of approximately 3.0. No catastrophic engine failure occurred with the use of the M85 fuel. Even though wear rates, indicated from used oil samples analyses, obtained when using M85 fuel appear to be 2 to 4 times those obtained using unleaded gasoline, actual wear, from inspections and measurements, does not appear to be as severe. M85 refueling stations were set up at four fleet test sites, and no significant operational or safety problem was encountered during the program. Recommendations are made for M85 fuel, its storage/distribution requirements, and engine lubricants suitable for use in any future program.
Authors
Citation
Baber, B., Lestz, S., and LePera, M., "Technology Demonstration of U.S. Army Methanol-Fueled Administrative Vehicles," SAE Technical Paper 902158, 1990, https://doi.org/10.4271/902158.Also In
References
- “U.S. Army's Methanol-Fueled Administrative Vehicle Demonstration Program Plan,” Department of the Army (AMCLD/AMSLC) November 1986
- Baber B.B. Lestz S.J. LePera M.E. “Final Report on U.S. Army Methanol-Fueled Administrative Vehicle Demonstration Program,” Interim Report BFLRF No. 233 A216013 San Antonio, Texas August 1989
- Bryant J.A. et al. “U.S. Army-Methanol-Fueled Vehicle Evaluation Program, Phase I and II Final Report,” Jet Propulsion Laboratory Report JPL D-4415 May 1987
- “1.6 L Methanol Escort,” Reference and Training Book Ford Parts and Service Division, Training and Publications Department
- Federal Specification, VV-G-1690C “Gasoline, Automotive, Leaded or Unleaded,” January 13 1982
- U.S. Military Specification Lubricating Oil, Internal Combustion Engine, Administrative Service 26 January 1981
- McGill R.N. et al. “Results from the Second of Operation of the Federal Methanol Fleet at Argonne National Laboratory,” ORNL Report ORNL/TM-11230 Martin Marietta Energy System August 1989
- Bechtold R.L. Timbario T.J. et al. “Operating Experience of a Baltimore, Maryland/USA Fleet Using 90/10 Blend of Methanol/Unleaded Gasoline,”
- Vann L.G. et al. “California's Methanol Fleet Test Experience: Implementation and Lessons Learned,” 1984 Washington Conference on Alcohol November 15-16 1984
- Present D.L. Kohl K.B. “Detailed Chemical Analysis of Fuel Methanol for Trace Impurities,” Interim Report BFLRF No. 216 San Antonio, TX September 1986
- Montemayor A.F. Baber B.B. Owens E.C. “Cold Startability of Methanol-Fueled Chevrolet S-10 Vehicles,” Interim Report BFLRF No. 221 San Antonio, TX December 1986
- “Final Report-Prototype Methanol Pump and Tank Units,” VSE Corp. Report No. VSE/ASG/0178-86/11RD , Contract No. DAAK70-81-D-0109 March 1986
- Baber B.B. “Evaluation of Potential Engine Oils for Use in Administrative Vehicles Operating on M85 Methanol Fuel,” Interim Report BFLRF No. 260 A205635 San Antonio, TX December 1988
- “Alternative Fuels, Information on DOD's Methanol Vehicle Program,” General Accounting Office Report GAO/RCED-87-91 May 1987