This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Preliminary Evaluation of a Membrane Gas Separation Unit for Space Station Freedom Atmosphere Revitalization Subsystem
Annotation ability available
Sector:
Language:
English
Abstract
A study was initiated to investigate the potential of integrating a membrane gas separation unit into the Space Station Atmosphere Revitalization Subsystem to remove inert impurities in the carbon dioxide stream fed to the Bosch reduction reactor. Removal of the inerts eliminates the need for a reactor bleed stream and subsequent treatment. Preliminary calculations indicate that under normal operating conditions, inclusion of the membrane unit reduces Atmosphere Revitalization power consumption and heat rejection by 388 and 300 watts, respectively, and causes only small weight and space penalties to be incurred. According to current cost factors, an annual net savings of $0.76 million (in 1989 dollars) excluding separator hardware costs is realized. Although based on preliminary data and estimates, there appears to be reasons for cautious optimism in the proposed design modification and continuation of the study to obtain more detailed data.
Authors
Citation
Kuse, R., "Preliminary Evaluation of a Membrane Gas Separation Unit for Space Station Freedom Atmosphere Revitalization Subsystem," SAE Technical Paper 891450, 1989, https://doi.org/10.4271/891450.Also In
References
- Anon “Space Station Program Definition and Requirements, ” SSP 30000, Revision G, National Aeronautics and Space Administration, Space Station Program Office Reston, Virginia October 31 1988
- Anon “Environmental Control and Life Support System Architectural Control Document, ” SSP 30262, Rev. B, National Aeronautics and Space Adminstration, Space Station Program Office Reston, Virginia July 30 1988
- Wright R. M. Ruder J. M. Dunn V. B. Hwang K. C. “Development of Design Information for Molecular-Sieve Type Regenerative CO 2 -Removal Systems, ” NASA CR-2277, Contract NAS1-8559, AiResearch Manufacturing Company: Los Angeles California July 1973
- Kay R. personal communication 1989
- Heppner D. B. Hallick T. M. Schubert F. H. “Performance Characterization of a Bosch CO 2 Reduction Subsystem, ” NASA CR-152342, Contract NAS2-10204, Life Systems Cleveland, Ohio February 1980
- Sacco A. Jr. Reid R. c. “Water Limitation in the C-H-O System Over Iron, ” AIChE J. , 25 , 839 ( 1979
- Weber W. F. Bowman W. “Membranes Replacing Other Separation Technologies, ” Chem. Eng. Prog., 81 (11), 23 ( 1986
- Parkinson G. “Membranes Widen Roles in Gas Separations, ” Chem. Eng., 91 (8), 14 ( 1984
- Spillman R. W. “Economics of Gas Separation Membranes, ” Chem. Eng. Prog., 85 (1), 41 ( 1989
- Pope W. M. Stookey D. J. Graham T. E. “Applications of Prism Separators in Natural Gas Service, ” paper presented at the 1984 Panhandle Plains Regional Meeting of the Gas Processors Association, Amarillo, Texas October 1984
- Schell W. J. “Membrane Use/Technology Growing, ” Hydrocarbon Process., 62 (8), 43 ( 1983
- Gifford R. D. Lucero D. “A Semi-Permeable Membrane System for Carbon Dioxide Control, ” Aerospace Med., 35 , 267 ( 1964
- Hendel F. J. “Gaseous Environment During Space Missions, ” J. Spacecraft and Rockets. 1 , 353 ( 1964
- Arnoldi in W. E. “Regenerative Systems Reexamined, ” D. W. Jenkins Proceedings of the Third International Interdisciplinary Conference, Princeton, New Jersey October 1965
- Major C. J. Tock R. W. “Gaseous Diffusion Cells, ” in Atmosphere in Space Cabins and Closed Environments , Kammermeyer K. New York 1966
- Stern S. A. “Gas Permeation Processes, ” in Industrial Processing with Membranes , Lacey R. E. Loeb S. New York 1972
- Wijmans J. G. Baker R. W. Dang L. T. “Removal of Carbon Dioxide from Spacecraft Atmosphere by Selective Membranes, ” Contract NAS9-17572, Membrane Technology and Research, Inc Menlo Park, California September 8 1986
- Noble L. “Refurbishment of One Person Regenerative Air Revitalization System: O 2 /CO 2 Separation Techniques Study Report, ” Contract NAS8-36435, Life Systems, Inc Cleveland, Ohio December 20 1988
- Paul D. R. Morel G. “Membrane Technology, ” in Kirk-Othmer Encyclopedia of Chemical Technology , 3rd ed., Vol 15 New York 1981
- Sherwood T. K. Pigford R. L. Wilke C. R. Mass Transfer , pp 43 44 New York 1975
- Koros W. J. “Membranes and Membrane Processes, ” in Encyclopedia of Chemical Processing and Design , McKetta J. J. 29 New York 1988
- Koros W. J. Fleming G. K. Jordan S. M. Kim T. H. Hoehn H. H. “Polymeric Membrane Materials for Solution-Diffusion Based Permeation Separations, ” Prog. Polym. Sci ., 13 , 339 ( 1988
- Stannett V. T. Koros W. J. Paul D. R. Lonsdale H. K. Baker R. W. “Recent Advances in Membrane Science and Technology, ” Adv. Polym. Sci ., 32 , 69 ( 1979
- Bixler H. J. Sweeting O. J. “Barrier Properties of Polymer Films, ” in The Science and Technology of Polymer Films , Volume II Sweeting O. J. New York 1971
- Yasuda H. Stannett V. “Permeability Coefficients, ” in Polymer Handbook , Brandup J. Immergut E. H. New York 1975
- van Amerongen G. J. “Diffusion in Elastomers, ” Rubber Chem. Technol ., 37 , 1065 ( 1965
- Stannett V. “Simple Gases, ” in Diffusion in Polymers , Crank J. Park G. S. New York 1968
- Koros W. J. Paul D. R. “CO 2 Sorption in Poly(ethylene Tere-phthalate) Above and Below the Glass Transition, ” J. Polym. Sci., Polym. Phys. Ed ., 16 , 1947 ( 1978
- Paul D. R. “Gas Sorption and Transport in Glassy Polymers, ” Ber. Bunsenges Phys. Chem ., 83 , 294 ( 1979
- Paul D. R. “Transport Properties of Polymers, ” Am. Chem. Soc. Symp. Ser ., 285 , 253 ( 1985
- O'brien K. C. Koros W. J. Husk G. R. “Influence of Casting and Curing Conditions on Gas Sorption and Transport in Polyimide Films, ” Polym. Eng. Sci ., 27 , 211 ( 1987
- El-Hibri M. J. Paul D. R. “Effects of Uniaxial Drawing and Heat-Treatment on Gas Sorption and Transport in PVC, ” J. Appl. Polym. Sci ., 30 , 3649 ( 1985
- El-Hibri M. J. Paul D. R. “Gas Transport in Poly(vinylidene Flour-ide): Effects of Uniaxial Drawing and Processing Temperature, ” J. Appl. Polym. Sci ., 31 , 2533 ( 1986
- Moe M. Koros W. J. Hoehn H. H. Husk G. R. “Effects of Film History on Gas Transport in a Flourinated Aromatic Polyimide, ” J. Appl. Polvm. Sci ., 36 , 1833 ( 1988
- Koros W. J. Chern R. T. “Separation of Gaseous Mixtures Using Polymer Membranes, ” in Handbook of Separation Process Technology , Rousseau R. W. (Ed.), Wiley-Interscience New York 1987
- Koros W. J. “Simplified Analysis of Gas/Polymer Selective Solubility Behavior, ” J. Polym. Sci. , Polym. Phys. Ed ., 23 , 1611 ( 1985
- Stern S. A. “New Developments in Membrane Processes for Gas Separations, ” paper presented at the 16th Michigan Molecular Institute Meeting Midland, Michigan August 19 22 1984
- Koros W. J. Paul D. R. “Current Aspects of Membrane-based Separation of Gases, ” 16th Michigan Molecular Institute Meeting Midland, Michigan August 19 22 1984
- McCandless F. P. “Separation of Binary Mixtures of CO and H 2 by Permeation Through Polymeric Films, ” Ind. Eng. Chem. , Process Pes. Dev ., 11 , 470 ( 1972
- Antonson G. R. Gardner R. J. King C. F. Ko D. Y. “Analysis of Gas Separation by Permeation in Hollow Fibers, ” Ind. Eng. Chem. , Process Pes. Dev ., 16 , 463 ( 1977
- Pye D. G. Hoehn H. H. Planar M. “Measurement of Gas Permeability of Polymers. I. Permeabilities in Constant Volume/ Variable Pressure Apparatus, ” J. Appl. Polym. Sci ., 20 . 1921 ( 1976
- Pye D. G. Hoehn H. H. Planar M. “Measurement of Gas Permeability of Polymers. II. Apparatus for Determination of Mixed Gases and Vapors, ” J. Appl. Polym. Sci ., 20 , 287 ( 1976
- Chern R. T. Koros W. J. Sanders E. S. Yui R. E. “Second Component Effects in Sorption and Pemeation of Gases in Glassy Polymers, ” J. Membr. Sci. , 15 , 157 ( 1983
- Koros W. J. Story B. J. Jordan s. M. O'brien K. Husk G. R. “Material Selection Considerations for Gas Separation Processes, ” Polym. Eng. Sci. , 27 , 603 ( 1987
- Henis J. M. S. Tripodi M. K. “A Novel Approach to Gas Separations Using Composite Hollow Fiber Membranes, ” Sep. Sci. Technol ., 15 , 1059 ( 1980
- Finken H. “Asymmetric Membranes for Gas Separations, ” Am. Chem. Soc. Symp. Ser. , 269 , 245 ( 1984
- Chern R. T. Koros W. J. Fedkiw P. S. “Simulation of a Hollow Fiber Gas Separator: The Effects of Process and Design Variables, ” Ind. Eng. Chem ., Process Pes. Dev. , 24 , 1015 ( 1985
- Coady A. B. Davis J. A. “CO 2 Recovery by Gas Permeation, ” Chem. Eng. Prog. , 78 (10), 44 ( 1982
- Koros W. J. personal communication 1988
- MacLean D. L. Prince C. E. Chae Y. C. “Energy Saving Modifications in Ammonia Plants, ” Chem. Eng. Prog ., 76 (10), 98 ( 1980
- Bollinger W. A. MacLean D. L. Narayan R. S. “Separation Systems for Oil Refining and Production, ” Chem. Eng. Prog ., 78 .(10), 27 ( 1982
- Dinello M. S. Narayan R. S. Patton C. J. “Bulk CO 2 Removal Achieved Using Membrane Separation, ” SPE paper 13281 presented at the 59th Annual Technical Conference and Exhibition Houston, Texas September 16 19 1984
- Anon “Nitrogen Systems, ” brochure, Permea: St. Louis, Missouri 1987
- Schell W. J. Houston C. D. “Membrane Gas Separations for Chemical Processes and Energy Applications, ” Am. Chem. Soc. Symp. Ser ., 223, 125 ( 1983
- Markiewicz G. “Separex Membrane Systems: The Economical Solution to Gas Treating Problems, ” paper presented at the Gas Processors Association Regional Meeting New Orleans, Louisiana January 21 1988
- Schell W. J. Houston C. D. “Refinery Hydrogen Recovery with Separex Membrane Systems, ” paper presented at the National Petroleum Refiners Association Annual Meeting San Antonio, Texas March 24 26 1985
- Anon “Separex Separation Systems, ” brochure, Air Products: Allentown, Pennsylvania 1986
- Anon “Space Station Program Definition and Requirements, ” SS-SRD-0001, Section 3, Boeing Aerospace Company Huntsville, Alabama September 8 1988
- Rotheram M. A. “Atmospheric Composition Monitor Assembly for Space Station Freedom Environmental Control and Life Support System, ” SAE paper 891451 to be presented at the 19th Intersociety Conference on Environmental Systems San Diego, California July 24 27 1989
- Humphries R. Turner L. Reuter J. Patterson D. “Status of the U. S. Space Station ECLSS and Internal TCS, ” Proceedings of the 3rd European Symposium on Space Thermal Control and Life Support Systems Noordwijk, The Netherlands October 1988
- Kay R. Woodward L. “Space Station Freedom-Carbon Dioxide Removal Assembly, ” SAE paper 891449 to be presented at the 19th Intersociety Conference on Environmental Systems San Diego, California July 24 27 1989
- Ray C. D. Ogle K. Y. Tipps R. W. Carrasquillo R. L. Wieland P. “The Space Station Air Revitalization Subsystem Design Concept, ” SAE paper 871448 presented at the 17th Intersociety Conference on Environmental Systems Seattle, Washington July 13 15 1987
- Fortunate F. A. Burke K. A. “Static Feed Electrolyzer Technology Advancement for Space Application, ” SAE paper 871450 presented at the 17th Intersociety Conference on Environmental Systems Seattle, Washington July 13 15 1987
- Larkins J. T. Kovach A. J. “Static Feed Water Electrolysis System for Space Station O 2 and H 2 Generation, ” SAE paper 851339 presented at the 15th Intersociety Conference on Environmental Systems San Francisco, California July 15 17 1985
- Schubert F. H. Lee M. K. Davenport R. J. Quattrone P. D. “Water Electrolysis System: H 2 and O 2 Generation, ” ASME Publication 78-ENAs-3 presented at the Intersociety Conference on Environmental Systems San Diego, California July 10 13 1978
- Anon “Extravehicular Activity System Architectural Control Document, ” SSP 30256, Rev. B, National Aeronautics and Space Administration, Space Station Program Office Reston, Virginia February 12 1988
- Spina L. Lee M. C. “Comparison of CO 2 Reduction Processes-Bosch and Sabatier, ” SAE paper 851343 presented at the 15th Intersociety Conference on Environmental Systems San Francisco, California July 15 17 1985
- Boyda R. B. personal communication 1989
- Anon “Baseline Configuration Document, ” SSP 30255, Rev. B, National Aeronautics and Space Administration, Space Station Program Office Reston, Virginia April 15 1988
- Leban M. I. Wagner P. A. “Space Station Gaseous Trace Contaminant Load Model Development, ” SAE paper 891513 to be presented at the 19th Intersociety Conference on Environmental Systems San Diego, California July 24 27 1989