This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Simulation of a Hydraulic Pump Control Valve
Annotation ability available
Sector:
Language:
English
Abstract
This paper describes the mode of operation of a control valve assembly that is used with a hydraulic pump. The operating system of the valve is modelled in a simplified form, and an analogy for hydraulic resonance of the pressure sensing system is presented. For the control valve investigated, air entrainment, length and diameter of the resonator neck, and valve mass produced the greatest shift in resonant frequency. Experimental work was conducted on the hydraulic system so that the resonance levels and frequencies could be measured and the accuracy of the theory verified. The results obtained make it possible to evaluate what changes to any of the variables considered would be most effective in driving the second harmonic frequency above the operating range.
Authors
Citation
Molen, G. and Akers, A., "Simulation of a Hydraulic Pump Control Valve," SAE Technical Paper 870807, 1987, https://doi.org/10.4271/870807.Also In
References
- Lee. S. Y. Blackburn J. F. “Contributions to Hydraulic Control 1 Steady-State Axial Forces on Control-Valve Pistons.” Trans. ASM 74 August 1952 1005 1011
- Ainsworth, F. W. “The Effect of Oil-Column Resonance on Hydraulic Valve Squeal.” Trans. ASHE 78 May 1956 773 778
- Ezekiel, F. D. “Effect of Conduit Dynamics on Control Valve Stability.” Trans. ASHE 80 May 1958 904 908
- Stone, J. A. “Discharge Coefficients and Steady-State Flow Farces for Hydraulic Poppet Valves.” J. Basic Eng., Trans. ASHE 82 March 1960 144 154
- Wylie, E. B. “Resonance in Pressurized Piping Systems.” J. Basic Eng., Trans. ASME 87 December 1965 960 966
- Streeter, V. L. Wylie E. B, Hydraulic Transients New York McGraw-Hill, Inc. 1967
- Funk, J. E. Wood D. J. Chao S. P. “The Transient Response of Orifices and Short Lines.” Trans. ASME 94 June 1972 483 491
- Wandling, D. E. Johnson B. L. “Hydraulic Poppet Valve Stability.” SAE Paper 720792 September 1972
- Woods, R. L. “The Effects of Source and Load impedances for Fluid Transmission Line Systems.” Fluid Transmission Line Dynamics Franke M. E. Drzewiecki T. H. New York Dynamic Systems and Control Division, ASME 1981