This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Determination of Individual Aldehyde Concentrations in the Exhaust of a Spark Ignited Engine Fueled by Alcohol/Gasoline Blends
Annotation ability available
Sector:
Language:
English
Abstract
Individual aldehyde (and acetone) emissions were measured from the exhaust gas of a premixed multicylinder spark ignition engine fueled with Indolene and blends of Indolene and either methanol or ethanol. The engine was operated at constant speed (2000 RPM) and MBT spark advance with fuel-air equivalence ratios (Φ) of 0.96, 0.90 and 0.82. During operation at Φ = 0.82, the engine experienced lean-limit misfiring.
The DNPH method with a gas chromatographic finish was employed to obtain exhaust gas concentrations of aldehydes and acetone. Also, the methods used in the past for measuring engine exhaust aldehyde and acetone data were compared to each other and briefly discussed.
Use of the alcohol blends increased the total aldehyde emission level. Formaldehyde was the largest component, exhibiting a continual increase with increasing alcohol blend level. Acetaldehyde, while exhibiting a small decrease with increasing methanol percentage, showed a marked increase when the ethanol blend was used.
Acetone was the only specie measured with the DNPH method that showed a marked increase when the engine was operated in the lean misfire region (Φ = 0.82).
The C3 aldehydes were successfully separated and quantified. It was found that acrolein emissions did not increase when the blends were used; in fact, a slight decrease was observed. Propionaldehyde exhibited a decrease when the methanol blends were used.
Samples taken in the exhaust manifold, upstream of an oxidizing catalyst, and downstream of the catalyst, indicated that aldehydes and acetone are partially destroyed in the exhaust system and virtually completely destroyed by the catalyst.
Recommended Content
Technical Paper | Powertrain Development of the 1996 Ford Flexible Fuel Taurus |
Technical Paper | Methanol/Gasoline Blends as Automotive Fuel |
Technical Paper | CRC Speciated Hydrocarbon Emissions Analysis Round Robin Test Program |
Authors
Citation
Harrenstien, M., Rhee, K., and Adt, R., "Determination of Individual Aldehyde Concentrations in the Exhaust of a Spark Ignited Engine Fueled by Alcohol/Gasoline Blends," SAE Technical Paper 790952, 1979, https://doi.org/10.4271/790952.Also In
References
- Oberdorfer P. E. “The Determination of Aldehydes in Automobile Exhaust Gas,” SAE Paper No. 670123 1967
- Sawicki E. Stanley T. W. Elbert W. “The 3-Methyl-2-Benzothiazolone Hydrazone Test,” 33 93 1961
- “Oxygenates in Automotive Exhaust: Part I, Techniques for Determining Aldehydes by the MBTH Method,” Coordinating Research Council Report No. 415 June 1968
- “Procedures for Determining Exhaust Carbonyls as 2, 4-Dinitrophenylhydrazones,” Fuels Combustion Research Projects Bartlesville Petroleum Research Center, Bureau of Mines 1969
- Hoshika Y. Takata Y. “Gas Chromatographic Separation of Carbonyl Compounds as their 2, 4-Dinitrophenylhydrazones Using Glass Capillary Columns,” Journal of Chromatography 120 379 389 1976
- McElvain S. M. “The Characterization of Organic Compounds,” 1953
- Iddles H. A. Jackson C. E. “Determination of Carbonyl Compounds by Means of 2, 4-Dinitrophenylhydrazine,” Industrial and Engineering Chemistry, Analytical Edition 6 454 456 November 16 1934
- “Oxygenates in Automotive Exhaust Gas: Part II, Techniques for Determining Aldehydes by the DNPH Method,” Coordinating Research Council Report No. 417 March 1969
- Lappin G. R. Clark L. C. “Colorimetric Method for Determination of Traces of Corbonyl Compounds,” Analytical Chemistry 23 541 March 1951
- Soukup R. J. Scarpellino R. J. Danielczik E. “Gas Chromatographic Separation of 2, 4-Dinitrophenylhydrazone Derivatives of Carbonyl Compounds,” Analytical Chemistry 36 12 2255 2256 November 1964
- Fracchia M. F. Schuette F. J. Mueller P. K. “A Method for Sampling and Determination of Organic Carbonyl Compounds in Automobile Exhaust,” 1 11 915 922 November 1967
- Papa L. J. Turner L. P. “Chromatographic Determination of Carbonyl Compounds as their 2, 4-Dinitrophenylhydrazones: 1, Gas Chromatography,” Journal of Chromatographic Science 10 744 December 1972
- Rosmus J. Deyl Z. “Two Improved Methods for the Separation of 2, 4-Dinitrophenylhydrazones of Carbonyl Compounds,” Journal of Chromatography 6 187 190 1961
- Ronkainen P. “Chromatographic Identification of Carbonyl Compounds: II. Thin-Layer Chromatography of Bishydrazones of Dicarbonyl Compounds,” Journal of Chromatography 27 380 383 1967
- Lynn, W. S. Jr. Steele L. A. Staple E. “Separation of 2, 4-Dinitrophenylhydrazones of Aldehydes and Ketones by Paper Chromatography,” Analytical Chemistry 28 1 132 133 January 1956
- Ellis R. Gaddis A. M. “Paper Chromatography of 2, 4-Dinitrophenylhydrazones: Estimation of 2-Alkanone, n-Alkanal, Alk-2-enal, and Alk-2, 4-dienal Derivatives,” Analytical Chemistry 31 12 1997 2000 December 1959
- Corbin E. A. “Separation of the 2, 4-Dinitrophenylhydrazones of Dicarbonyl and Other Polar Compounds by Liquid-Liquid Partition Chromatography,” Analytical Chemistry 34 10 1244 1247 September 1962
- Keeney M. “Regeneration of Carbonyls from 2, 4-Dinitrophenylhydrazones with Luvulinic Acid,” Analytical Chemistry 29 10 1489 1491 October 1957
- Ralls J. W. “Rapid Method for Semiquantitative Determination of Volatile Aldehydes, Ketones and Acids: Flash Exchange Gas Chromatography,” Analytical Chemistry 32 3 332 336 March 1960
- Stevens R. L. Teszler A. P. “Quantitative Estimation of Low Boiling Carbonyls by a Modified Alpha-Ketoglutaric Acid-2, 4-Dinitrophenylhydrazones Exchange Procedure,” Analytical Chemistry 32 8 1047 July 1960
- Gadbois D. F. Mendelsohn J. M. Ronsivalli L. J. “Modification of Girard-T Reagent Method for Concentrating Carbonyl Compounds for Gas Chromatographic Analysis,” Analytical Chemistry 37 1776 1778 December 1965
- Vogh J. W. “Isolation and Analysis of Carbonyl Compounds as Oximes,” Analytical Chemistry 43 12 1718 1623 October 1971
- Ninomiya J. S. Golovoy A. Labana S. S. “Effect of Methanol on Exhaust Composition of a Fuel Containing Toluene, n-Heptane, and Isoctane,” Journal of the Air Pollution Control Association 20 314 317 May 1970
- Adelman H. G. Devoto R. S. Andrews D. G. “Reduction of Automobile Exhaust Emissions with Methyl Alcohol as a Fuel,” September 1971
- Wigg E. E. Lunt R. S. “Methanol as a Gasoline Extender - Fuel Economy, Emissions, and High Temperature Driveability,” SAE Paper No. 741008 1974
- Hilden D. L. Parks F. B. “A Single Cylinder Engine Study of Methanol Fuel - Emphasis on Organic Emissions,” SAE Paper No. 760378 1976
- Furey R. L. Jackson M. W. “Exhaust and Evaporative Emissions from a Brazilian Chevrolet Fueled with Ethanol/Gasoline Blends,” Environmental Activities Staff, General Motors Corporation 1977
- Ebersole G. D. Manning F. S. “Engine Performance and Exhaust Emissions: Methanol versus Isooctane,” SAE Paper No. 720692 1972
- Bernhardt W. E. Lee W. “Combustion of Methyl Alcohol in Spark-Ignition Engines,” 15th International Symposium on Combustion Tokyo, Japan August 1974
- Heitland H. Bernhardt W. Lee W. “Comparative Results on Methanol and Gasoline-Fueled Passenger Cars,” 2nd Symposium on Low Pollution Power Systems Developments Dusseldorf, Germany November 1974
- Ingamells J. S. Lindquist R. H. “Methanol as a Motor Fuel,” Science May 1974
- Bernhardt W. E. “Engine Performance and Exhaust Emission Characteristics from a Methanol-Fueled Automobile,” 1975 GMR Symposium, Future Automotive Fuels-Prospects, Performances, and Perspectives October 1975
- Johnson R. T. Riley R. K. “Evaluation of Methyl Alcohol as a Vehicle Fuel Extender,” August 1975
- Pefley R. K. Saad M. A. Sweeney M. A. Kilgroe J. D. “Performance and Emissions Characteristics Using Blends of Methanol and Dissociated Methanol as an Automotive Fuel,” SAE Paper No. 719008 1971
- Pefley R. K. “Summary of Methanol Mobile Power Research Investigations,” EPA Grant No. R803548-01 for Office of Highway Vehicle Systems, ERDA, Contractors Coordination Meeting Ann Arbor, Michigan May 4-6 1976
- Gabele P. A. Braddock J. N. Bradow R. L. “A Characterization of Exhaust Emissions from Lean Burn, Rotary, and Stratified Charge Engines,” SAE Paper No. 770301 1977
- Springer K. J. “Investigation of Diesel-Powered Vehicle Emissions VII,” Southwest Research Institute Report for EPA February 1977
- Chester K. A. Adt, R. R. Jr. Rhee K. T. Pappas J. M. Swain M. R. “The Effect of Blending Methanol with Gasoline on the Lean Misfire Limit of a Multi-cylinder Carbureted Engine,” International Symposium on Alcohol Fuel Technology: Methanol and Ethanol II Wolfsburg November 21-23 1977
- Harrenstien M. S. “Measurement of Aldehyde Concentrations in the Exhaust of an Internal Combustion Engine Fueled by Alcohol/Gasoline Blends,” University of Miami 1978
- Obert E. F. “Internal Combustion Engines,” 1968 International Textbook Company New York