This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Experimental Investigations of Methane-Hydrogen Blended Combustion in a Heavy-Duty Optical Diesel Engine Converted to Spark Ignition Operation
Technical Paper
2023-01-0289
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
The global need for de-carbonization and stringent emission regulations are pushing the current engine research toward alternative fuels. Previous studies have shown that the uHC, CO, and CO2 emissions are greatly reduced and brake thermal efficiency increases with an increase in hydrogen concentration in methane-hydrogen blends for the richer mixture compositions. However, the combustion suffers from high NOx emissions. While these trends are well established, there is limited information on a detailed optical study on the effect of air-excess ratio for different methane-hydrogen mixtures. In the present study, experimental investigations of different methane-hydrogen blends between 0 and 100% hydrogen concentration by volume for the air-excess ratio of 1, 1.4, 1.8, and 2.2 were conducted in a heavy-duty optical diesel engine converted to spark-ignition operation. The engine was equipped with a flat-shaped optical piston to allow bottom-view imaging of the combustion chamber. High-speed natural combustion luminosity images were recorded at a frame rate of 7.2 kHz for all cases, together with in-cylinder pressure measurements. Results showed that the increase in hydrogen concentration has shifted the CA50 towards TDC thus increasing the peak combustion pressure. Methane combustion shows the lean limit at lambda 1.4 and extension of the lean limit requires at least 20% of hydrogen addition while maintaining the COV of IMEP below 5%. However, at lambda 1.8 case, 60% of hydrogen enhancement was needed to achieve stable combustion. Overall, with higher hydrogen concentration, there is an improvement in the combustion stability irrespective of the air-excess ratio. Image analysis was performed on the high-speed natural combustion luminosity images to obtain quantitative information on the flame front propagation speed for the tested methane-hydrogen blends. Hydrogen addition results in an increase in flame front propagation speed. When the hydrogen concentration in methane-hydrogen blends is about 50% by volume and more, the flame kernel propagates rapidly at the onset of combustion and decreases, resulting in a shorter combustion duration.
Authors
Topic
Citation
Panthi, N., Chang, J., AlRamadan, A., and Magnotti, G., "Experimental Investigations of Methane-Hydrogen Blended Combustion in a Heavy-Duty Optical Diesel Engine Converted to Spark Ignition Operation," SAE Technical Paper 2023-01-0289, 2023, https://doi.org/10.4271/2023-01-0289.Also In
References
- Kalghatgi , G. Is it Really the End of Internal Combustion Engines and Petroleum in Transport? Applied Energy 225 May 2018 965 974 https://doi.org/10.1016/j.apenergy.2018.05.076
- https://www.eea.europa.eu/themes/transport/heavy-duty-vehicles 2022
- Sens , M. , Danzer , C. , Von Essen , C. , Brauer , M. , et al Hydrogen Powertrains in Competition to Fossil Fuel Based Internal Combustion Engines and Battery Electric Powertrains 42nd International Vienna Motor Symposium 2021
- Christensen , M. , Johansson , B. , and Einewall , P. Homogeneous Charge Compression Ignition (HCCI) Using Isooctane, Ethanol and Natural Gas - a Comparison with Spark Ignition Operation SAE Technical Paper 972874 1997 https://doi.org/10.4271/972874
- Dec , J.E. Advanced Compression-Ignition Engines - Understanding the in-Cylinder Processes Proceedings of the Combustion Institute 32 II 2 2009 2727 2742 https://doi.org/10.1016/j.proci.2008.08.008
- Kokjohn , S. , Reitz , R.D. , Splitter , D. , and Musculus , M. Investigation of Fuel Reactivity Stratification for Controlling PCI Heat-Release Rates Using High-Speed Chemiluminescence Imaging and Fuel Tracer Fluorescence SAE International Journal of Engines 5 2 2012 248 269 https://doi.org/10.4271/2012-01-0375
- Kalghatgi , G.T. , Hildingsson , L. , Harrison , A.J. , and Johansson , B. Autoignition Quality of Gasoline Fuels in Partially Premixed Combustion in Diesel Engines Proceedings of the Combustion Institute 33 2 2011 3015 3021 https://doi.org/10.1016/j.proci.2010.07.007
- Raman , V. , Tang , Q. , An , Y. , Shi , H. et al. Impact of Spray-Wall Interaction on the in-Cylinder Spatial Unburned Hydrocarbon Distribution of a Gasoline Partially Premixed Combustion Engine Combustion and Flame 215 2020 157 168 https://doi.org/10.1016/j.combustflame.2020.01.033
- Goyal , H. and Kook , S. Ignition Process of Gasoline Compression Ignition (GCI) Combustion in a Small-Bore Optical Engine Fuel 256 2019 115844 https://doi.org/10.1016/j.fuel.2019.115844
- Babayev , R. , Houidi , M.B. , Andersson , A. , and Johansson , B. Isobaric Combustion: A Potential Path to High Efficiency, in Combination with the Double Compression Expansion Engine (DCEE) Concept SAE Technical Paper 2019-01-0085 2019 https://doi.org/10.4271/2019-01-0085
- Panthi , N. , Goyal , H. , AlRamadan , A. , and Magnotti , G. Influence of Primary Reference Fuels on Isobaric Combustion in a Heavy-Duty Optical Diesel Engine Fuel 337 2023 127169 https://doi.org/10.1016/j.fuel.2022.127169
- Goyal , H. , Panthi , N. , Houidi , M.Ben. , Al Ramadan , A.S. , et al Performance Analysis and in-Cylinder Visualization of Conventional Diesel and Isobaric Combustion in an Optical Diesel Engine SAE Technical Paper 2021-24-0040 2021 https://doi.org/10.4271/2021-24-0040
- Panthi , N. , Goyal , H. , Al Ramadan , A.S. , et al Optical Diagnostics of Isobaric and Conventional Diesel Combustion in a Heavy- Duty Diesel Engine SAE Technical Paper 2022-01-0418 2022 https://doi.org/10.4271/2022-01-0418
- Panthi , N. , Goyal , H. , Houidi , M.Ben. , Al Ramadan , A.S. , et al Flow-Field Analysis of Isobaric Combustion Using Multiple Injectors in an Optical Accessible Diesel Engine SAE Technical paper 2021-24-0042 2021 https://doi.org/10.4271/2021-24-0042
- Bendu , H. and Murugan , S. Homogeneous Charge Compression Ignition (HCCI) Combustion: Mixture Preparation and Control Strategies in Diesel Engines Renewable and Sustainable Energy Reviews 38 2014 732 746 https://doi.org/10.1016/j.rser.2014.07.019
- Alramadan , A.S. , Houidi , M.B. , Nyrenstedt , G. , and Johansson , B. Fuel Flexibility Study of a Compression Ignition Engine at High Loads SAE Technical Paper 2019-01-2193 2019 https://doi.org/10.4271/2019-01-2193
- Hill , J. , Tajibaeva , L. , and Polasky , S. Climate Consequences of Low-Carbon Fuels: The United States Renewable Fuel Standard Energy Policy 97 2016 351 353 https://doi.org/10.1016/j.enpol.2016.07.035
- Martínez-Martínez , S. , de la Rosa-Urbalejo , D. , Rua-Mojica , L.F. , Hernández-Altamirano , R. , et al Experimental Analysis of Real-World Emissions Using Ultra-Low Carbon Intensity Biodiesel for a Light-Duty Diesel Vehicle in Monterrey Metropolitan Area Fuel 317 123408 2022 https://doi.org/10.1016/j.fuel.2022.123408
- Verhelst , S. , Wallner , T. , and Sierens , R. Hydrogen-Fueled Internal Combustion Engines Handbook of Hydrogen Energy 2014 821 902 https://doi.org/10.1201/b17226
- Liu , J. and Dumitrescu , C.E. Flame Development Analysis in a Diesel Optical Engine Converted to Spark Ignition Natural Gas Operation Applied Energy 230 June 2018 1205 1217 https://doi.org/10.1016/j.apenergy.2018.09.059
- Karim , G. and Wierzba , I. Comparative Studies of Methane and Propane as Fuels for Spark Ignition and Compression Ignition Enginesle SAE Technical Paper 831196 1983 https://doi.org/10.4271/831196
- Peñaranda , A. , Martinez Boggio , S.D. , Lacava , P.T. , Merola , S. et al. Characterization of Flame Front Propagation during Early and Late Combustion for Methane-Hydrogen Fueling of an Optically Accessible SI Engine International Journal of Hydrogen Energy 43 52 2018 23538 23557 https://doi.org/10.1016/j.ijhydene.2018.10.167
- Hlaing , P. , Echeverri Marquez , M. , Bhavani Shankar , V.S. , Cenker , E. et al. A Study of Lean Burn Pre-Chamber Concept in a Heavy Duty Engine SAE Technical Paper 2019-24-0107 2019 https://doi.org/10.4271/2019-24-0107
- Echeverri Marquez , M. , Hlaing , P. , Houidi , M.B. , Magnotti , G. et al. Optical Diagnostics of Pre-Chamber Combustion with Flat and Bowl-in Piston Combustion Chamber SAE Technical Paper 2021-01-0528 2021 https://doi.org/10.4271/2021-01-0528
- Sampath , R. , Tang , Q. , Marquez , M.E. , Sharma , P. et al. Study on the Pre-Chamber Fueling Ratio Effect on the Main Chamber Combustion Using Simultaneous PLIF and OH* Chemiluminescence Imaging SAE Int. J. Adv. & Curr. Prac. in Mobility 3 1 2021 137 149 https://doi.org/10.4271/2020-01-2024
- Tang , Q. , Sampath , R. , Marquez , M.E. , Sharma , P. et al. Optical Diagnostics on the Pre-Chamber Jet and Main Chamber Ignition in the Active Pre-Chamber Combustion (PCC) Combustion and Flame 228 2021 218 235 https://doi.org/10.1016/j.combustflame.2021.02.001
- Di Iorio , S. , Sementa , P. , and Vaglieco , B.M. Experimental Investigation on the Combustion Process in a Spark Ignition Optically Accessible Engine Fueled with Methane/Hydrogen Blends International Journal of Hydrogen Energy 39 18 9809 9823 2014 https://doi.org/10.1016/j.ijhydene.2014.04.065
- Wang , J. , Chen , H. , Liu , B. , and Huang , Z. Study of Cycle-by-Cycle Variations of a Spark Ignition Engine Fueled with Natural Gas-Hydrogen Blends International Journal of Hydrogen Energy 33 18 2008 4876 4883 https://doi.org/10.1016/j.ijhydene.2008.06.062
- Ma , F. , Ding , S. , Wang , Y. , Wang , Y. et al. Study on Combustion Behaviors and Cycle-by-Cycle Variations in a Turbocharged Lean Burn Natural Gas S.I. Engine with Hydrogen Enrichment International Journal of Hydrogen Energy 33 23 2008 7245 7255 https://doi.org/10.1016/j.ijhydene.2008.09.016
- Ma , F. , Ding , S. , Wang , Y. , Wang , M. et al. Performance and Emission Characteristics of a Spark-Ignition (SI) Hydrogen-Enriched Compressed Natural Gas (HCNG) Engine under Various Operating Conditions Including Idle Conditions Energy and Fuels 23 6 2009 3113 3118 https://doi.org/10.1021/ef900144s
- Xu , J. , Zhang , X. , Liu , J. , and Fan , L. Experimental Study of a Single-Cylinder Engine Fueled with Natural Gas-Hydrogen Mixtures International Journal of Hydrogen Energy 35 7 2010 2909 2914 https://doi.org/10.1016/j.ijhydene.2009.05.039
- Park , C. , Kim , C. , Choi , Y. , Won , S. et al. The Influences of Hydrogen on the Performance and Emission Characteristics of a Heavy Duty Natural Gas Engine International Journal of Hydrogen Energy 36 5 2011 3739 3745 https://doi.org/10.1016/j.ijhydene.2010.12.021
- Bysveen , M. Engine Characteristics of Emissions and Performance Using Mixtures of Natural Gas and Hydrogen Energy 32 4 2007 482 489 https://doi.org/10.1016/j.energy.2006.07.032
- Kahraman , N. , Çeper , B. , Akansu , S.O. , and Aydin , K. Investigation of Combustion Characteristics and Emissions in a Spark-Ignition Engine Fuelled with Natural Gas-Hydrogen Blends International Journal of Hydrogen Energy 34 2 2009 1026 1034 https://doi.org/10.1016/j.ijhydene.2008.10.075
- Akansu , S.O. , Kahraman , N. , and Çeper , B. Experimental Study on a Spark Ignition Engine Fuelled by Methane-Hydrogen Mixtures International Journal of Hydrogen Energy 32 17 2007 4279 4284 https://doi.org/10.1016/j.ijhydene.2007.05.034
- Catapano , F. , Di Iorio , S. , Magno , A. , Sementa , P. , and Vaglieco , B.M. A Comprehensive Analysis of the Effect of Ethanol, Methane and Methane-Hydrogen Blend on the Combustion Process in a PFI (Port Fuel Injection) Engine Energy 88 101 110 2015 https://doi.org/10.1016/j.energy.2015.02.051
- Otsu , N. , Smith , P.L. , Reid , D.B. , Environment , C. et al. Otsu_1979_otsu_method IEEE Transactions on Systems, Man, and Cybernetics C 1 1979 62 66
- Zhang , R. , Chen , L. , Wei , H. , Li , J. et al. Understanding the Difference in Combustion and Flame Propagation Characteristics between Ammonia and Methane Using an Optical SI Engine Fuel 324 PC 2022 124794 https://doi.org/10.1016/j.fuel.2022.124794
- Zhang , R. , Chen , L. , Pan , J. , Wei , H. et al. Effects of Direct-Injected Hydrogen Addition on Methane Combustion Performance in an Optical SI Engine with High Compression-Ratio International Journal of Hydrogen Energy 45 4 2020 3284 3293 https://doi.org/10.1016/j.ijhydene.2019.11.220
- Sementa , P. , de Vargas Antolini , J.B. , Tornatore , C. , Catapano , F. , et al Exploring the Potentials of Lean-Burn Hydrogen SI Engine Compared to Methane Operation International Journal of Hydrogen Energy 7 2022 https://doi.org/10.1016/j.ijhydene.2022.05.250