This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
A Comparison of Coated and Uncoated Diesel Engine Performance and Emission Characteristics Powered by Chlorella Vulgaris Biodiesel Blend with an Assistance of Alumina Nano Additive
Technical Paper
2022-28-0021
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
The engine parameters of a diesel engine (using coated and uncoated pistons) operating with alumina additive chlorella vulgaris biodiesel blends were evaluated experimentally. The properties of test fuel samples were investigated using ASTM standards, and the composition of C. Vulgaris biodiesel was also examined using an FTIR report. A diesel engine’s performance and pollution characteristics were studied using different fuel samples such as diesel, CBD20, CBD20ANP with coated and uncoated pistons. The experimental results showed that the coated engine had a higher BTE (1.8-3.2 percent) and a lower BSFC (1.2-3.8 percent) than the uncoated engine. It is also identified that, exhaust emissions like as CO, HC, and smoke opacity have also been moderately reduced with the coated engine, while NOx emissions were slightly increased.
Authors
- Raghurami Reddy Doddipalli - Sree Vidyanikethan Engineering College
- R L krupakaran - Mohan Babu University
- Vidyasagar reddy Gangula - Sree Vidyanikethan Engineering College
- Hariprasad Tarigonda - Sree Vidyanikethan Engineering college
- Praveen anchupogu - Bapatla Engineering College
- Ratna Kamala PETLA - Siddharth Institute of Engg & Technology
Topic
Citation
Doddipalli, R., krupakaran, R., Gangula, V., Tarigonda, H. et al., "A Comparison of Coated and Uncoated Diesel Engine Performance and Emission Characteristics Powered by Chlorella Vulgaris Biodiesel Blend with an Assistance of Alumina Nano Additive," SAE Technical Paper 2022-28-0021, 2022, https://doi.org/10.4271/2022-28-0021.Also In
References
- Raj , A.G. , Mishra , C.S. , Sachuthananthan , B. , and Banu , P.A. Impact of Dual Fuel Compression Ignition Engine on Its Performance, Combustion and Emission Characteristics Materials Today: Proceedings 2022
- Lawrence , K.R. , Huang , Z. , Nguyen , X.P. , Balasubramanian , D. et al. Exploration over Combined Impacts of Modified Piston Bowl Geometry and Tert-butyl Hydroquinone Additive-Included Biodiesel/Diesel Blend on Diesel Engine Behaviors Fuel 15 322 2022 124206
- Raj , A.G. , Mallikarjuna , J.M. , and Venkitachalam , G. Analysis of In-Cylinder Air Motion in a DI Diesel Engine with Four Different Piston Bowl Configuration-A CFD and PIV Comparison SAE Int. J. of Engines 6 4 2013 1978 1983
- Vellaiyan , S. Enhancement in Combustion, Performance, and Emission Characteristics of a Diesel Engine Fueled with Diesel, Biodiesel, and Its Blends by Using Nanoadditive Environmental Science and Pollution Research. 26 10 2019 9561 9573
- Balasubramanian , D. and Lawrence , K.R. Influence on the Effect of Titanium Dioxide Nanoparticles as an Additive with Mimusops Elengi Methyl Ester in a CI Engine Environmental Science and Pollution Research 26 16 2019 16493 16502
- Prabu , A. , Premkumar , I.J. , and Pradeep , A. An Assessment on the Nanoparticles-Dispersed Aloe Vera Biodiesel Blends on the Performance, Combustion and Emission Characteristics of a DI Diesel Engine Arabian Journal for Science and Engineering 44 9 2019 7457 7463
- Ramakrishnan , G. , Krishnan , P. , Rathinam , S. , and Devarajan , Y. Role of Nano-additive Blended Biodiesel on Emission Characteristics of the Research Diesel Engine International Journal of Green Energy 16 6 2019 435 441
- Tamilalagan , A. , Singaram , J. , and Rajamohan , S. Generation of Biodiesel from Industrial Wastewater Using Oleaginous Yeast: Performance and Emission Characteristics of Microbial Biodiesel and Its Blends on a Compression Injection Diesel Engine Environmental Science and Pollution Research 26 11 2019 11371 11386
- Kannan , D. and Christraj , W. Emission analysis of Azolla Methyl Ester with Bi2O3 Nano Additives for IC Engine Energy Sources, Part A: Recovery, Utilization, and Environmental Effects 40 10 2018 1183 1189
- Sachuthananthan , B. , Krupakaran , R.L. , and Balaji , G. Exploration on the Behaviour Pattern of a DI Diesel Engine Using Magnesium Oxide Nano Additive with Plastic Pyrolysis Oil as Alternate Fuel International Journal of Ambient Energy 42 6 2021 701 712
- Bharathy , S. , Gnanasikamani , B. , and Radhakrishnan , L.K. Investigation on the Use of Plastic Pyrolysis Oil as Alternate Fuel in a Direct Injection Diesel Engine with Titanium Oxide Nanoadditive Environmental Science and Pollution Research 26 10 2019 10319 10332
- Selvam , M. , Shanmugan , S. , and Palani , S. Performance Analysis of IC Engine with Ceramic-Coated Piston Environmental Science and Pollution Research International 25 35 2018 35210 35220
- Thirunavukkarasu , R. and Periyasamy , S. Enhancing Diesel Engine Performance and Balancing Emissions with Effect and Contribution of MgO-ZrO2 and AT13 Layered Piston Arabian Journal for Science and Engineering 45 11 2020 9699 9707
- Venu , H. and Appavu , P. Analysis on a Thermal Barrier Coated (TBC) Piston in a Single Cylinder Diesel Engine Powered by Jatropha Biodiesel-Diesel Blends SN Applied Sciences 1 12 2019 1 3
- Saravanan , S. , Kumar , C.R. , Pugazhendhi , A. , and Brindhadevi , K. Role of Thermal Barrier Coating and Porous Medium Combustor for a Diesel Engine: An Experimental Study Fuel. 280 2020 118597
- Mohamed Abbas , S. and Elayaperumal , A. Experimental Investigation on the Effect of Ceramic Coating on Engine Performance and Emission Characteristics for Cleaner Production Journal of Cleaner Production 2018 10.1016/j.jclepro.2018.12.040
- Gorkal , A. , Reddy , C.P. , and Ravi , M.U. Experimental Investigations on LHR Single Cylinder Air Cooled Diesel Engine using Simarouba Biodiesel and its Blends as Alternate to Diesel Fuel Journal of the Institution of Engineers (India): Series C 99 5 2018 513 524
- Gangula , V.R. , Nandhana Gopal , G.R. , and Tarigonda , H. Experimental Analysis and Energy Balance on Thermal Barrier-Coated Piston Diesel Engine Using Biodiesel Journal of the Institution of Engineers (India): Series C 101 6 2020 1015 1026
- Reddy , G.V. , Krupakaran , R.L. , Tarigonda , H. , Reddy , D.R. et al. Energy Balance and Emission Analysis on Diesel Engine Using Different Thermal Barrier Coated Pistons Materials Today: Proceedings 43 2021 646 654
- Altarazi , Y.S. , Yu , J. , Gires , E. , Ghafir , M.F. et al. Effects of Biofuel on Engines Performance and Emission Characteristics: A Review Energy 238 2022 121910
- Shabir , M.F. , Authars , S. , Ganesan , S. , Karthik , R. , Madhan , S.K. Low Heat Rejection Engines-Review
- Praveen , A. , Lakshmi Narayana , V. , and Ramanaiah , K. Influence of Nanoadditive Chlorella Vulgaris Microalgae Biodiesel Blends on the Performance and Emission Characteristics of a DI Diesel Engine International Journal of Ambient Energy 2020 1 7
- Krupakaran , R.L. , Hariprasasd , T. , Gopalakrishna , A. , and Babu , P. The Performance and Exhaust Emissions Investigation of a Diesel Engine Using γ- Al2O3 Nanoparticle Additives to Biodiesel Carbon Management. 7 3-4 2016 233 241
- Praveen , A. , Krupakaran , R.L. , Lakshmi Narayana Rao , G. , and Balakrishna , B. An Assessment of the TiO2 Nanoparticle Concentration in the C. Inophyllum Biodiesel Blend on the Engine Characteristics of a DI Diesel Engine International Journal of Ambient Energy 2021
- Anchupogu , P. , Rao , G.L.N. , Balakrishna , B. , Sankar , B.R. et al. Effect of TiO2Nanoadditives on the Combustion Performance and Emission Characteristics of a DI Diesel Engine Advanced Science Letters 24 8 2018 5712 5717
- Krupakaran , R.L. , Hariprasad , T. , and Gopalakrishna , A. Impact of Various Blends of Mimusops Elengi Methyl Esters on Performance and Emission Characteristics of a Diesel Engine International Journal of Green Energy 15 7 2018 415 426