This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Energy Management System for Input-Split Hybrid Electric Vehicle (Si-EVT) with Dynamic Coordinated Control and Mode-Transition Loss
Technical Paper
2022-01-0674
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
Instantaneous optimization-based energy management systems (EMS) are getting popular since they can yield near-optimal performance in unknown driving situations with minimalistic tuning parameters. However, they often disregard the drivability score of the powertrain as a performance assessment criterion, and this leads to too frequent or even infeasible mode-transitions during the multi-mode operation of a hybrid electric powertrain. Aiming to bring down the mode-transition frequency below a feasible limit, this paper proffers an instantaneous optimization-based EMS, which also accounts for the energy lost during mode-transitions into the cost function along with the electrical and chemical energy losses. The energy lost during a single mode-transition event refers to the summation of change in rotational energy for all the prime-movers, i.e., internal combustion engine and electric machines. However, this approach will add another weighting factor for weighting the mode-transition loss term in the same equivalent scale used for weighting other loss terms too. A dynamic coordinated control prescribed in literature is also employed along with the EMS to enhance the drivability score of multi-mode hybrid electric powertrains. Simulation results corroborate the efficacy of the proffered EMS framework in ameliorating the drivability issues without sacrificing much in the fuel consumption and charge sustainability performances.
Authors
- Atriya Biswas - McMaster University
- Omkar Rane - Stellantis NV
- Aashit Rathore - McMaster University
- Pier Giuseppe Anselma - Politecnico Di Torino
- Yue Wang - McMaster University
- Jack Toller - McMaster University
- Joel Roeleveld - McMaster University
- Bryon Wasacz - Stellantis NV
- Ali Emadi - McMaster University
Topic
Citation
Biswas, A., Rane, O., Rathore, A., Anselma, P. et al., "Energy Management System for Input-Split Hybrid Electric Vehicle (Si-EVT) with Dynamic Coordinated Control and Mode-Transition Loss," SAE Technical Paper 2022-01-0674, 2022, https://doi.org/10.4271/2022-01-0674.Also In
References
- Emadi , A. Advanced Electric Drive Vehicles Boca Raton, FL CRC Press Oct. 2014
- Wang , Y. , Biswas , A. , Rodriguez , R. , Keshavarz-Motamed , Z. et al. Hybrid Electric Vehicle Specific Engines: State-Of-The-Art Review Energy Reports 8 2022 832 851
- Biswas , A. , Anselma , P.G. , Rathore , A. , and Emadi , A. Effect of Coordinated Control on Real-Time Optimal Mode Selection for Multi-Mode Hybrid Electric Powertrain Appl. Energy 289 2021 116695
- Pittel , M. and Martin , D. Eflite Dedicated Hybrid Transmission for Chrysler Pacifica SAE Technical Paper 2018-01-0396 2018 10.4271/2018-01-0396
- Yang , C. , Jiao , X. , Li , L. , Zhang , Y. et al. Robust Coordinated Control for Hybrid Electric Bus with Single-Shaft Parallel Hybrid Powertrain IET Control Theory Appl. 9 2 2015 270 282
- Fu , Z. , Su , P. , Song , S. , and Tao , F. Mode Transition Coordination Control for Phev Based on Cascade Predictive Method IEEE Access 7 2019 138403 138414
- Liang , C. , Xu , X. , Wang , F. , and Zhou , Z. Coordinated Control Strategy for Mode Transition of DM-PHEV Based on MLD Nonlinear Dynamics 103 Jan 2021 809 832
- Zhao , Z. and Tang , X. Control of E-CVT to EV Mode Transition on Braking Deceleration Condition for a Compound Power-Split Hybrid Electrical Vehicle IEEE Access 7 2019 111954 111967
- Wang , J. , Cai , Y. , Chen , L. , Shi , D. et al. Review on Multi-Power Sources Dynamic Coordinated Control of Hybrid Electric Vehicle During Driving Mode Transition Process Int. J. Energy Res. 44 8 2020 6128 6148
- Wang , X. , Li , L. , and Yang , C. Hierarchical Control of Dry Clutch for Engine-Start Process in a Parallel Hybrid Electric Vehicle IEEE Trans. Transp. Electrification 2 June 2016 231 243
- Lei , Z. , Sun , D. , Liu , Y. , Qin , D. et al. Analysis and Coordinated Control of Mode Transition and Shifting for a Full Hybrid Electric Vehicle Based on Dual Clutch Transmissions Mech. Mach. Theory 114 2017 125 140
- Tang , X. , Zhang , D. , Liu , T. , Khajepour , A. et al. Research on the Energy Control of a Dual-Motor Hybrid Vehicle During Engine Start-Stop Process Energy 166 2019 1181 1193
- Kim , S. and Choi , S.B. Cooperative Control of Drive Motor and Clutch for Gear Shift of Hybrid Electric Vehicles with Dual-Clutch Transmission IEEE/ASME Transactions on Mechatronics 25 June 2020 1578 1588
- Dadam , S.R. , Jentz , R. , Lenzen , T. , and Meissner , H. Diagnostic Evaluation of Exhaust Gas Recirculation (EGR) System on Gasoline Electric Hybrid Vehicle WCX SAE World Congress Experience, SAE International Apr 2020
- Su , Y. , Hu , M. , Su , L. , Qin , D. et al. Dynamic Coordinated Control During Mode Transition Process for a Compound Power-Split Hybrid Electric Vehicle Mechanical Systems and Signal Processing 107 2018 221 240
- Biswas , A. , Anselma , P.G. , and Emadi , A. Real-Time Optimal Energy Management of Electrified Powertrains with Reinforcement Learning Proc. 2019 IEEE Transp. Electrification Conf. (ITEC) June 2019 1 6
- Geng , W. , Lou , D. , Wang , C. , and Zhang , T. A Cascaded Energy Management Optimization Method of Multimode Power-Split Hybrid Electric Vehicles Energy 199 2020 117224
- Su , Y. , Hu , M. , Su , L. , Qin , D. et al. Dynamic Coordinated control During Mode Transition Process for a Plug-in Hybrid Electric Vehicle IEEE Access 7 2019 53891 53908
- Wang , J. , Hou , X. , Du , C. , Xu , H. et al. A Moment-Of-Inertia-Driven Engine Start-Up Method Based on Adaptive Model Predictive Control for Hybrid Electric Vehicles with Drivability Optimization IEEE Access 8 2020 133063 133075
- Yang , C. , Jiao , X. , Li , L. , Zhang , Y. et al. A Robust H-Infinity Control-Based Hierarchical Mode Transition Control System for Plug-In Hybrid Electric Vehicle Mech. Syst. Signal Process 99 2018 326 344
- Biswas , A. , Anselma , P.G. , and Emadi , A. Real-Time Optimal Energy Management of Multi-Mode Hybrid Electric Powertrain with Online Trainable Asynchronous Advantage Actor-Critic Algorithm IEEE Transactions on Transportation Electrification 2021 1 1
- Li , L. , Tao , F. , and Fu , Z. Drivability Improving Control During Mode Transition Process of Through-the-Road Hybrid Electric Vehicles IEEE Canadian Journal of Electrical and Computer Engineering 44 65 74 2021
- Li , G. and Görges , D. Optimal Integrated Energy Management and Shift Control in Parallel Hybrid Electric Vehicles with Dual-Clutch Transmission Proceedings of the Institution of Mechanical Engineers, Part D: Journal of Automobile Engineering 234 2-3 2020 599 609
- Oncken , J. , Sachdeva , K. , Wang , H. , and Chen , B. Integrated Predictive Powertrain Control for a Multimode Plug-in Hybrid Electric Vehicle IEEE/ASME Transactions on Mechatronics 26 June 2021 1248 1259
- Zhuang , W. , Zhang , X. , Yin , G. , Peng , H. et al. Mode Shift Schedule and Control Strategy Design of Multimode Hybrid Powertrain IEEE Tran. Control Syst. Technol. 28 May 2020 804 815
- Paganelli , G. , Delprat , S. , Guerra , T.M. , Rimaux , J. et al. Equivalent Consumption Minimization Strategy for Parallel Hybrid Powertrains IEEE 55th Veh. Technol. Conf May 2002 4 2076 2081
- Serrao , L. and Rizzoni , G. Optimal Control of Power Split for a Hybrid Electric Refuse Vehicle Proc. 2008 Am. Control. Conf June 2008 4498 4503
- Zhang , C. , Vahidi , A. , Pisu , P. , Li , X. et al. Role of Terrain Preview in Energy Management of Hybrid Electric Vehicles IEEE Transactions on Vehicular Technology 59 March 2010 1139 1147
- Lempert , J. , Vadala , B. , Arshad-Aliy , K. , Roeleveld , J. et al. Practical Considerations for the Implementation of Dynamic Programming for HEV Powertrains IEEE Transportation Electrification Conference and Expo (ITEC) June 2018 755 760
- Zeng , X. , Yang , N. , Wang , J. , Song , D. et al. Predictive-Model-Based Dynamic Coordination Control Strategy for Power-Split Hybrid Electric Bus Mech. Syst. Signal Process. 60-61 2015 785 798
- Zhuang , W. , Zhang , X. , Li , D. , Wang , L. et al. Mode Shift Map Design and Integrated Energy Management Control of a Multi-Mode Hybrid Electric Vehicle Appl. Energy 204 2017 476 488