This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Real World Emissions from Tier 4F Off-Road Construction Equipment
Technical Paper
2022-01-0577
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
The primary purpose of this study was to obtain gas-phase and particular matter (PM) emissions from newer Tier 4 final off-road construction equipment using a Portable Emissions Measurement System (PEMS). This information can be used to provide accurate estimates of emissions from off-road construction equipment under real-world scenarios. Emission measurements were made for 10 pieces of Tier 4 final construction equipment including 3 excavators, 3 wheel loaders, 2 crawler tractors and 2 backhoe/loaders. The duty cycles included a pre-defined combined sequence of a cold-start phase, trenching, backfilling, travelling, and idling. For all types of equipment, the highest emissions were seen for the cold start phase, which showed NOx emissions levels ranging from 3.4 to 6.3 g/bhp-hr, from 15.8 to 26.1 g/kg-fuel and from 107 to 249 g/hour, with an average exhaust temperature around 100°C.The next highest emissions were found for the travel mode. NOx emissions from the idle period ranged from 12.8 to 50 g/hour. NOx emissions from all equipment categories over trench and backfill modes show a range from 0.07 to 0.69 g/bhp-hr, from 0.4 to 3.7 g/kg-fuel, and from 11.4 to 34.2 g/hour. NOx emissions over trench and backfill work modes were generally close to or below the in-use compliance emission rate (1.5 times engine certified emissions rate) except for a few pieces of equipment that showed higher emissions due to less effective aftertreatment systems or lower exhaust temperatures. PM emissions ranged from 0.1 to 13 mg/bhp-hr, which is below the standard of 20 mg/bhp-hr for Tier 4 final off-road equipment. The backhoe/loader category shows the highest emissions because both pieces of equipment in this category lacked a DPF to reduce PM emissions.
Authors
- Hanwei Zhu - University Of California Riverside
- George Scora - University Of California Riverside
- Georgios Karavalakis - University Of California Riverside
- Kent Johnson - University Of California Riverside
- Robert Russell - University Of California Riverside
- Tom Durbin - University Of California Riverside
Topic
Citation
Zhu, H., Scora, G., Karavalakis, G., Johnson, K. et al., "Real World Emissions from Tier 4F Off-Road Construction Equipment," SAE Technical Paper 2022-01-0577, 2022, https://doi.org/10.4271/2022-01-0577.Also In
References
- U.S. Environmental Protection Agency 2017 National Emissions Inventory Report https://gispub.epa.gov/neireport/2017/
- California Air Resources Board http://www.arb.ca.gov/msei/msei.htm
- U.S. Environmental Protection Agency https://www.epa.gov/moves/nonroad-technical-reports#2008a
- California Air Resource Board https://www.arb.ca.gov/msprog/offroad/cert/cert.php
- Marshall , S.K. , Rasdorf , W. , Lewis , P. , and Frey , H.C. Methodology for Estimating Emissions Inventories for Commercial Building Projects J. Archit. Eng. 18 2012 251 260 https://doi.org/10.1061/(ASCE)AE.1943-5568.0000073
- Rasdorf , W. , Lewis , P. , Marshall , S.K. , Arocho , I. et al. Evaluation of On-site Fuel Use and Emissions Over the Duration of a Commercial Building Project J. Infrastruct. Syst. 18 2012 119 112 https://doi.org/10.1061/(ASCE)IS.1943-555X.0000071
- Rasdorf , W. , Frey , C. , Lewis , P. , Kim , K. et al. Field procedures for Real-World Measurements of Emissions from Diesel Construction Vehicles J. Infrastruct. Syst. 16 2012 216 225
- Shao , Z. Non-road Emission Inventory Model Methodology The International Council of Clean Transportation (ICCT) 2016 http://www.theicct.org/sites/default/files/publications/ICCT_nonroad-model-method_20160224.pdf
- Lewis , P. , Rasdorf , W. , Frey , H.C. , and Leming , M. Effects of Engine Idling on National Ambient Air Quality Standards Criteria Pollutant Emissions from Nonroad Diesel Construction Equipment Transp. Res. Rec. 2270 2012 67 75
- Cao , T. , Russell , R.L. , Durbin , T.D. et al. Characterization of the Emissions Impacts of Hybrid Excavators with a Portable Emissions Measurement System (PEMS)-Based Methodology Science of the Total Environment 635 2018 112 119 https://doi.org/10.1016/j.scitotenv.2018.04.011
- Lewis , P. , Rasdorf , W. , and Frey , H.C. Development and Use of Emissions Inventories for Construction Vehicles Transp. Res. Rec. 2123 2009 46e53
- Lewis , P. , Rasdorf , W. , Frey , H.C. , Pang , S.H. et al. Requirements and Incentives for Reducing Construction Vehicle Emissions and Comparison of Non-road Diesel Engine Emissions Data Sources J. Constr. Eng. Manage. 135 2009 341e351
- Lewis , P. , Karimi , B. , Shan , Y. , and Rasdorf , W. Comparing the Economic, Energy, and Environmental Impacts of Biodiesel Versus Petroleum Diesel Fuel Use in Construction Equipment Int. J. Constr. Educ. Res. 15 2019 276 290 https://doi.org/10.1080/15578771.2018.1483982
- Sepasgozar , S.M.E. and Blair , J. Measuring Non-road Diesel Emissions in the Construction Industry: A Synopsis of the Literature Int. J. Constr. Manag. 0 2019 1 16 https://doi.org/10.1080/15623599.2019.1573479
- Tan , D. , Tan , J. , Peng , D. , Fu , M. et al. Study on Real-World Power-Based Emission Factors from Typical Construction Machinery Science of the Total Environment 799 2021 149436
- Frey , H.C. , Kangwook , K. , Pang , H.-S. , Rasdorf , W. et al. Characterization of Real-World Activity, Fuel Use, and Emissions for Selected Motor Graders Fueled with Petroleum Diesel and B20 Biodiesel J. Air Waste Manage. Assoc. 58 2008 1274e1284
- Frey , H.C. , Pang , H.-S. , and Rasdorf , W. Vehicle Emissions Modeling for 34 Off-road Construction Vehicles Based Upon Real-World On-board Measurements 18th CRC On-road Vehicle Emissions Workshop San Diego, CA April, 2008
- Frey , H.C. , Rasdorf , W. , Kim , K. , Pang , H.-S. et al. Comparison of Real-World Emissions of B20 Biodiesel Versus Petroleum Diesel for Selected Non-road Vehicles and Engine Tiers Transp. Res. Rec. 33e42 2058 2010
- Frey , H.C. , Rasdorf , W. , and Lewis , P. Comprehensive Field Study of Fuel Use and Emissions of Nonroad Diesel Construction Equipment Transp. Res. Rec. 2158 2010 69e76
- Lewis , P. , Leming , M. , Frey , H.C. , and Rasdorf , W. Assessing Effects of Operational Efficiency on Pollutant Emissions of Nonroad Diesel Construction Equipment Transp. Res. Rec. 2233 2011 11 18
- Abolhasani , S. , Frey , H.C. , Kim , K. , Rasdorf , W. et al. Real-World In-use Activity, Fuel Use, and Emissions for Nonroad Construction Vehicles: A Case Study for Excavators Journal of the Air and Waste Management Association 58 8 2008 1033 1046 https://doi.org/10.3155/1047-3289.58.8.1033
- Fu , M. , Ge , Y. , Tan , J. , Zeng , T. et al. Characteristics of Typical Non-road Machinery Emissions in China by Using Portable Emission Measurement System Science of the Total Environment 437 x 2012 255 261 https://doi.org/10.1016/j.scitotenv.2012.07.095
- Cao , T. , Durbin , T.D. , Russell , R.L. et al. Evaluations of In-use Emission Factors from Off-road Construction Equipment Atmospheric Environment 147 x 2016 234 245 https://doi.org/10.1016/j.atmosenv.2016.09.042
- Desouza , C.D. , Marsh , D.J. , Beevers , S.D. , Molden , N. et al. Real-World Emissions from Non-road Mobile Machinery in London Atmospheric Environment 223 January 2020 117301 https://doi.org/10.1016/j.atmosenv.2020.117301
- Miller , W. , Johnson , K.C. , Durbin , T. , and Dixit , P. In-use Emissions Testing and Demonstration of Retrofit Technology for Control of On-road Heavy-Duty Engines Final Report by University of California, Riverside to the South Coast Air Quality Management District Under Contract No. 11612 Sep 2013
- Misra , C. , Collins , J.F. , Herner , J.D. et al. In-use NOx Emissions from Model Year 2010 and 2011 Heavy- Duty Diesel Engines Equipped with Aftertreatment Devices Environ. Sci. Technol. 47 14 2013 7892 7898
- California Air Resources Board https://www.arb.ca.gov/msei/downloads/emfac2014/emfac2014-vol3-technical-documentation-052015.pdf
- Quiros , D.C. , Ham , W.A. , Ianni , R. , and Smith , J.D. Assessing Emission Control System Durability Using ARB's Pilot Heavy-Duty Truck and Bus Surveillance Program Presentation at the 27th CRC Real World Emissions Workshop Long Beach, CA March, 2017
- Jiang , Y. , Yang , J. , Cocker , D. , Karavalakis , G. et al. Characterizing Emission Rates of Regulated Pollutants from Model Year 2012 + Heavy-Duty Diesel Vehicles Equipped with DPF and SCR Systems Science of the Total Environment 619-620 2018 765 771 https://doi.org/10.1016/j.scitotenv.2017.11.120
- Khan , A.S. , Clark , N.N. , Gautam , M. , Wayne , W.S. et al. Idle Emissions from Medium Heavy-Duty Diesel and Gasoline Trucks Journal of the Air and Waste Management Association 59 3 2009 354 359 https://doi.org/10.3155/1047-3289.59.3.354
- California Air Resource Board https://ww2.arb.ca.gov/capp-resource-center/heavy-duty-diesel-vehicle-idling-information
- Lewis , P. , Leming , M. , Rasdorf , W. et al. Impact of Engine Idling on Fuel Use and CO2 Emissions of Nonroad Diesel Construction Equipment Journal of Management in Engineering 28 1 2012 31 38 https://doi.org/10.1061/(asce)me.1943-5479.0000068
- Bermúdez , V. , Lujan , J.M. , Pla , B. , and Linares , W.G. Effects of Low Pressure Exhaust Gas Recirculation on Regulated and Unregulated Gaseous Emissions During NEDC in a Light-Duty Diesel Engine Energy 36 9 2012 5655 5665 https://doi.org/10.1016/j.energy.2011.06.061
- Ko , J. , Si , W. , Jin , D. , Myung , C.L. et al. Effect of Active Regeneration On Time-Resolved Characteristics of Gaseous Emissions and Size-Resolved Particle Emissions from Light-Duty Diesel Engine Journal of Aerosol Science 91 x 2016 62 77 https://doi.org/10.1016/j.jaerosci.2015.09.007
- Mendoza-Villafuerte , P. , Suarez-Bertoa , R. , Giechaskiel , B. , Riccobono , F. et al. NOx, NH3, N2O and PN Real Driving Emissions from a Euro VI Heavy-Duty Vehicle. Impact of Regulatory On-road Test Conditions on Emissions Science of the Total Environment 609 x 2017 546 555 https://doi.org/10.1016/j.scitotenv.2017.07.168
- McCaffery , C. , Zhu , H. , Tang , T. , Li , C. et al. Real-world NOx emissions from heavy-duty diesel, natural gas, and diesel hybrid electric vehicles of different vocations on California roadways Science of the Total Environment 784 2021 147224 https://doi.org/10.1016/j.scitotenv.2021.147224