This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Characterization of Methane Emissions from a Natural Gas-Fuelled Marine Vessel under Transient Operation
Technical Paper
2021-01-0631
ISSN: 0148-7191, e-ISSN: 2688-3627
This content contains downloadable datasets
Annotation ability available
Sector:
Event:
SAE WCX Digital Summit
Language:
English
Abstract
Natural gas is an increasingly attractive fuel for marine applications due to its abundance, lower cost, and reduced CO2, NOx, SOx, and particulate matter (PM) emissions relative to conventional fuels such as diesel. Methane in natural gas is a potent greenhouse gas (GHG) and must be monitored and controlled to minimize GHG emissions. In-use GHG emissions are commonly estimated from emission factors based on steady state engine operation, but these do not consider transient operation which has been noted to affect other pollutants including PM and NOx. This study compares methane emissions from a coastal marine vessel during transient operation to those expected based on steady state emission factors.
The exhaust methane concentration from a diesel pilot-ignited, low pressure natural gas-fuelled engine was measured with a wavelength modulation spectroscopy system, during periods of increasing and decreasing engine load (between 3 and 90%). Methane concentration, methane emissions, and excess air ratio were compared to steady state conditions. Load increases resulted in similar exhaust methane concentrations relative to steady state values (within 8%). In contrast, decreasing engine load increased the exhaust methane concentration up to 1.9-times relative to equivalent steady-load values and showed total methane emissions up to 43% higher over the transient duration. However, the marine vessel considered here, operated at steady load approximately 91% of the time and the transient CH4 emissions will have only a negligible impact on the total in-use GHG emission (1.7% increase). This indicates that while transient operation does affect CH4 emissions, the uncertainty introduced in using steady state emissions factors for the considered load cycles is negligible for ships that mostly operate at steady load. Moreover, the load transitions during which CH4 concentration was measured were more aggressive than what is experienced routinely during sailings. The transient measurements indicated the need for CH4 emission reduction control strategies, particularly for transients with load reductions.
Recommended Content
Authors
Citation
Cohen Sacal, D., Corbin, J., Gagné, S., Penner, H. et al., "Characterization of Methane Emissions from a Natural Gas-Fuelled Marine Vessel under Transient Operation," SAE Technical Paper 2021-01-0631, 2021, https://doi.org/10.4271/2021-01-0631.Data Sets - Support Documents
Title | Description | Download |
---|---|---|
Unnamed Dataset 1 |
Also In
References
- U.S. Energy Information Administration International Energy Outlook 2019 https://www.eia.gov/outlooks/ieo/pdf/ieo2019.pdf Oct. 2020
- U.S. Energy Information Administration U.S. Marketed Natural Gas Production https://www.eia.gov/dnav/ng/hist/n9050us2a.htm Oct. 2020
- Natural Resources Canada Natural Gas Facts https://www.nrcan.gc.ca/science-data/data-analysis/energy-data-analysis/energy-facts/natural-gas-facts/20067 Oct. 2020
- U.S. Department of Energy Clean Cities Alternative Fuel Price Report https://afdc.energy.gov/files/u/publication/alternative_fuel_price_report_april_2020.pdf Oct. 2020
- International Maritime Organization Amendments to the Technical Code on Control of Emission of Nitrogen Oxides From Marine Diesel Engines MEPC 177 58 2008
- International Maritime Organization 2019 Guidelines for Consistent Implementation of the 0.50% Sulphur Limit Under MARPOL Annex VI MEPC 320 74 2017
- International Maritime Organization Energy Efficiency Measures https://www.imo.org/en/OurWork/Environment/Pages/Technical-and-Operational-Measures.aspx Oct. 2020
- Wei , L. and Geng , P. A Review on Natural Gas/Diesel Dual Fuel Combustion, Emissions and Performance Fuel Processing Technology 142 264 278 2016 10.1016/j.fuproc.2015.09.018
- Mohseni , S.A. , Hassel , E. , Sys , C. , and Vanelslander , T. Economic Evaluation of Alternative Technologies to Mitigate Sulphur Emissions in Maritime Container Transport from Both the Vessel Owner and Shipper perspective Journal of Shipping and Trade 4 15 1 27 2019 10.1186/s41072-019-0051-8
- U.S. Environmental Protection Agency Understanding Global Warming Potentials https://www.epa.gov/ghgemissions/understanding-global-warming-potentials Oct. 2020
- Ushakov , S. , Stenersen , D. , and Einang , P.M. Methane Slip from Gas Fuelled Ships: A Comprehensive Summary Based on Measurement Data Journal of Marine Science and Technology 24 4 1308 1325 2019 10.1007/s00773-018-00622-z
- Smith , T.W.P. , Jalkanen , J.P. , Anderson , B.A. , Corbett , J.J. et al. Third IMO Greenhouse Gas Study 2014 London International Maritime Organization 2015 27 57
- Karim , G.A. , Liu , Z. , and Jones , W. Exhaust Emissions from Dual Fuel Engines at Light Load SAE Technical Paper 932822 1993 https://doi.org/10.4271/932822
- Sommer , D.E. , Yeremi , M. , Son , J. , Corbin , J.C. et al. Characterization and Reduction of In-Use CH4 Emissions from a Dual Fuel Marine Engine Using Wavelength Modulation Spectroscopy Environmental Science and Technology 53 5 2892 2899 2019 10.1021/acs.est.8b04244
- Sommer , D. , Kirchen , P. , and Penner , H. Characterization and Reduction Strategies for GHG Emission from an LNG-Powered Coastal Vessel CIMAC Congress Paper No. 473 Vancouver 2019
- Giakoumis , E.G. Review of Some Methods for Improving Transient Response in Automotive Diesel Engines through Various Turbocharging Configurations Frontiers in Mechanical Engineering 2 4 1 18 2016 10.3389/fmech.2016.00004
- CIMAC Gas Engines Position Paper Transient Response Behaviour of Gas Engine Apr. 2011
- Son , J. Development of a Fast Methane Sensor Based on Wavelength Modulation Spectroscopy for Exhaust Methane Emission Measurement 2019 10.14288/1.0384580