This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
A Study on Combustion Characteristics of a High Compression Ratio SI Engine with High Pressure Gasoline Injection
Technical Paper
2019-24-0106
ISSN: 0148-7191, e-ISSN: 2688-3627
This content contains downloadable datasets
Annotation ability available
Sector:
Language:
English
Abstract
In order to improve thermal efficiency of spark ignition (SI) engines, an improved technology to avoid irregular combustion under high load conditions of high compression ratio SI engines is required. In this study, the authors focused on high pressure gasoline direct injection in a high compression ratio SI engine, which its rapid air-fuel mixture formation, turbulence, and flame speed, are enhanced by high-speed fuel spray jet. Effects of fuel injection pressure, injection and spark ignition timing on combustion characteristics were experimentally and numerically investigated. It was found that the heat release rate was drastically increased by raising the fuel injection pressure. The numerical simulation results show that the high pressure gasoline direct injection enhanced small-scale turbulent intensity and fuel evaporation, simultaneously. These two effects were considered as the main factors to increase the flame propagation speed, suggesting a new combustion concept different from conventional SI combustion controlled by in-cylinder bulk flow. This combustion method enables the delay of fuel injection and spark ignition timing up to near top dead center (TDC) which leads to avoid pre-ignition and knocking by shortening the end-gas reaction time. Therefore, it was shown that the irregular combustion in a high compression ratio SI engine could be avoided by utilizing high pressure gasoline injection, which leads to improve partial load thermal efficiency without affecting the high load performance.
Recommended Content
Authors
Topic
Citation
Kaminaga, T., Yamaguchi, K., Ratnak, S., Kusaka, J. et al., "A Study on Combustion Characteristics of a High Compression Ratio SI Engine with High Pressure Gasoline Injection," SAE Technical Paper 2019-24-0106, 2019, https://doi.org/10.4271/2019-24-0106.Data Sets - Support Documents
Title | Description | Download |
---|---|---|
Unnamed Dataset 1 | ||
Unnamed Dataset 2 | ||
Unnamed Dataset 3 | ||
Unnamed Dataset 4 | ||
Unnamed Dataset 5 | ||
Unnamed Dataset 6 | ||
Unnamed Dataset 7 | ||
Unnamed Dataset 8 | ||
Unnamed Dataset 9 | ||
Unnamed Dataset 10 | ||
Unnamed Dataset 11 |
Also In
References
- Yamakawa , M. , Youso , T. , Fujikawa , T. , Nishimoto , T. et al. Combustion Technology Development for a High Compression Ratio SI Engine SAE Int. J. Fuels Lubr. 5 1 98 105 2012 10.4271/2011-01-1871
- Moteki , K. , Aoyama , S. , Ushijima , K. , Hiyoshi , R. et al. A Study of a Variable Compression Ratio System with a Multi-Link Mechanism SAE Technical Paper 2003-01-0921 2003 10.4271/2003-01-0921
- Kleeberg , H. , Tomazic , D. , Dohmen , J. , Wittek , K. et al. Increasing Efficiency in Gasoline Powertrains with a Two-Stage Variable Compression Ratio (VCR) System SAE Technical Paper 2013-01-0288 2013 10.4271/2013-01-0288
- Maricq , M. , Podsiadlik , D. , Brehob , D. , and Haghgooie , M. Particulate Emissions from a Direct-Injection Spark-Ignition (DISI) Engine SAE Technical Paper 1999-01-1530 1999 10.4271/1999-01-1530
- Couet , S. , Higelin , P. , and Moreau , B. APIR: A New Firing Concept for the Internal Combustion Engines - Sensitivity to Knock and In-Cylinder Aerodynamics SAE Technical Paper 2001-01-1954 2001 10.4271/2001-01-1954
- Attard , W. , Blaxill , H. , Anderson , E. , and Litke , P. Knock Limit Extension with a Gasoline Fueled Pre-Chamber Jet Igniter in a Modern Vehicle Powertrain SAE Int. J. Engines 5 3 1201 1215 2012 10.4271/2012-01-1143
- Iwamoto , Y. , Noma , K. , Nakayama , O. , Yamauchi , T. et al. Development of Gasoline Direct Injection Engine SAE Technical Paper 970541 1997 10.4271/970541
- Zhao , F. , Lai , M. , and Harrington , D. A Review of Mixture Preparation and Combustion Control Strategies for Spark-Ignited Direct-Injection Gasoline Engines SAE Technical Paper 970627 1997 10.4271/970627
- Ellies , B. , Schenk , C. , and Dekraker , P. Benchmarking and Hardware-in-the-Loop Operation of a 2014 MAZDA Sky Activ 2.0L 13: 1 Compression Ratio Engine SAE Technical Paper 2016-01-1007 2016 10.4271/2016-01-1007
- Schumann , F. , Kubach , H. and Spicher , U. The Influence of Injection Pressures of up to 800 bar on Catalyst Heating Operation in Gasoline International Symposium COMODIA 2012 Fukuoka 603 608 2012
- Medina , M. , Fatouraie , M. , and Wooldridge , M. High-Speed Imaging Studies of Gasoline Fuel Sprays at Fuel Injection Pressures from 300 to 1500 bar SAE Technical Paper 2018-01-0294 2018 10.4271/2018-01-0294
- Yamaguchi , A. , Koopmans , L. , Helmantel , A. , Karrholm , F. et al. Spray Characterization of Gasoline Direct Injection Sprays Under Fuel Injection Pressures up to 150 MPa with Different Nozzle Geometries SAE Technical Paper 2019-01-0063 2019 10.4271/2019-01-0063
- Heywood , J. Internal Combustion Engine Fundamentals New York McGraw-Hill 1988
- Woschni , G. A Universally Applicable Equation for the Instantaneous Heat Transfer Coefficient in the Internal Combustion Engine SAE Technical Paper 670931 1967 10.4271/670931
- Ellies , B. , Schenk , C. , and Dekraker , P. Benchmarking and Hardware-in-the-Loop Operation of a 2014 MAZDA SkyActiv 2.0L 13:1 Compression Ratio Engine SAE Technical Paper 2016-01-1007 2016 10.4271/2016-01-1007
- Livengood , J. and Wu , P. Correlation of Autoignition Phenomena in Internal Combustion Engines and Rapid Compression Machines International Symposium on Combustion 5 1 347 356 1955 10.1016/S0082-0784(55)80047-1
- He , X. , Donovan , M. , Zigler , B. , Palmer , T. et al. An Experimental and Modeling Study of ISO-Octane Ignition Delay Times Under Homogeneous Charge Compression Ignition Conditions Combustion and Flame 142 3 266 275 2005
- Suzuki , M. , Nishida , K. , and Hiroyasu , H. Simultaneous Concentration Measurement of Vapor and Liquid in an Evaporating Diesel Spray SAE Technical Paper 930863 1993 10.4271/930863
- Yamakawa , M. , Takaki , D. , Li , T. , Zhang , Y. et al. Quantitative Measurement of Liquid and Vapor Phase Concentration Distributions in a D.I. Gasoline Spray by the Laser Absorption Scattering (LAS) Technique SAE Technical Paper 2002-01-1644 2002 10.4271/2002-01-1644
- Gao , J. and Nishida , K. Laser Absorption-Scattering Technique Applied to Asymmetric Evaporating Fuel Sprays for Simultaneous Measurement of Vapor/Liquid Mass Distributions Applied Physics B 101 433 443 2010 10.1007/s00340-010-4059-x
- Amsden , A. , O’Rourke , P. , and Butler , T. 1989
- Amsden , A. 1993
- Torres , D. and Trujillo , M. KIVA-4: An Unstructured ALE Code for Compressible Gas Flow with Sprays Journal of Computational Physics 219 2 943 975 2006 10.1016/j.jcp.2006.07.006
- Beale , J. and Reitz , R. Modeling Spray Atomization with the Kelvin-Helmholtz/Rayleigh-Taylor Hybrid Model Atomization and Sprays 9 6 623 650 1999 10.1615/AtomizSpr.v9.i6.40
- Marble , F. and Broadwell , J. 1977
- Poinsot , T. , Haworth , D. , and Bruneaux , G. Direct Simulation and Modeling of Flame-Wall Interaction for Premixed Turbulent Combustion Combustion and Flame 95 1-2 1993 10.1016/0010-2180(93)90056-9
- Meneveau , C. and Poinsot , T. Stretching and Quenching of Flamelets in Premixed Turbulent Combustion Combustion and Flame 86 4 311 332 1991 10.1016/0010-2180(91)90126-V
- Zhuang , H. , Sick , V. , and Chen , H. Impact of Fuel Sprays on In-Cylinder Flow Length Scales in a Spark-Ignition Direct-Injection Engine SAE Int. J. Engines 10 3 752 766 2017 10.4271/2017-01-0618
- Wiese , W. , Pischinger , S. , Adomeit , P. , and Ewald , J. Prediction of Combustion Delay and -Duration of Homogeneous Charge Gasoline Engines based on In-Cylinder Flow Simulation SAE Technical Paper 2009-01-1796 2009 10.4271/2009-01-1796
- Hayakawa , A. , Miki , Y. , Nagano , Y. , and Kitagawa , T. Analysis of Turbulent Burning Velocity of Spherically Propagating Premixed Flame with Effective Turbulence Intensity Journal of Thermal Science and Technology 7 4 507 521 2012 10.1299/jtst.7.507
- Boudier , P. , Henriot , S. , Poinsot , T. , and Baritaud , T. A model for turbulent flame ignition and propagation in spark ignition engines International Symposium on Combustion 24 1 503 510 1992 10.1016/S0082-0784(06)80064-0
- Ratnak , S. , Kusaka , J. , and Daisho , Y. 3D Simulations on Premixed Laminar Flame Propagation of iso-Octane/Air Mixture at Elevated Pressure and Temperature SAE Technical Paper 2015-01-0015 2015 10.4271/2015-01-0015
- Metghalchi , M. and Keck , J. Burning Velocities of Mixtures of Air with Methanol, Isooctane, and Indolene at High Pressure and Temperature Combustion and Flame 48 191 210 1982 10.1016/0010-2180(82)90127-4
- Gülder , Ö. Correlations of Laminar Combustion Data for Alternative S.I. Engine Fuels SAE Technical Paper 841000 1984 10.4271/841000
- Mehl , M. , Pitz , W. , Westbrook , C. , and Curran , H. Kinetic Modeling of Gasoline Surrogate Components and Mixtures under Engine Conditions Proceedings of the Combustion Institute 33 1 193 200 2011 10.1016/j.proci.2010.05.027
- Yamazaki , H. , Beini , Z. , Kusaka , J. , Ishii , Y. , et al. A Numerical Study on A Natural Gas Engine Ignited by Pilot Diesel Fuel JSAE Annual Congress Spring Proceedings 2017
- Damköhler , G. The Effect of Turbulence on the Combustion Rate in Gas Compounds Zeitschrift für Elektrochemie und Angew. Phys. Chemie 46 11 601 626 1940
- Kaminaga , T. , Kikusato , A. , Beini , Z. , Morii , Y. et al. Large Eddy Simulation and Analysis of Cycle-by-Cycle Variations in a Spark Ignition Gasoline Engine Transactions of Society of Automotive Engineers of Japan 50 1 19 24 2019 10.11351/jsaeronbun.50.19
- Hill , P. Cyclic Variations and Turbulence Structure in Spark-Ignition Engines Combustion and Flame 72 73 89 1988 10.1016/0010-2180(88)90098-3
- Hill , P. and Kapil , A. The Relationship Between Cyclic Variations in Spark-Ignition Engines and the Small Structure of Turbulence Combustion and Flame 78 237 247 1989 10.1016/0010-2180(89)90128-4
- Ting , D. , Checkel , M. , and Johansson , B. The Importance of High-Frequency, Small-Eddy Turbulence in Spark Ignited, Premixed Engine Combustion SAE Technical Paper 952409 1995 10.4271/952409
- Ting , D. and Checkel , M.D. The importance of turbulence intensity, eddy size and flame size in spark ignited, premixed flame growth Proceedings of the Institution of Mechanical Engineers, Part D 211 1 83 86 1997 10.1243/0954407971526245
- Wakuri , Y. , Fujii , M. , Amitani , T. , and Tsuneya , R. Studies on the Penetration of Fuel Spray in a Diesel Engine Bulletin of JSME 3 9 1960 10.1299/jsme1958.3.123