This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Effects of Single versus Two-Stage Heat Release on the Load Limits of HCCI Using Primary Reference Fuels
Technical Paper
2019-01-0950
ISSN: 0148-7191, e-ISSN: 2688-3627
This content contains downloadable datasets
Annotation ability available
Sector:
Language:
English
Abstract
Homogeneous Charge Compression Ignition (HCCI) enables combustion with high efficiency and low emissions. Control over the combustion process and its narrow operating range are still the biggest challenges associated with HCCI. To expand the operable load ranges of HCCI, this paper explores the effects of single versus two-stage ignition fuels by studying the Primary Reference Fuels (PRF) in a variable compression ratio Cooperative Fuel Research (CFR) engine. The PRF fuels, iso-octane and n-heptane, are blended together at various concentrations to create fuel blends with different autoignition characteristics. Experiments were conducted using these PRF blends to explore the extent to which the load range can be extended with two-stage ignition fuels at various compression ratios and intake temperatures. The reactivity of the PRF blends increases with the fraction of n-heptane and so does the amount of low temperature heat release (LTHR).
Since the low PRF number fuels have a higher reactivity, they can be autoignited at very low compression ratios while maintaining comparable combustion phasing and equivalence ratios. At the lower compression ratios, the low load limits were found to be extended while maintaining high combustion efficiencies. Additionally, lower peak pressures and pressure rise rates were achieved at low PRF number fuels as a result of its two-stage heat release, which can be used to reach higher loads. In addition, the energy released from the LTHR can be used to delay the CA50 combustion phasing (i.e., the crank angle timing where 50% of the energy has been released) beyond what is possible with a single-stage ignition fuel, which allows further high load extension. However, using lower compression ratios has a negative impact on the thermal efficiency. The effects of the extended load, single- and two-stage heat release, combustion phasing, and equivalence ratios on combustion efficiency, thermal efficiencies, and combustion durations were also explored.
Recommended Content
Authors
Citation
Hariharan, D., Yang, R., Mamalis, S., and Lawler, B., "Effects of Single versus Two-Stage Heat Release on the Load Limits of HCCI Using Primary Reference Fuels," SAE Technical Paper 2019-01-0950, 2019, https://doi.org/10.4271/2019-01-0950.Data Sets - Support Documents
Title | Description | Download |
---|---|---|
Unnamed Dataset 1 | ||
Unnamed Dataset 2 | ||
Unnamed Dataset 3 | ||
Unnamed Dataset 4 | ||
Unnamed Dataset 5 |
Also In
References
- Dec , J.E. , Hwang , W. , and Sjöberg , M. An Investigation of Thermal Stratification in HCCI Engines using Chemiluminescence Imaging SAE Technical Paper 2006-01-1518 2006 10.4271/2006-01-1518
- Sjöberg , M. , Dec , J.E. , and Cernansky , N.P. Potential of Thermal Stratification and Combustion Retard for Reducing Pressure-Rise Rates in HCCI Engines, Based on Multi-Zone Modeling and Experiments SAE Technical Paper 2005-01-0113 2005 10.4271/2005-01-0113
- Flowers , D.L. , Aceves , S.M. , Martinez-Frias , J. , and Dibble , R.W. Prediction of Carbon Monoxide and Hydrocarbon Emissions in Iso-Octane HCCI Engine Combustion Using Multizone Simulations Proceedings of the Combustion Institute 29 1 687 694 2002
- Jun , D. , Ishii , K. , and Iida , N. Combustion Analysis of Natural Gas in a Four Stroke HCCI Engine Using Experiment and Elementary Reactions Calculation SAE Technical Paper 2003-01-1089 2003 10.4271/2003-01-1089
- Battin-Leclerc , F. Detailed Chemical Kinetic Models for the Low-Temperature Combustion of Hydrocarbons with Application to Gasoline and Diesel Fuel Surrogates Progress in Energy and Combustion Science 34 4 440 498 2008
- Zádor , J. , Taatjes , C.A. , and Fernandes , R.X. Kinetics of Elementary Reactions in Low-Temperature Autoignition Chemistry Progress in Energy and Combustion Science 37 4 371 421 2011
- Lawler , B. , Hoffman , M. , Filipi , Z. , Güralp , O. et al. Development of a Postprocessing Methodology for Studying Thermal Stratification in an HCCI Engine Journal of Engineering for Gas Turbines and Power 134 10 102801 2012
- Lawler , B. , Lacey , J. , Güralp , O. , Najt , P. et al. HCCI Combustion with an Actively Controlled Glow Plug: The Effects on Heat Release, Thermal Stratification, Efficiency, and Emissions Applied Energy 211 809 819 2018
- Komninos , N.P. The Effect of Thermal Stratification on HCCI Combustion: A Numerical Investigation Applied Energy 139 291 302 2015
- Dec , J.E. and Hwang , W. Characterizing the Development of Thermal Stratification in an HCCI Engine Using Planar-Imaging Thermometry SAE Int. J. Engines 2 1 421 438 2009 10.4271/2009-01-0650
- Dronniou , N. and Dec , J. Investigating the Development of Thermal Stratification from the Near-Wall Regions to the Bulk-Gas in an HCCI Engine with Planar Imaging Thermometry SAE Int. J. Engines 5 3 1046 1074 2012 10.4271/2012-01-1111
- Sjöberg , M. and Dec , J.E. Effects of Engine Speed, Fueling Rate, and Combustion Phasing on the Thermal Stratification Required to Limit HCCI Knocking Intensity SAE Technical Paper 2005-01-2125 2005 10.4271/2005-01-2125
- Dec , J.E. Advanced Compression-Ignition Engines-Understanding the In-Cylinder Processes Proceedings of the Combustion Institute 32 2 2727 2742 2009
- Saxena , S. and Bedoya , I.D. Fundamental Phenomena Affecting Low Temperature Combustion and HCCI Engines, High Load Limits, and Strategies for Extending these Limits Progress in Energy and Combustion Science 39 5 457 488 2013
- Dec , J.E. , Hwang , W. , and Sjöberg , M. An Investigation of Thermal Stratification in HCCI Engines using Chemiluminescence Imaging SAE Technical Paper 2006-01-1518 2006 10.4271/2006-01-1518
- Sjöberg , M. , Dec , J.E. , Babajimopoulos , A. , and Assanis , D.N. Comparing Enhanced Natural Thermal Stratification against Retarded Combustion Phasing for Smoothing of HCCI Heat-Release Rates SAE Technical Paper 2004-01-2994 2004 10.4271/2004-01-2994
- Dec , J.E. and Hwang , W. Characterizing the Development of Thermal Stratification in an HCCI Engine Using Planar-Imaging Thermometry SAE Int. J. Engines 2 1 421 438 2009 10.4271/2009-01-0650
- Sjöberg , M. , Dec , J.E. , and Cernansky , N.P. Potential of Thermal Stratification and Combustion Retard for Reducing Pressure-Rise Rates in HCCI Engines, Based on Multi-Zone Modeling and Experiments SAE Technical Paper 2005-01-0113 2005 10.4271/2005-01-0113
- Lawler , B. , Splitter , D. , Szybist , J. , and Kaul , B. Thermally Stratified Compression Ignition: A New Advanced Low Temperature Combustion Mode with Load Flexibility Applied Energy 189 122 132 2017
- Rahimi Boldaji , M. , Sofianopoulos , A. , Mamalis , S. , and Lawler , B. Computational Fluid Dynamics Investigations of the Effect of Water Injection Timing on Thermal Stratification and Heat Release in Thermally Stratified Compression Ignition Combustion International Journal of Engine Research 2018
- Boldaji , M.R. , Sofianopoulos , A. , Mamalis , S. , and Lawler , B. Effects of Mass, Pressure, and Timing of Injection on the Efficiency and Emissions Characteristics of TSCI Combustion with Direct Water Injection SAE Technical Paper 2018-01-0178 2018 10.4271/2018-01-0178
- Gainey , B. , Hariharan , D. , Yan , Z. , Zilg , S. et al. A Split Injection of Wet Ethanol to Enable Thermally Stratified Compression Ignition International Journal of Engine Research 2018
- Boldaji , M.R. , Gainey , B. , and Lawler , B. Thermally Stratified Compression Ignition Enabled by Wet Ethanol with a Split Injection Strategy: A CFD Simulation Study Applied Energy 235 813 826 2019
- Sjöberg , M. and Dec , J.E. Combined Effects of Fuel-Type and Engine Speed on Intake Temperature Requirements and Completeness of Bulk-Gas Reactions for HCCI Combustion SAE Technical Paper 2003-01-3173 2003 10.4271/2003-01-3173
- Sjoberg , M. and Dec , J.E. Ethanol Autoignition Characteristics and HCCI Performance for Wide Ranges of Engine Speed, Load, and Boost SAE Int. J. Engines 3 1 84 106 2010 10.4271/2010-01-0338
- Dec , J.E. and Yang , Y. Boosted HCCI for High Power without Engine Knock and with Ultra-Low NOx Emissions-Using Conventional Gasoline SAE Int. J. Engines 3 1 750 767 2010 10.4271/2010-01-1086
- Dec , J.E. , Yang , Y. , and Dronniou , N. Improving Efficiency and Using E10 for Higher Loads in Boosted HCCI Engines SAE Int. J. Engines 5 3 1009 1032 2012 10.4271/2012-01-1107
- Wolk , B. and Chen , J.Y. Computational Study of Partial Fuel Stratification for HCCI Engines Using Gasoline Surrogate Reduced Mechanism Combustion Science and Technology 186 3 332 354 2014
- Inagaki , K. , Fuyuto , T. , Nishikawa , K. , Nakakita , K. et al. Dual-Fuel PCI Combustion Controlled by In-Cylinder Stratification of Ignitability SAE Technical Paper 2006-01-0028 2006 10.4271/2006-01-0028
- Wada , Y. and Senda , J. Demonstrating the Potential of Mixture Distribution Control for Controlled Combustion and Emissions Reduction in Premixed Charge Compression Ignition Engines SAE Technical Paper 2009-01-0498 2009 10.4271/2009-01-0498
- Dahl , D. , Andersson , M. , Berntsson , A. , Denbratt , I. et al. Reducing Pressure Fluctuations at High Loads by Means of Charge Stratification in HCCI Combustion with Negative Valve Overlap SAE Technical Paper 2009-01-1785 2009 10.4271/2009-01-1785
- Yang , Y. , Dec , J. , Dronniou , N. , and Cannella , W. Boosted HCCI Combustion Using Low-Octane Gasoline with Fully Premixed and Partially Stratified Charges SAE Int. J. Engines 5 3 1075 1088 2012 10.4271/2012-01-1120
- Dec , J.E. and Sjöberg , M. Isolating the Effects of Fuel Chemistry on Combustion Phasing in an HCCI Engine and the Potential of Fuel Stratification for Ignition Control SAE Technical Paper 2004-01-0557 2004 10.4271/2004-01-0557
- Dec , J.E. , Yang , Y. , and Dronniou , N. Boosted HCCI-Controlling Pressure-Rise Rates for Performance Improvements Using Partial Fuel Stratification with Conventional Gasoline SAE Int. J. Engines 4 1 1169 1189 2011 10.4271/2011-01-0897
- Yang , Y. , Dec , J.E. , Dronniou , N. , and Sjöberg , M. Tailoring HCCI Heat-Release Rates with Partial Fuel Stratification: Comparison of Two-Stage and Single-Stage-Ignition Fuels Proceedings of the Combustion Institute 33 2 3047 3055 2011
- Sjöberg , M. and Dec , J.E. Smoothing HCCI Heat-Release Rates Using Partial Fuel Stratification with Two-Stage Ignition Fuels SAE Technical Paper 2006-01-0629 2006 10.4271/2006-01-0629
- Tanaka , S. , Ayala , F. , Keck , J.C. , and Heywood , J.B. Two-Stage Ignition in HCCI Combustion and HCCI Control by Fuels and Additives Combustion and Flame 132 1-2 219 223 2003
- Cox , R.A. and Cole , J.A. Chemical Aspects of the Autoignition of Hydrocarbon-Air Mixtures Combustion and Flame 60 2 109 123 1985
- Hessel , R.P. , Foster , D.E. , Aceves , S.M. , Davisson , M.L. et al. Modeling Iso-Octane HCCI using CFD with Multi-Zone Detailed Chemistry; Comparison to Detailed Speciation Data Over a Range of Lean Equivalence Ratios SAE Technical Paper 2008-01-0047 2008 10.4271/2008-01-0047
- Yang , R. , Hariharan , D. , Zilg , S. , Lawler , B. et al. Efficiency and Emissions Characteristics of an HCCI Engine Fueled by Primary Reference Fuels SAE Technical Paper 2018-01-1255 2018 10.4271/2018-01-1255
- Zheng , J. , Yang , W. , Miller , D.L. , and Cernansky , N.P. Prediction of Pre-Ignition Reactivity and Ignition Delay for HCCI using a Reduced Chemical Kinetic Model SAE Technical Paper 2001-01-1025 2001 10.4271/2001-01-1025
- Epping , K. , Aceves , S. , Bechtold , R. , and Dec , J.E. The Potential of HCCI Combustion for High Efficiency and Low Emissions SAE Technical Paper 2002-01-1923 2002 10.4271/2002-01-1923
- Tanaka , S. , Ayala , F. , and Keck , J.C. A Reduced Chemical Kinetic Model for HCCI Combustion of Primary Reference Fuels in a Rapid Compression Machine Combustion and Flame 133 4 467 481 2003
- Shibata , G. , Oyama , K. , Urushihara , T. , and Nakano , T. The Effect of Fuel Properties on Low and High Temperature Heat Release and Resulting Performance of an HCCI Engine SAE Technical Paper 2004-01-0553 2004 10.4271/2004-01-0553
- Vuilleumier , D. , Atef , N. , Kukkadapu , G. , Wolk , B. et al. The Influence of Intake Pressure and Ethanol Addition to Gasoline on Single-and Dual-Stage Autoignition in an HCCI Engine Energy & Fuels 32 9 9822 9837 2018
- Sjöberg , M. and Dec , J.E. Comparing Late-Cycle Autoignition Stability for Single-and Two-Stage Ignition Fuels in HCCI Engines Proceedings of the Combustion Institute 31 2 2895 2902 2007
- Brettschneider , J. Extension of the Equation for Calculation of the Air-Fuel Equivalence Ratio SAE Technical Paper 972989 1997 10.4271/972989
- Chang , J. , Güralp , O. , Filipi , Z. , Assanis , D.N. et al. New Heat Transfer Correlation for an HCCI Engine Derived from Measurements of Instantaneous Surface Heat Flux SAE Technical Paper 2004-01-2996 2004 10.4271/2004-01-2996
- Goodwin , D.G. , Moffat , H.K. , and Speth , R.L. Cantera: An Object-Oriented Software Toolkit for Chemical Kinetics, Thermodynamics, and Transport Processes Pasadena, CA Caltech 2009
- Wang , H. , Yao , M. , and Reitz , R.D. Development of a Reduced Primary Reference Fuel Mechanism for Internal Combustion Engine Combustion Simulations Energy & Fuels 27 12 7843 7853 2013
- Lawler , B. , Joshi , S. , Lacey , J. , Guralp , O. et al. Understanding the Effect of Wall Conditions and Engine Geometry on Thermal Stratification and HCCI Combustion ASME 2014 Internal Combustion Engine Division Fall Technical Conference 2014 V001T03A020 V001T03A020
- Olsson , J.O. , Tunestål , P. , Johansson , B. , Fiveland , S. et al. Compression Ratio Influence on Maximum Load of a Natural Gas Fueled HCCI Engine SAE Technical Paper 2002-01-0111 2002 10.4271/2002-01-0111
- Kumar , K. , Mittal , G. , and Sung , C.J. Autoignition of N-Decane under Elevated Pressure and Low-to-Intermediate Temperature Conditions Combustion and Flame 156 6 1278 1288 2009
- Kumar , K. and Sung , C.J. An Experimental Study of the Autoignition Characteristics of Conventional Jet Fuel/Oxidizer Mixtures: Jet-A and JP-8 Combustion and Flame 157 4 676 685 2010
- Weber , B.W. , Kumar , K. , Zhang , Y. , and Sung , C.J. Autoignition of N-Butanol at Elevated Pressure and Low-to-Intermediate Temperature Combustion and Flame 158 5 809 819 2011