Try Mobilus Beta
Search tips
 This content is not included in your SAE MOBILUS subscription, or you are not logged in.

Knock Resistance and Fine Particle Emissions for Several Biomass-Derived Oxygenates in a Direct-Injection Spark-Ignition Engine

Journal Article
2016-01-0705
ISSN: 1946-3952, e-ISSN: 1946-3960
DOI: https://doi.org/10.4271/2016-01-0705
Published April 05, 2016 by SAE International in United States
Knock Resistance and Fine Particle Emissions for Several Biomass-Derived Oxygenates in a Direct-Injection Spark-Ignition Engine
Sector:
Citation: Ratcliff, M., Burton, J., Sindler, P., Christensen, E. et al., "Knock Resistance and Fine Particle Emissions for Several Biomass-Derived Oxygenates in a Direct-Injection Spark-Ignition Engine," SAE Int. J. Fuels Lubr. 9(1):59-70, 2016, https://doi.org/10.4271/2016-01-0705.
Language: English

References

  1. Intergovernmental Panel on Climate Change Fifth Assessment Report: Climate Change 2014: Mitigation of Climate Change http://www.ipcc.ch/report/ar5/wg3/ September 7 2014
  2. Lane , J. Biofuels Mandates Around the World: 2014 Biofuels Digest December 31 2013 http://www.biofuelsdigest.com/bdigest/2013/12/31/biofuels-mandates-around-the-world-2014/
  3. Energy Independence and Security Act of 2007 Renewable Fuel Standard December 19 2007
  4. U.S. Environmental Protection Agency EPA and NHTSA Set Standards to Reduce Greenhouse Gases and Improve Fuel Economy for Model Years 2017-2025 Cars and Light Trucks August 2012
  5. Fraser , N. , Blaxill , H. , Lumsden , G. , and Bassett , M. Challenges for Increased Efficiency through Gasoline Engine Downsizing SAE Int. J. Engines 2 1 991 1008 2009 10.4271/2009-01-1053
  6. Mittal , V. and Heywood , J. The Shift in Relevance of Fuel RON and MON to Knock Onset in Modern SI Engines Over the Last 70 Years SAE Int. J. Engines 2 2 1 10 2010 10.4271/2009-01-2622
  7. Stein , R. , Polovina , D. , Roth , K. , Foster , M. et al. Effect of Heat of Vaporization, Chemical Octane, and Sensitivity on Knock Limit for Ethanol-Gasoline Blends SAE Int. J. Fuels Lubr. 5 2 823 843 2012 10.4271/2012-01-1277
  8. Kalghatgi , G. Fuel Anti-Knock Quality- Part II. Vehicle Studies - How Relevant is Motor Octane Number (MON) in Modern Engines? SAE Technical Paper 2001-01-3585 2001 10.4271/2001-01-3585
  9. Mittal , V. , Heywood , J. , and Green , W. The Underlying Physics and Chemistry behind Fuel Sensitivity SAE Int. J. Fuels Lubr. 3 1 256 265 2010 10.4271/2010-01-0617
  10. Mittal , V. and Heywood , J. The Relevance of Fuel RON and MON to Knock Onset in Modern SI Engines SAE Technical Paper 2008-01-2414 2008 10.4271/2008-01-2414
  11. Price , P. , Stone , R. , Collier , T. , and Davies , M. Particulate Matter and Hydrocarbon Emissions Measurements: Comparing First and Second Generation DISI with PFI in Single Cylinder Optical Engines SAE Technical Paper 2006-01-1263 2006 10.4271/2006-01-1263
  12. Aakko , P. and Nylund , N. Particle Emissions at Moderate and Cold Temperatures Using Different Fuels SAE Technical Paper 2003-01-3285 2003 10.4271/2003-01-3285
  13. Aikawa , K. , Sakurai , T. , and Jetter , J. Development of a Predictive Model for Gasoline Vehicle Particulate Matter Emissions SAE Int. J. Fuels Lubr. 3 2 610 622 2010 10.4271/2010-01-2115
  14. State of California Air Resources Board Preliminary Discussion Paper-Proposed Amendments to California’s Low-Emission Vehicle Regulations-Particulate Matter Mass, Ultrafine Solid Particle Number, and Black Carbon Emissions State of California Air Resources Board Sacramento, CA 2010 http://www.arb.ca.gov/msprog/levprog/leviii/meetings/051810/pm_disc_paper-v6.pdf
  15. U.S. Environmental Protection Agency Integrated Science Assessment for Particulate Matter Final Report EPA/600/R-08/139F 2009
  16. Ramanathan , V. , and Carmichael , G. Global and Regional Climate Changes due to Black Carbon Nature Geoscience 1 221 227 2008 http://www.nature.com/ngeo/journal/v1/n4/full/ngeo156.html
  17. California Air Resources Board Attachment A-3, “California 2015 and Subsequent Model Criteria Pollutant Exhaust Emission Standards and Test Procedures and 2017 and Subsequent Model Greenhouse Gas Exhaust Emission Standards and Test Procedures for Passenger Cars, Light-Duty Trucks, and Medium-Duty Vehicles Amendments to the Low-Emission Vehicle Program - LEV III; California Air Resources Board 2012 http://www.arb.ca.gov/msprog/levprog/leviii/leviii.htm
  18. European Union Regulation 459/2012 Commission Regulation (EU) No. 459/2012 of 29 May 2012, Amending Regulation (EC) No. 715/2007 of the European Parliament and of the Council and Commission Regulation (EC) No 692/2008 as regards Emissions from Light Passenger and Commercial Vehicles (Euro VI) Off. J. Eur. Union 2012 L 142 16 24
  19. U.S. Environmental Protection Agency EPA Sets Tier 3 Tailpipe and Evaporative Emission and Vehicle Fuel Standards March 2014
  20. Aikawa , K. , and Jetter , J.J. Impact of Gasoline Composition on Particulate Matter Emissions from a Direct-Injection Engine: Applicability of Particulate Matter Index Int. J. Eng. Res. 15 3 298 306 2013 10.1177/1468087413481216 http://jer.sagepub.com/content/15/3/298.abstract
  21. Fatouraie , M. , Wooldridge , M. , and Wooldridge , S. In-Cylinder Particulate Matter and Spray Imaging of Ethanol/ Gasoline Blends in a Direct Injection Spark Ignition Engine SAE Int. J. Fuels Lubr. 6 1 1 10 2013 10.4271/2013-01-0259
  22. Maricq , M.M. , Szente , J.J. , and Jahr , K. The Impact of Ethanol Fuel Blends on PM Emissions from a Light-Duty GDI Vehicle Aerosol Science and Technology 46 5 576 583 2012 10.1080/02786826.2011.648780 http://www.tandfonline.com/doi/abs/10.1080/02786826.2011.648780
  23. He , X. , Ratcliff , M.A. , and Zigler , B.T. Effects of Gasoline Direct Injection Engine Operating Parameters on Particle Number Emissions Energy Fuels 26 4 2014 2027 2012 http://pubs.acs.org/doi/pdf/10.1021/ef201917p
  24. Anderson , J.E. , DiCicco , D.M. , Ginder , J.M. , Kramer , U. et al. High Octane Number Ethanol-Gasoline Blends: Quantifying the Potential Benefits in the United States Fuel 97 585 594 2012 10.1016/j.fuel.2012.03.017 http://www.sciencedirect.com/science/article/pii/S0016236112002268
  25. Stein , R. , Anderson , J. , and Wallington , T. An Overview of the Effects of Ethanol-Gasoline Blends on SI Engine Performance, Fuel Efficiency, and Emissions SAE Int. J. Engines 6 1 470 487 2013 10.4271/2013-01-1635
  26. U.S. Department of Energy 2011 U.S. Billion-Ton Update: Biomass Supply for a Bioenergy and Bioproducts Industry Perlack R.D. and Stokes B.J. Technical Report ORNL/TM-2011/224. Oak Ridge National Laboratory Oak Ridge, TN 227
  27. Humbird , D. , Davis , R. , Tao , L. , Kinchin , C. et al. Process Design and Economics for Biochemical Conversion of Lignocellulosic Biomass to Ethanol Dilute-Acid Pretreatment and Enzymatic Hydrolysis of Corn Stover Golden, CO National Renewable Energy Laboratory May 2011
  28. Arbogast , S. , Bellman , D. , Paynter , J.D. , and Wykowski , J. Advanced Bio-Fuels from Pyrolysis Oil: The Impact of Economies of Scale and Use of Existing Logistic and Processing Capabilities Fuel Proc. Techn. 104 121 127 2012 10.1016/j.fuproc.2012.04.036 http://www.sciencedirect.com/science/article/pii/S0378382012001658
  29. Arbogast , S. , Bellman , D. , Paynter , J.D. , and Wykowski , J. Advanced Biofuels from Pyrolysis Oil…Opportunities for Cost Reduction Fuel Proc. Techn. 106 518 525 2013 10.1016/j.fuproc.2012.09.022 http://www.sciencedirect.com/science/article/pii/S0378382012003384
  30. Talmadge , M.S. , Baldwin , R.M. , Biddy , M.J. , McCormick , R.L. et al. A Perspective on Oxygenated Species in the Refinery Integration of Pyrolysis Oil Green Chem. 16 407 453 2014 10.1039/C3GC41951G http://pubs.rsc.org/en/content/articlelanding/2014/gc/c3gc41951g#!divAbstract
  31. Christensen , E. , Chupka , G. , Luecke , J. , Alleman , T.L. et al. Analysis of Oxygenated Compounds in Hydrotreated Biomass Fast Pyrolysis Oil Distillate Fractions Energy Fuels 25 5462 5471 2011 http://pubs.acs.org/doi/pdf/10.1021/ef201357h
  32. Alonso , D.M. , Bond , J.Q , and Dumesic , J.A. Catalytic Conversion of Biomass to Biofuels Green Chem. 12 1493 1513 2010 10.1039/C004654J http://pubs.rsc.org/en/Content/ArticleLanding/2010/GC/c004654j#!divAbstract
  33. Roman-Leshkov , Y. , Barrett , C.J. , Liu , Z.Y. , and Dumesic , J. Production of Dimethylfuran for Liquid Fuels from Biomass-Derived Carbohydrates Nature 447 982 986 2007 10.1038/nature05923 http://www.nature.com/nature/journal/v447/n7147/full/nature05923.html
  34. Huber , G. , Iborra , S. , and Corma , A. Synthesis of Transportation Fuels from Biomass: Chemistry, Catalysts, and Engineering Chem. Rev . 106 9 4044 4098 2006 10.1021/cr068360d http://pubs.acs.org/doi/abs/10.1021/cr068360d
  35. Higashide , W. , Li , Y. , Yang , Y. , and Liao , J.C. Metabolic Engineering of Clostridium Cellulolyticum for Isobutanol Production from Cellulose Appl. Environ. Microbiol. 77 8 2727 2733 2011 10.1128/AEM.02454-10 http://aem.asm.org/content/77/8/2727.abstract
  36. McCormick , R.L. , Ratcliff , M. , Christensen , E. , Fouts , L. et al. Properties of Oxygenates Found in Upgraded Biomass Pyrolysis Oil as Components of Spark and Compression Ignition Engine Fuels Energy Fuels 29 4 2453 2461 2015 10.1021/ef502893g http://pubs.acs.org/doi/abs/10.1021/ef502893g
  37. Chupka , G. , Christensen , E. , Fouts , L. , Alleman , T. et al. Heat of Vaporization Measurements for Ethanol Blends Up To 50 Volume Percent in Several Hydrocarbon Blendstocks and Implications for Knock in SI Engines SAE Int. J. Fuels Lubr. 8 2 251 263 2015 10.4271/2015-01-0763
  38. Perry , R.H. , and Green , D.W. Perry's Chemical Engineers' Handbook. 7th McGraw-Hill 1999 2 346
  39. API Technical Data Book - Petroleum Refining Washington, DC American Petroleum Institute Publishing Services 1993
  40. Yaws , C.L. Yaws' Handbook of Thermodynamic and Physical Properties of Chemical Compounds: Physical, Thermodynamic and Transport Properties for 5,000 Organic Chemical Compounds McGraw-Hill 2003
  41. National Instruments, Combustion Analysis System Software for LabVIEW User Manual 162 http://digital.ni.com/manuals.nsf/websearch/C2B04021AA306BBB86257BCD007365C6
  42. AAM Alliance of Automobile Manufacturers North American Fuel Survey 2011
  43. Chickoos , J.S. , and Acree , W.E. Enthalpies of Vaporization of Organic and Organometallic Compounds, 1880-2002 J. Phys. Chem. Ref. Data 32 2 519 878 2003 http://dx.doi.org/10.1063/1.1529214
  44. Christensen , E. , Yanowitz , J. , Ratcliff , M. , and McCormick , R.L. Renewable Oxygenate Blending Effects on Gasoline Properties Energy Fuels 25 4723 4733 2011 http://pubs.acs.org/doi/pdf/10.1021/ef2010089
  45. API Technical Data Book - Petroleum Refining API 1993
  46. Material Safety Data Sheet www.sigmaaldrich.com December 14 2014
  47. Amer , A. , Babiker , H. , Chang , J. , Kalghatgi , G. et al. Fuel Effects on Knock in a Highly Boosted Direct Injection Spark Ignition Engine SAE Int. J. Fuels Lubr. 5 3 1048 1065 2012 10.4271/2012-01-1634
  48. Chen , L. , and Stone , R. Measurement of Enthalpies of Vaporization of Isooctane and Ethanol Blends and Their Effects on PM Emissions from a GDI Engine Energy Fuels 25 1254 1259 2011 http://pubs.acs.org/doi/pdf/10.1021/ef1015796
  49. Ratcliff , M. , Luecke , J. , Williams , A. , Christensen , E. et al. Impact of Higher Alcohols Blended in Gasoline on Light-Duty Vehicle Exhaust Emissions Environ. Sci. Technol. 47 23 13865 13872 2013 10.1021/es402793p http://pubs.acs.org/doi/abs/10.1021/es402793p
  50. Pecullan , M. , Brezinsky , K. , and Glassman , I. Pyrolysis and Oxidation of Anisole near 1000 K J. Phys. Chem. A 101 18 3305 3316 1997 10.1021/jp963203b http://pubs.acs.org/doi/abs/10.1021/jp963203b
  51. Scheer , A.M. , Mukarakate , C. , Robichaud , D.J. , Ellison , G.B. et al. Radical Chemistry in the Thermal Decomposition of Anisole and Deuterated Anisoles: An Investigation of Aromatic Growth J. Phys. Chem. A 114 34 9043 9056 2010 10.1021/jp102046p http://pubs.acs.org/doi/abs/10.1021/jp102046p

Cited By

Recommended Content

Technical Paper Investigations of Port Dual Injection (PDI) Strategies in Single Cylinder SI Engine Fueled with Ethanol/Gasoline Blends
Journal Article Experimental Investigation of the Influence of Boost on Combustion and Particulate Emissions in Optical and Metal SGDI-Engines Operated in Stratified Mode
Technical Paper The Effect of Direct Injection Timing and Pressure on Engine Performance in an Ethanol Direct Injection Plus Gasoline Port Injection (EDI+GPI) SI Engine