This content is not included in your SAE MOBILUS subscription, or you are not logged in.
Ambient Emission Measurements from Parked Regenerations of 2007 and 2010 Diesel Particulate Filters
ISSN: 0148-7191, e-ISSN: 2688-3627
Published September 30, 2014 by SAE International in United States
Annotation ability available
A novel ambient dilution tunnel has been designed, tested and employed to measure the emissions from active parked regenerations of Diesel Particulate Filters (DPFs) for 2007 and 2010 certified heavy duty diesel trucks (HDDTs). The 2007 certified engine had greater regulated emissions than the 2010 certified engine. For a fully loaded 2007 DPF there was an initial period of very large mass emissions, which was then followed by very large number of small particle emissions. The Particle Size Distribution, PSD, was distributed over a large range from 10 nm to 10 μm. The parked regenerations of the 2010 DPF had a much lower initial emission pattern, but the second phase of large numbers of small particles was very similar to the 2007 DPF. The emission results during regeneration have been compared to total emissions from recent engine dynamometer testing of 2007 and 2010 DPFs, and they are much larger.
Due to the very wide spectrum in the PSD a wide variety of instrumentation was used, which included the following: (1) Engine On-board diagnostics; (2) Exhaust flow PEMS; (3) Tunnel temperature, CO2, mixture dilution ratio, and relative humidity; (4) Real-time PM instrumentation: EEPS, SMPS, DustTrak, and Dekati Mass Monitor; and (5) Gravimetric filter media. This instrumentation allowed for the determination of PM, NOx, real-time Particle Size Distribution (PSD), real time particle numbers, and estimates of real time mass emissions. It has been shown that the ambient dilution tunnel creates a homogenous mixture of ambient air and exhaust gases, which gives detailed information on the emissions into the atmosphere.
|Technical Paper||NOx Adsorber Performance In A Light-Duty Diesel Vehicle|
|Journal Article||Sensing of Particulate Matter for On-Board Diagnosis of Particulate Filters|
|Journal Article||New Particulate Matter Sensor for On Board Diagnosis|
- Harry Dwyer - University of California
- Seungju Yoon - California Air Resources Board
- David Quiros - California Air Resources Board
- Mark Burnitzki - California Air Resources Board
- Roelof Riemersma - California Air Resources Board
- Donald Chernich - California Air Resources Board
- John Collins - California Air Resources Board
- Jorn Herner - California Air Resources Board
CitationDwyer, H., Yoon, S., Quiros, D., Burnitzki, M. et al., "Ambient Emission Measurements from Parked Regenerations of 2007 and 2010 Diesel Particulate Filters," SAE Technical Paper 2014-01-2353, 2014, https://doi.org/10.4271/2014-01-2353.
- Khan M. Yusuf, Johnson Kent C., Durbin Thomas D., Jung Heejung, Cocker David R. III, Bishnu Dipak, Giannelli Robert, “Characterization of PM-PEMS for in-use measurements conducted during validation testing for the PM-PEMS measurement allowance program”, Atmospheric Environment 55 (2012) 311-318.
- Dwyer, H., Ayala, A., Zhang, S., Collins, J., Huai, T., Herner, J., Chau, W., 2010. Emissions from a diesel car during regeneration of an active diesel particulate filter. Journal of Aerosol Science 41, 541-552.
- Ayala, A., Zhang, S., Collins, J., Zhan T., Dwyer, H., Huai, T., Herner, J., Chau, W., CALIFORNIA'S INFORMAL PARTICIPATION IN THE PARTICLE MEASUREMENT PROGRAMME (PMP) LIGHT DUTY INTER-LABORATOR CORRELATION EXERCISE (ILCE_LD), ARB Final Research Report, Oct. 2008.
- CRC Report: Aces Phase 1, June,2009
- Khalek, I., et. al., “Phase 1 of the Advanced Collaborative Emissions Study (ACES): Highlights of Project Finding”, DEER 2009 Conference, Dearborn, August 4-6, 2009.
- CRC Report: ACES Phase 2PHASE 2 OF THE ADVANCED COLLABORATIVE EMISSIONS STUDY, November 2013.
- Dwyer, H. (2013). Final Report, Agreement Number 11-329. In Measurement of Emissions from both Active and Parked Regenerations of a Diesel Particulate Fitler from Heavy Duty Trucks. California Air Resources Board.
- Quiros David C., Yoon Seungju, Dwyer Harry A., Collins John, et al., Measuring particulate matter emissions during parked active diesel particulate filter regeneration of heavy-duty diesel trucks, J. of Aerosol Science, 73 (2014) 48-62.
- Yoon Seungju, Quiro David C., Dwyer Harry A., Burnitzki Mark, et. al., Characteristics of Realtime Particulate Matter Mass and Particle Number Emissions During Heavy-Duty Diesel Truck Parked Active DPF Regeneration in an Ambient Dilution Wind Tunnel, in preparation for publication in ES&T.
- CRC Report No. A-66, “CURRENT UNDERSTANDING OF ULTRA FINE PARTICULATE MATTER EMITTED FROM MOBILE SOURCES, FINAL REPORT, FEBRUARY 2008.
- MECA, Ultrafine Particulate Matter and the Benefits of Reducing Particle Numbers in the United States, July 2013