This content is not included in your SAE MOBILUS subscription, or you are not logged in.
Effects of Driver Characteristics on Seat Belt Fit
Published November 11, 2013 by The Stapp Association in United States
Annotation ability available
A laboratory study of posture and belt fit was conducted with 46 men and 51 women, 61% of whom were age 60 years or older and 32% age 70 years or older. In addition, 28% of the 97 participants were obese, defined as body mass index ≥ 30 kg/m2. A mockup of a passenger vehicle driver's station was created and five belt anchorage configurations were produced by moving the buckle, outboard-upper (D-ring), and outboard-lower anchorages. An investigator recorded the three-dimensional locations of landmarks on the belt and the participant's body using a coordinate measurement machine. The location of the belt with respect to the underlying skeletal structures was analyzed, along with the length of belt webbing. Using linear regression models, an increase in age from 20 to 80 years resulted in the lap belt positioned 18 mm further forward relative to the pelvis, 26 mm greater lap belt webbing length, and 19 mm greater shoulder belt length. An increase in stature of 350 mm (approximately the range from 5th-percentile female to 95th-percentile male in the U.S. population) was associated with the lap belt 14 mm further forward relative to the pelvis, the shoulder belt 37 mm more outboard relative to the body centerline, and 38 mm less shoulder belt webbing length. Among the driver factors considered, body mass index had the greatest effects. An increase of BMI in 20 kg/m2, which spans approximately the central 90% of U.S. adults, was associated with the lap belt being placed 102 mm further forward and 94 mm higher, relative to the pelvis, and increases in lap and shoulder belt webbing length of 276 and 258 mm, respectively. Gender did not have important effects on the analyzed belt fit measures after taking into account stature and body mass index. These results offer important considerations for future crash safety assessments and suggest that further research is needed to consider belt fit for older and obese occupants.
CitationReed, M., Ebert, S., and Hallman, J., "Effects of Driver Characteristics on Seat Belt Fit," SAE Technical Paper 2013-22-0002, 2013, https://doi.org/10.4271/2013-22-0002.
- Austin, R. A. and Faigin B. M. (2003). Effect of vehicle and crash factors on older occupants. Journal of Safety Research 34(4): 441-452.
- Elliott MR, Kallan MJ, Durbin DR, Winston FK. (2006a). Effectiveness of child safety seats vs seat belts in reducing risk for death in children in passenger vehicle crashes. Arch Pediatr Adolesc Med 160(6):617-21.
- Flegal, K.M, Carroll, M.D. Ogden, C.L., and Curtin, L.R. (2010). Prevalence and Trends in Obesity Among US Adults, 1999-2008. JAMA 303(3):235-241.
- Frampton, R., Lenard, J. and Compigne, S. (2012). An In-depth Study of Abdominal Injuries Sustained by Car Occupants in Frontal Crashes. Annals of the Association of the Advancement of Automotive Medicine 2012:137-149.
- Fryar, CD, Gu, Q, and Ogden, CL. (2012). Anthropometric reference data for children and adults: United States, 2007-2010. National Center for Health Statistics. Vital Health Statistics. 11(252).
- Glassbrenner, D. and Starnes, M. (2009). Lives Saved Calculations for Seat Belts and Frontal Air Bags. Report DOT HS 811 206. National Highway Traffic Safety Administration. Washington, D.C.
- Kahane, C. (2000). Fatality Reduction by Safety Belts for Front-Seat Occupants of Cars and Light Trucks, Technical Report. DOT HS 809 199. National Highway Traffic Safety Administration, Washington, D.C.
- Kent, R.W, Lee, SH, Darvish, K. Wang, S. Poster, C.S., Lange, A.W. et al. (2005). Structural and Material Changes in the Aging Thorax and Their Role in Crash Protection for Older Occupants. Stapp Car Crash Journal, 49:231-249.
- Kent, R.W., Forman, J.L., and Bostrom, O. (2010). Is there really a “cushion effect”?: a biomechanical investigation of crash injury mechanisms in the obese. Obesity 18(4):749-753.
- Newman, J. A., Woods, D. K., Garland, L. A., and Van Humbeck, T. C. (1984). Development of a belt configuration test device. Technical Paper 840402. Society of Automotive Engineers, Inc., Warrendale, PA.
- Reed, M.P., Manary, M.A., and Schneider, L.W. (1999). Methods for measuring and representing automobile occupant posture. Technical Paper 990959. Proceedings of the SAE International Congress and Exposition, Society of Automotive Engineers, Warrendale, PA.
- Reed, M.P., Ebert-Hamilton, S.M., and Rupp, J.D. (2012). Effects of obesity on seat belt fit. Traffic Injury Prevention, 13(4):364-372. 10.1080/15389588.2012.659363
- Reed, M.P., Ebert-Hamilton, S.M., Klinich, K.D., Manary, M.A., and Rupp, J.D. (2013). Effects of vehicle seat and belt geometry on belt fit for children with and without belt positioning booster seats. Accident Analysis and Prevention. 50:512-22. 10.1016/j.aap.2012.05.030
- Reed, M.P., and Rupp, J.D. (2013). An anthropometric comparison of current ATDs with the U.S. adult population. Traffic Injury Prevention. 14(7):703-705. 10.1080/15389588.2012.752819.
- Ridella, S.A., Rupp, J.D., and Poland, K. (2012). Age-related difference in AIS 3+ crash injury risk, types, causation, and mechanisms. Proceeding of the 2012 IRCOBI Conference.
- Rupp, J.D., Flannagan, C.A.C, Leslie, A.J., Hoff, C.N., Reed. M.P., and Cunningham, R.M. (2013). Effects of BMI on the risk and frequency of serious injury in motor-vehicle crashes. Obesity. 21(1):88-97
- SAE (2011). SAE Handbook. SAE International, Warrendale, PA.
- Shimokata, H., Andres, R., Coon, P.J., Elahi, D., Muller, D.C., and Tobin, J.D., (1989). Studies in the distribution of body fat. II. Longitudinal effects of change in weight. International Journal of Obesity. 13(4):455-64.
- Turkovich M, Hu J, van Roosmalen L, and Brienza D (2013). Computer simulations of obesity effects on occupant injury in frontal impacts. International Journal of Crashworthiness. DOI:10.1080/13588265.2013.809646.
- Viano, D.C., Parenteau. C.S., and Edwards, M.L. (2008). Crash Injury Risks for Obese Occupants Using a Matched-Pair Analysis. Traf Inj Prev 9:59-64.
- Yaguchi, M., Omoda, Y., Ono, K., Masuda, M., and Onda, K. (2011). Traffic accident analysis towards the development of an advanced frontal crash test dummy indispensable for further improving vehicle occupant protection performance. Proceedings of the 20th International Technical Conference on the Enhanced Safety of Vehicles. Paper number 11-0221
- Wells, R.P., Norman, R.W., Bishop, P. and Ranney, D.A. (1986). Assessment of the static fit of automobile lap-belt systems on front-seat passengers. Ergonomics, 29(8):955-976.
- Zhu, S., Layde, P.M., Guse, C.E., Purushottam, W.L., Pintar, F., Nirula, R., and Hargarten, S. (2006). Obesity and risk for death due to motor vehicle crashes. Am J Pub Health 96(4):734-739.