This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Low Power Real Time Simulation of Electric Motor Controller Unit Evaluation
Technical Paper
2013-01-2243
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
It has always been great challenge for the Aerospace Industries to validate the actual Motor Control Unit (MCU) functionalities while integrating with the real plant (Motor). This integration demands more time and cost because of complex integration requirement and more expensive to install at every testing stage. The control algorithm developer requires the simplified verification target to validate the control algorithm. This in-turn makes the necessity to adopt Low Power Real Time Simulation (LPRTS) System. This paper describes the design and timing challenges of converting simulation model of plant into Real Time Simulation model for precise validation at a high execution rate of up to max-50KHz (20μsec). The higher execution rate requires faster I/O (Input/output) handling, which is managed by the FPGA based configurable I/O device. This paper describes LPRTS with experimental example of Permanent Magnet Synchronous Machine (PMSM) using OPAL-RT.
Authors
- Muthukumar Murthy - Honeywell Technology Solutions
- Mahadevanna Shreshthi - Honeywell Technology Solutions
- Rajesh Sathyanathan - Honeywell Technology Solutions
- Suneetha PS - Honeywell Technology Solutions
- Shunmugavel Madasamy - Honeywell Technology Solutions
- Peddaiah Thappeta - Honeywell Technology Solutions
Citation
Murthy, M., Shreshthi, M., Sathyanathan, R., PS, S. et al., "Low Power Real Time Simulation of Electric Motor Controller Unit Evaluation," SAE Technical Paper 2013-01-2243, 2013, https://doi.org/10.4271/2013-01-2243.Also In
References
- Real-Time Simulation of Physical Systems Using Simscape Miller Steve , Wendlandt Jeff
- Real-Time and Hardware-In-The-Loop Simulation of Electric Drives and Power Electronics: Process, problems and solutions Simon Abourida Dufour Christian , Bélanger Jean
- http://www.opalrt.com/sites/default/files/OP5600%20HILbox_User_Manual-1.pdf
- The What, Where and Why of Real-Time Simulation Bélanger J. , Member, IEEE , Venne P. , Student Member, IEEE , and Paquin J.-N. , Member, IEEE
- Real-time Digital Simulation of Switching Power Circuits Dinavahi Venkata R.
- Real Time Simulation of Voltage Source Converters based on Time Average Method Lian K.L. , Student member, IEEE and Lehn P.W. , Member, IEEE
- Modeling of Permanent Magnet Motor Drives Pillay Pragasan , Member, IEEE , IEEE Transactions On industrial Electronics 35 34 November 1988
- Modeling and Simulation of Permanent Magnet Synchronous motor Drive System Arroyo Enrique L. Carrillo
- Simulation of PMSM Vector Control System Based on Propeller Load Characteristic Dishore S.V (M.Tech student) Bhubesh Ms. Jisha (Assistant. Professor) Devdas G. CMR College of Engg college & Technology Hyderabad International Journal of Engineering Research & Technology (IJERT) 2278-0181 2 1 January 2013
- http://www.mathworks.in/support/solutions/en/data/1-16V6S/