This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
The Regeneration of Diesel Particulates Filter (DPF) with Hydrogen
Technical Paper
2013-01-0090
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
Diesel engines possess high energy efficiency as for power
generation, and they have been used in commercial vehicles widely
for a long time. Due to the coming shortage of fossil fuel in the
near future and the impact of greenhouse gas effect in recent
years, the types and quantities of diesel vehicles have grown year
by year. However, smoke emission of diesel engine has always been
an issue. Diesel smoke can be seen by eyes apparently, and it
becomes an obvious pollution problem.
Traditional diesel particulate filter (DPF) is the current
solution to solve the problem of smoke emission currently. However,
after using DPF for a certain period of time, the back pressure of
engine will rise up and the engine performance will be affected
because of the accumulation of soot particles. The soot particles
must be removed. This process is the regeneration of DPF.
Generally, diesel fuel is injected into exhaust pipe, and with the
help of an oxidation catalyst (DOC), diesel fuel can be burned, and
the exhaust temperature is raised to the point that the soot
particles accumulated in DPF can be ignited. But the regeneration
system is very complicated, and the cost of DPF is high. Besides,
to maintain enough exhaust temperature, the engine must be operated
at high load during regeneration. As a result, the regeneration
process can be carried out at limited engine running conditions,
and penalty in fuel consumption may occur.
This study is to present a set of hydrogen regeneration systems
making use of the characteristics of wide range of inflammability
and high heating value to substitute for diesel regeneration
system. The advantages of hydrogen regeneration system are
simplicity and high efficiency. It doesn't need a DOC and the
cost is reduced. Moreover, the temperature is high and duration is
short, and the process can be conducted at any engine condition,
including idle.
A Hino W06E diesel engine was used in this study for testing. It
was operated at idle to conduct the generation process. The exhaust
temperature was only 77°C. By providing 170 L/min of hydrogen, the
exhaust temperature could be raised up to 700°C in front of DPF,
and the rear temperature was also up to 520°C, reaching the
ignition tem soot particles. The whole regeneration process could
complete within 10 minutes, and 96% of soot particles have been
removed.
Topic
Citation
Lu, J. and Chen, Y., "The Regeneration of Diesel Particulates Filter (DPF) with Hydrogen," SAE Technical Paper 2013-01-0090, 2013, https://doi.org/10.4271/2013-01-0090.Also In
References
- Bureau of Energy Energy Statistics http://www.moeaboe.gov.tw/opengovinfo/Plan/oilgas/
- Tadrous , T. , Brown , K. , Towgood , P. , and McConnell , C. Development of Passive / Active DPF System Utilizing Syngas Regeneration Strategy - Retrofit, Real Life Optimization and Performance Experience SAE Technical Paper 2010-01-0560 2010 10.4271/2010-01-0560
- Stamatelos A. A Review of the Effect of Particulate Traps on the Efficiency of Vehicle Diesel Engines Energy Conservation and Management 38 1 1997
- Hiranuma , S. , Takeda , Y. , Kawatani , T. , Doumeki , R. et al. Development of DPF System for Commercial Vehicle - Basic Characteristic and Active Regenerating Performance SAE Technical Paper 2003-01-3182 2003 10.4271/2003-01-3182
- Park , K. , Song , S. , and Chun , K. Low Temperature Active Regeneration of Soot Using Hydrogen in a Multi- Channel Catalyzed DPF SAE Technical Paper 2010-01-0562 2010 10.4271/2010-01-0562
- http://www.dieselnet.com/tech/dpf_sys_fuel.html
- Lu Jau-Huai , Chao Shih-Jie , Liao Jhih-Wei , Ku Yong-Yuan , Shih Yu-Tsen The burning of diesel fuel in the DOC of the particulate filtering system of diesel engine during the regeneration process International Workshop of Automobile, Power and Energy Engineering APEE 2011
- Lu Jau-Huai , Chang Yao Sheng , Liao Jhih-Wei , and Ku Yong-Yuan Diffuser Design for the Particulate Filter of Diesel Engine 2012 International Conference on Aerosol Science & Technology & Conference on Management and Strategies of PM2.5 213 216 2012
- Global Energy Co., Ltd. http://140.128.90.71/E-prices.html
- Doty F. David PhD A Realistic Look at Hydrogen Price Projections Mar. 11 2004 Sept 21 2004