This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Influence of Internal Leakages on Hydraulic Pump Noise Generation
Technical Paper
2011-36-0233
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
The present work analyzes the influence of rotating group leakage flows over the generated hydraulic pump noise. Firstly, the analysis is held numerically through a MatLab/Simulink based pump model and then the simulated results are checked experimentally.
The work has aimed the slot-vane leakage path clearance changes which the experience has shown to have a direct correlation with the low-frequency noise perceived inside the vehicle, known as “moan noise”.
Simulation shows that, varying slot-vane clearance from 0.01mm to 0.08mm, a large increase in the flow ripple low-frequencies is verified. Vehicular evaluation is carried out using pumps especially manufactured with different slot-vane clearances to check the simulations results. The subjective evaluation shows that the pump's acoustical performance goes down from “very good/acceptable” to “bad/unacceptable” when clearances vary the simulated clearance range confirming the numerical results.
Citation
Rocha, L., "Influence of Internal Leakages on Hydraulic Pump Noise Generation," SAE Technical Paper 2011-36-0233, 2011, https://doi.org/10.4271/2011-36-0233.Also In
References
- Gerges, S. Johnston, D.N. Rocha, L. Z. Noise and Vibration in Fluid Power Systems Handbook of Hydraulic Fluid Technology Taylor & Francis group Florida, US 2010
- Yang, M. Modelling and Analysis of Pressure Pulsations in Hydraulic Components and Systems with Particular Reference to Pump Fault Diagnosis PhD Thesis University of Bath UK 2009
- Johnston, D.N. Measurement and Prediction of the Fluid Borne Noise Characteristics of Hydraulic Components and Systems PhD Thesis University of Bath UK 1987
- Rocha, L.Z. Paul, S. Jordan, R. Gerges, S. Sound Quality Evaluations of Hydraulic Pumps SAE paper 2008-36-0583 São Paulo 2008
- Edge, K.A. Johnston, D.N. The Secondary Source Method for the Measurement of Pump Pressure Ripple Characteristics, part 2: Experimental Results Proc IMechE 204 1990 41 46
- Chalu, C. Torque Fluctuations and Vibrations in a Vane Pump MPhil Thesis University of Bath UK 2004
- Dickinson, A L Edge, K A Johnston, D N Measurement and Prediction of Power Steering Vane Pump Fluidborne Noise SAE Transactions - Journal of Passenger Cars 102 1993 1753 1761