This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Analytical Study of Effectiveness of a Degreened and Aged DOC as an Oxidation Device for NO Under Variable Operating and Inlet Conditions
Technical Paper
2009-01-0908
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
It has recently been suggested in an experimental study that an aged DOC could be net consumer of engine out NO2 (Katare et al, 2007) thus inhibiting the fast reaction (2NH3 + NO + NO2 => 2N2+3H2O) in an SCR that might follow. Both engine test and flow reactor results indicated that at low temperatures CO and HC reduces NO2 to NO and that CO is much better reductant than HC. The present study investigates the mechanistic story behind this experimentally observed phenomenon by means of a global reaction mechanism. It also investigates the role of CO inhibition of NO oxidation at higher temperature which also plays key role in the overall oxidation efficiency of a DOC. Once a suitable mechanism is defined by comparing against measurements, the current study will use it to examine conditions under which DOC can destroy NO2 and to propose possible strategies to avoid NO2 consumption in order to obtain high SCR efficiency. Additionally drive cycle data will be used to indicate cumulative NO2 reduction effects of the aged DOC.
Recommended Content
| Technical Paper | The ABC's of Motor Oil Oxidation |
| Technical Paper | Fe-Si Sintered Alloy for use in Exhaust Applications |
| Ground Vehicle Standard | Rod Ends and Clevis Pins |
Citation
Wenzel, S. and Wahiduzzaman, S., "Analytical Study of Effectiveness of a Degreened and Aged DOC as an Oxidation Device for NO Under Variable Operating and Inlet Conditions," SAE Technical Paper 2009-01-0908, 2009, https://doi.org/10.4271/2009-01-0908.Also In
References
- Katare S. R. Patterson J. E. Laing P. “Aged DOC is a Net Consumer of NO2: Analysis of Vehicle, Engine-dynamometer and Reactor Data” SAE NO. 2007-01-3984
- Shigeki, S. Ijuin, K. Yamada T. Yaegashi, T. Baba, N. “A Multi-Dimensional Numerical Method for Predicting Warm-Up Characteristic of Automobile Catalytic Converter Systems” SAE paper 952413 1995
- Kandylas I. P. Koltsakis G. C. “NO 2 -Assisted Regeneration of Diesel Particulate Filters: A Modeling Study” Ind. Eng. Chem. Res. 2002 41 2115 2123
- Chatterjee, D. Weibel, W. Nova, I. Tronconi, E. Burkhardt, T. Grossale, A. “Numerical Simulation of Zeolite- and V-Based SCR Catalytic Converters” SAE NO. 2007-01-1136
- Chatterjee, D. Weibel, W. Nova, I. Tronconi, E. Ciardelli C. Burkhardt, T. “Numerical Simulation of NO/NO2/NH3 Reactions on SCR-Catalytic Converters: Model Development and Applications” SAE NO. 2006-01-0468
- Ciardelli C. Nova, I. Tronconi, E. Konrad, B. Chatterjee, D. Ecke, K. Weibel, W. “SCR-DeNOx for Diesel Engine Exhaust Aftertreatment: Unsteady-state Kinetic Study and Monolith Reactor Modelling” Chemical Engineering Science 59 5301 5309 2004
- Floerchinger, F. Winkler, C. et al: “Modelling of SCR Denox Catalyst - Looking At the Impact of Substrate Attributes” SAE NO. 2003-01-0845 2003
- Ciardelli C. Nova, I. Tronconi, E. Konrad, B. Chatterjee, D. Ecke, K. Weibel, W. “SCR-DeNOx for Diesel Engine Exhaust Aftertreatment: Unsteady-state Kinetic Study and Monolith Reactor Modelling” Chemical Engineering Science 59 5301 5309 2004
- Floerchinger, F. Winkler, C. Patil, M. D. Spurket al. “Modelling of Scr Denox Catalyst - Looking At the Impact of Substrate Attributes” SAE NO. 2003-01-0845 2003
- Ciardelli C. Nova, I. Tronconi, E. Konrad, B. Chatterjee, D. Ecke, K. Weibel, W. “SCR-DeNO x for Diesel Engine Exhaust Aftertreatment: Unsteady-state Kinetic Study and Monolith Reactor Modelling” Chemical Engineering Science 59 5301 5309 2004
- Floerchinger, F. Winkler, C. Patil, M. D. Spurket al. “Modelling of Scr Denox Catalyst - Looking At the Impact of Substrate Attributes” SAE NO. 2003-01-0845 2003
- Press, W. H. Flannery, B.P. et al. “Numerical Recipes in FORTRAN: The Art of Scientific Computing” 2rd Ed. Cambridge Press 1992
- Wahiduzzaman, Syed Wenzel, Seth Despujols Benoit Tang, Weiyong ”Development of Diesel Engine & Catalyst Model Derived from Detailed Model for Engine & Powertrain Control Design” SIA # R-2008-05-12 Rouen May 2008
- Kim J. Y. Cheng, Y. Patterson J. E. Laing, P. Lambert, C. “Modeling Study of Urea SCR Catalyst Aging Characteristics” SAE paper 2007-01-1580
- Wahiduzzaman, S. Tang, W. Wenzel, S. Leonard, A. “Modeling of Integrated Aftertreatment Systems” SAE NO. 2007-01-4127
- Chatterjee, D. Burkhardt, T. Rappe, T. Guthennke, A. Weibel, M. “Numerical Simulation of DPC+DPF+SCR Systems: DOC Influence on SCR Performance.” SAE NO. 2008-01-0867