This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Simulations and Measurements of a Two-Stage Turbocharged Heavy-Duty Diesel Engine Including EGR in Transient Operation
Technical Paper
2008-01-0539
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
To meet future demands with respect to emissions for heavy-duty diesel engines high EGR rates together with an optimized injection system are most likely required. The increase in smoke production associated with EGR, especially during transient operation implies that high boost pressures are needed to at least maintain the air excess ratio. To reach required boost pressure without extending the response time a more advanced turbocharger system than the use of a single turbocharger might be needed. A possible solution is two-stage turbocharger systems.
Experiments and simulations with focus on transient performance were therefore made on a heavy-duty diesel engine with a two-stage turbocharger system and a high pressure loop for EGR. The turbocharger system consists of a twin-entry turbine used at the high pressure stage and a variable geometry turbine at the low pressure stage. The simulation results are verified with experimental data to show to which extent it is possible to predict the performance of the gas exchange system for transient operation with today's simulation tools.
The results show that the turbocharger model which is based on stationary measured performance data needs adjustment of up to 10% to give a good correlation to the measurements. The turbocharger system configuration used for the study shows good potential for the engine to run with high amounts of transient EGR.
Recommended Content
Authors
Citation
Winkler, N. and Ångström, H., "Simulations and Measurements of a Two-Stage Turbocharged Heavy-Duty Diesel Engine Including EGR in Transient Operation," SAE Technical Paper 2008-01-0539, 2008, https://doi.org/10.4271/2008-01-0539.Also In
References
- Langridge S. Fessler H. Strategies for High EGR rates in a Diesel Engine SAE 2002-01-0961
- Wahlström J. Control of EGR and VGT for emission control and pumping work minimization in diesel engines Linköpings University of Technology Linköping, Sweden 2006
- Hagena j. R. Filipi Z. S. Assanis D. N. Transient Diesel Emissions: Analysis of Engine Operation During a Tip-In SAE 2006-01-1151
- Pflüger F. Regulated two-stage turbocharging system for commercial diesel engines IMechE C554/35/98 London
- Buchwald R. Lautrich G. Maiwald O. Sommer A. Boost and EGR System for the Highly Premixed Diesel Combustion SAE 2006-01-0204
- Serrano J. R. Climent H. Arnau F. J. Traumat G. Global Analysis of the EGR Circuit in a HSDI Diesel Engine in Transient Operation SAE 2005-01-0699
- Weber O. Jörgl V. Shutty J. Keller P. Future breathing systems requirements for clean diesel engines Aachener Kolloquium Fahrzeug- und Motorentechnick Aachen, Germany 2005
- Tomazic D. Pfeifer A. Cooled EGR - A Must or an Option for 2002/04 SAE 2002-01-0962
- Gamma Technologies GT-Power User's Manual version 6.1 August 2004
- Morel T. Keribar R. Silvestri J. Wahiduzzaman S. Integrated Engine/vechicle simulation and Control SAE 1999-01-0907
- Heywood J. B. Internal Combustion Engine Fundamentals McGraw-Hill 1988 0-07-100499-8
- Winterbone D. E. Pearson R. J. Design Techniques for Engine Manifolds Professional Engineering Publisher 1999 0-7680-0482-9
- Costall A. Rajoo S. Martinez-Botas R. F. Modelling and experimental study of the unsteady effects and their significance for nozzleless and nozzled turbocharger turbine performance THIESEL conference 2006
- Rakopoulos C. D. Giakoumis E. G. Review of Thermodynamic Diesel Engine Simulations under Transient Operating Conditions SAE 2006-01-0884 .
- Dale A. Watson N. Vaneless radial turbocharger turbine performance IMechE C110/86 London