This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Multi-Cylinder Laser and Spark Ignition in an IC Gasoline Automotive Engine: A Comparative Study
Technical Paper
2008-01-0470
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
A direct comparison of engine performance and stability is made between two different systems for igniting gasoline and air mixtures in an internal combustion (IC) engine. A conventional spark ignition (SI) coil and electrical plug setup is compared to a laser ignition (LI) system, comprising of two Q-switched Nd:YAG lasers and a series of mirrors and lenses. The lasers were operated in single-mode at the fundamental wavelength of 1064 nm and were successfully used to ignite air-fuel mixtures in all four cylinders from engine start-up without misfires. The test engine used was an unmodified four cylinder 1.6 litre port fuel injection (PFI) production engine. Both ignition systems were triggered twice per engine cycle with one redundant spark on the exhaust stroke and the second spark on the compression stroke to ignite the air-fuel mixture.
The results are presented in terms of changes in coefficient of variation in indicated mean effective pressure (COVIMEP) and the variance in the peak cylinder pressure position (VarPPP), measured for each engine cylinder. Laser induced ignition was demonstrated to improve the combustion stability, shown through a reduction in COVIMEP and VarPPP for a range of engine speeds (800 - 2400 rpm), loads (50 - 75 Nm) and ignition timings (16 - 36° before top dead centre), when compared to conventional electrical spark plugs.
Recommended Content
Authors
Topic
Citation
Mullett, J., Dickinson, P., Shenton, A., Dearden, G. et al., "Multi-Cylinder Laser and Spark Ignition in an IC Gasoline Automotive Engine: A Comparative Study," SAE Technical Paper 2008-01-0470, 2008, https://doi.org/10.4271/2008-01-0470.Also In
SI Combustion and Direct Injection SI Engine Technology, 2008
Number: SP-2187; Published: 2008-04-14
Number: SP-2187; Published: 2008-04-14
References
- Ronney, P. D. 1994 “Laser versus conventional ignition of flames” Optical Engineering 33 510 522
- Spiglanin, T. A. McIlroy, A. Fournier, E. W. Cohen, R. B. Syage, J. A. 1995 “Time-resolved imagimg of flame kernels: Laser spark Ignition of H 2 /O 2 /Ar mixtures” Elsevier Combustion and Flame 102 310 328
- Ma, J. X. Alexander, D. R. Poulain, D. E. 1998 “Laser spark ignition and combustion characteristics of methane-air mixtures” Elsevier Combustion and Flame 112 492 506
- Lackner, M. Winter, F. Graf, J. Geringer, B. Weinrotter, M. Kopecek, H. Wintner, E. Klausner, J. Herdin, G. 2004 “Laser ignition in internal combustion engines - A contribution to a sustainable environment” Proc. 14th IFRF Members Conference 1 18
- Richardson, S. McMillian, M. H. Woodruff, S. D. 2004 “Misfire, knock and NO x mapping of a laser spark ignited single cylinder lean burn natural gas engine” SAE technical paper, 2004-01-1853
- Bradley, D. Sheppard, C. G. W. Suardjaja, I. M. Woolley, R. 2004 “Fundamentals of high-energy spark ignition with lasers” Elsevier Combustion and Flame 138 55 77
- Alger, T. A. Mehta, D. Chadwell, C. J. 2005 “Laser ignition in a pre-mixed engine: The effect of focal volume and energy density on stability and the lean operating limit” SAE technical paper, 2005-01-3752
- Weinrotter, M. Ast, G. Kopecek, H. Wintner, E. 2005 “An extensive comparison of laser-induced plasma ignition and conventional spark ignition of lean methane-air mixtures under engine like conditions” SAE technical paper, 2005-01-0248
- Phuoc, T. X. 2006 “Laser-induced spark ignition fundamental and applications” Elsevier Ltd Optics and Lasers in Engineering 44 351 397
- Weinrotter, M. Srivastava, D. K. Iskra, K. Graf, J. Kopecek, H. Klausner, J. Herdin, G. Wintner, E. 2006 “Laser ignition of engines- a realistic option!” High power lasers and applications, Proceedings of SPIE 6053
- Mullett, J. D. Dodd, D. Williams, C. J. Triantos, G. Dearden, G. Shenton, A. T. Watkins, K. G. Carroll, S. D. Scarisbrick, A. D. Keen, S. 2007 “The influence of beam energy, mode and focal length on the control of laser ignition in an internal combustion engine” Institute of physics, Journal of Physics D 40 4730 4739
- Phuoc, T. X. 2000 “Single point versus multi-point laser ignition: Experimental measurements of combustion times and pressures” Elsevier Combustion and Flame 122 508 510
- Morsy, M. H. Chung, S. H. 2003 “Laser-induced multi-point ignition with a single-shot laser using two conical cavities for hydrogen/air mixture” Elsevier Experimental Thermal and Fluid Science 27 491 497
- Weinrotter, M. Kopecek, H. Wintner, E. 2005 “Laser Ignition of Engines” Laser Physics 15 7 947 953
- Dale, J. D. Smy, P. R. Clements, R. M. 1978 “Laser ignited internal combustion engine: An experimental study” SAE, 780329
- Graf, J. Weinrotter, M. Kopecek, H. Wintner, E. 2004 “Laser ignition, optics and contamination of optics in an I.C. engine” Proceedings of ICEF04 2004 Fall Technical Conference of the ASME Internal Combustion Engine Division 11 17
- Liedl, G. Schuöcker, D. Geringer, B. Graf, J. Klawatsch, D. Lenz, H. P. Piock, W. F. Jetzinger, M. Kapus, P 2005 “Laser induced ignition of gasoline direct injection engines” Proc. SPIE 5777 955 960
- Dodd, R. Mullett, J. D. Carroll, S. Dearden, G. Shenton, A. T. Watkins, K. G. Triantos, G. Keen, S. 2007 “Laser ignition of an IC test engine using an Nd:YAG laser and the effect of key laser parameters on engine combustion performance” Lasers in Engineering 17 213 231
- Chen, Y. L. Lewis, J. W. L. Parigger, C. 2000 “Spatial and temporal profilesof pulsed laser-induced air plasma emissions” JQSRT 67 91 103
- Heywood, J. 1988 “Internal combustion engine fundamentals” McGraw-Hill, Inc. New York
- Triantos, G. Shenton, A.T. Carroll, S.D. 2004 “Minimum variance control of cylinder peak pressure position” IFAC AAC04
- Steen, W. M. 2003 “Laser materials processing” Springer Third
- Stakhiv, A. Gilber, R. Kopecek, H. Zheltikov, A. M. Wintner, E. 2004 “Laser ignition of enegines via optical fibers?” Laser Physics, Photonic Crystals 14 5 738 747
- Yalin, A. P. Defoort, D. Willson, B. Matsuura, Y. Miyagi, M. 2005 “Use of hollow-core fibers to deliver nanosecond Nd:YAG laser pulse to form sparks in gases” Optics Letters 30 16 2083 2085
- Weinrotter, M. Iskra, K. Al-Janabi, A. H. Kopecek, H. Wintner, E. 2005 “Laser ignition of engines: multipoint, fiber delivery and diagnostics” Advanced Laser Technologies, Proceedings of SPIE 5850 88 98
- Kofler, H. Tauer, J. Tartar, G. Iskra, K. Klausner, J. Herdin, G. Wintner, E. 2007 “An innovative solid-state laser for engine ignition” Wiley Laser Physics Letters 4 4 322 327