This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Measurement of High-Number-Density Droplets in Diesel Spray using Micro-Probe L2F with Mega-Hertz Data Acquisition
Technical Paper
2007-01-0932
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
A laser 2-focus velocimeter (L2F) has been applied for the measurements of velocity and size of droplets in the core region of diesel spray. The L2F had a micro-scale probe which consists of two foci. The distance between two foci was 14 μm and the focus size was nominally 3 μm. Valid data were extracted by the criteria that a downstream signal was sequentially observed after an upstream signal. The maximum data sampling rate of the L2F was set at 15 MHz. Fuel was intermittently injected into the atmosphere by using a common rail injector. The nozzle orifice diameter of the injector was 0.113 mm and the injection pressure was set at 70 MPa. Five measurement positions were located in the plane of 15 mm from the nozzle orifice. The L2F could detect droplets just after the spray tip reached the measurement position. Measurement result showed that the velocity and size of droplets in the spray core decreased at the off-axis region. It was clearly shown that the distance between droplets decreased towards the off-axis direction within 0.6mm. It could be mentioned that short distances between droplets after disintegration can be measured by a mega-hertz data-rate sampling.
Recommended Content
Authors
Citation
Ueki, H., Ishida, M., Sakaguchi, D., and Oluwole, A., "Measurement of High-Number-Density Droplets in Diesel Spray using Micro-Probe L2F with Mega-Hertz Data Acquisition," SAE Technical Paper 2007-01-0932, 2007, https://doi.org/10.4271/2007-01-0932.Also In
SI and CI Engine Cold Start and Transient Emissions and Control
Number: SP-2092; Published: 2007-04-16
Number: SP-2092; Published: 2007-04-16
References
- Hayato, Y. Takashi, S. Hiroshi, M. Makoto, M. Koji, K. Research of the DI Diesel Spray Characteristics at High Temperature and High Pressure Ambient SAE Paper No. 2007-01-0665 169 181 2007
- Han, J-S. Lu, P-H. Xie, X-B. Lai, M-C. Henein, N.A. 2002 Investigation of Diesel spray Primary Break-up and Development for Different Nozzle Geometries SAE Paper No. 2002-01-2775 2528 2548
- Alan, K. Christopher, F. P. Thomas, R. Seon-Kyun, C. Yojie, W. Kyoung-Su, I. Xin, L. Jin, W. Determination of Diesel Spray Axial Velocity Using X-Ray Radiography SAE Paper No. 2007-01-0666 183 189 2007
- Hung, C. C. Martin, J. K. Koo, J. Y. 1997 Injection Pressure Effects Upon Droplet Behavior in Transient Diesel Sprays SAE Paper No. 970053 168 181
- Cao, J. 2002 On the Theoretical Prediction of Fuel Droplet Size Distribution in Non-reactive Diesel Sprays, Transactions of the ASME Journal of Fluids Engineering 124 2 182 185
- Levy, N. Amara, D. Champoussin, J.-C. Guerrassi, N. 1997 Non-Reactive Diesel Spray Computations Supported by PDA Measurements SAE Paper No. 970049 1 14
- Lacoste, J. Crua, C. Heikal, M. Kennaird, D. Gold, M. 2003 PDA Characterisation of Dense Diesel Sprays Using a Common-Rail Injection System SAE Paper No. 2003-01-3085 2074 2085
- Shodl, R. 1974 L2F A Laser-Dual-Beam Method for Flow Measurements in Turbomachines ASME Paper No.74-GT-157
- Ueki H. Ishida M. Sakaguchi D. 1997 Measurement of Temperature and Velocity Fluctuations in a Turbulent Diffusion Flame by Optical Fiber Thermometer and Laser 2-Focus Velocimeter Proceedings of SPIE, Optical Technology in Fluid, Thermal, and Combustion Flow III 3172 360 369
- Chaves, H. Kirmse, C. Obermeier, F. 2001 Velocity Measurements of Dense Diesel Sprays in Pressurized Air Proceed-ings of Spray 2001 TU Hamburg-Harburg II.2-1 II.2-8
- Schugger, C. Meingast, U. Renz, U. 2000 Time-Resolved Velocity Measurements in the Primary Breakup Zone of a High Pressure Diesel Injection Nozzle Proceedings of ILASS-Europe 2000 Darmstadt 1 5
- Ueki H Ishida M Sakaguchi 2004 Investigation of Atomization Characteristics in Dense Diesel Spray from Common Rail Injector using Micro-Probe L2F Proceedings of THIESEL 2006 111 122
- Ueki, H. Ishida, M. Sakaguchi, D. Investigation of Droplet disintegration in Diesel Spray Core by Advanced Laser 2-Focus Velocimeter SAE Paper No. 2005-01-1238 1 11 2005
- Sakaguchi, D. Ueki, H. Ishida, M. Improvement of SN Ratio by Time-Scattering Measurement in Laser 2-Focus Velocimeter Proceedings of the 2 nd Joint ASME/JSME Fluid Engineering Conference 211 137 142 1995
- Reitz, D. R. Diwakar, R. Structure of High-Pressure Fuel Sprays SAE Paper 870598 96 492 509 1987
- Menard, T. Beau, P. A. Tanguy, S. Demoulin, F. X. Berlemont, A. Primary Breakup Modeling, ICLASS-2006 2006
- Simmons M. J. H. Langston P. A. Burbidge A. S. Particle and droplet analysis from chord distributions Powder Technology 102 75 83 1999
- Ueki H. Ishida M. Sakaguchi D. Simultaneous Measurement of Particle Size and Velocity by Laser 2-Focus Particle Analyzer Proceedings of ICLASS 94 483 490 1994