This content is not included in
your SAE MOBILUS subscription, or you are not logged in.
Experimental Investigation into the Effects of Direct Fuel Injection During the Negative Valve Overlap Period in an Gasoline Fueled HCCI Engine
Technical Paper
2007-01-0219
ISSN: 0148-7191, e-ISSN: 2688-3627
Annotation ability available
Sector:
Language:
English
Abstract
A single cylinder Yamaha research engine was operated with gasoline HCCI combustion using negative valve overlap (NVO). The injection strategy for this study involved using fuel injected directly into the cylinder during the NVO period (pre-DI) along with a secondary injection either in the intake port (PI) or directly into the cylinder (DI). The effects of timing of the pre-DI injection along with the percent of fuel injected during the pre-DI injection were studied in two sets of experiments using secondary PI and DI injections in separate experiments.
Results have shown that by varying the pre-DI timing and pre-DI percent the main HCCI combustion timing can be influenced as a result of varied heat release during the negative valve overlap period along with hypothesized varied degrees of reformation of the pre-DI injected fuel. In addition to varying the main combustion timing the ISFC, emissions and combustion stability are all influenced by changes in pre-DI timing and percent.
Experiments performed using secondary DI and secondary PI have shown similar trends on the influence of HCCI combustion timing when the pre-DI timing and pre-DI percent are varied.
Recommended Content
Authors
- John Waldman - Engine Research Center, University of Wisconsin-Madison
- Dennis Nitz - Engine Research Center, University of Wisconsin-Madison
- Tanet Aroonsrisopon - Engine Research Center, University of Wisconsin-Madison
- David E. Foster - Engine Research Center, University of Wisconsin-Madison
- Minoru Iida - Yamaha Motor Company, Japan
Citation
Waldman, J., Nitz, D., Aroonsrisopon, T., Foster, D. et al., "Experimental Investigation into the Effects of Direct Fuel Injection During the Negative Valve Overlap Period in an Gasoline Fueled HCCI Engine," SAE Technical Paper 2007-01-0219, 2007, https://doi.org/10.4271/2007-01-0219.Also In
References
- Najt, P. M. Foster, D. E. “Compression-Ignited Homogeneous Charge Combustion” SAE Paper 830264 1983
- Iida, M. et al “The effect of Intake Air Temperature, Compression Ratio and Coolant Temperature on the Start of Heat Release in an HCCI (Homogeneous Charge Compression Ignition) Engine” SAE Paper 2001-01-1880/4278 2001
- Hayashi, M. “The Effects of Charge Thermodynamics on Performance and Auto-ignition Timing in an HCCI Engine” Mechanical Engineering Department University of Wisconsin-Madison 2000
- Werner, P. “Impact of Fuel Composition and Charge Stratification on HCCI Combustion Characteristics” Mechanical Engineering Department University of Wisconsin-Madison 2003
- Gunther, D. “Impact of n-Heptane and Charge Stratification on HCCI Combustion Characteristics” Student Research Project, Mechanical Engineering Department University of Wisconsin-Madison 2003
- Persson, H. et al “The Effect of Intake Temperature on HCCI Operation Using Negative Valve Overlap” SAE Paper 2004-01-0944 2004
- Low, D. et al “4-Stroke Active Combustion (Controlled Auto-Ignition) Investigations Using a Single Cylinder Engine with Lotus Active Valve Train (AVT)” Internal report 2000
- Christensen et al “Influence of Mixture Quality on Homogeneous Charge Compression Ignition” SAE Paper 982454 1998
- Flowers et al “HCCI in a CFR Engine: Experiments and Detailed Kinetic Modeling” SAE Paper 2000-01-0328 2000
- Christensen et al “Homogeneous Charge Compression Ignition with Water Injection” SAE Paper 199-01-0182 1999
- Christensen et al “Supercharged Homogeneous Charge Compression Ignition” SAE Paper 980787 1998
- Urata, Y. et al “A Study of Gasoline-Fuelled HCCI Engine Equipped with an Electromagnetic Valve Train” SAE Paper 2004-01-1898 2004
- Pierik, R. Burkhard, J. Design and Development of a Mechanical Variable Valve Actuation System” SAE Paper 2000-01-3307 2000
- Strandh, P. et al “Variable Valve Actuation for Timing Control of a Homogenous Charge Compression Ignition Engine” SAE Paper 2005-01-0147 2005
- Law, D. et al “Controlled Combustion in an IC-Engine with a Fully Variable Valve Train” SAE Paper 2001-01-0251 2001
- Allen, J. Law, D. “Variable Valve Actuated Controlled Auto-Ignition: Speed Load maps and Strategic Regimes of Operation” SAE Paper 2002-01-0422 2002
- Agrell, F. et al “Transient Control of HCCI through Combined Intake and Exhaust Valve Actuation” SAE Paper 2003-01-3172 2003
- Koopmans, L. “A Four Stroke Camless Engine, Operated in Homogeneous Charge Compression Ignition Mode with Commercial Gasoline” SAE Paper 2001-01-3610 2001
- Milovanovic, N. Blundell, D. Gedge, S. Turner, J. “Cam Profile Switching (CPS) and Phasing Strategy vs. Fully Variable Valve Train (FVVT) Strategy for Transitions between Spark Ignition and Controlled Auto Ignition Modes” SAE Paper 2005-01-0766 2005
- Kaahaaina, N. et al “Use of Dynamic Valving to Achieve Residual-Affected Combustion” SAE Paper 2001-01-0549 2001
- Caton, P. Song, H. Kaahaaina, N. Edwards, C. “Strategies for Achieving Residual-Effected Homogeneous Charge Compression Ignition Using Variable Valve Actuation” SAE Paper 2005-01-0165 2005
- Urata, Y. et al “A Study of Gasoline-Fuelled HCCI Engine Equipped with an Electromagnetic Valve Train” SAE Paper 2004-01-1898 2004
- Takemura, S. et al “A Study of a Continuous Variable Valve Event and Lift (VEL) System SAE Paper 2001-01-0243 2001
- Takeda, Y. et al “Emissions Characteristic of Premixed Lean Diesel Combustion with Extremely Early Staged Fuel Injection” SAE Paper 961163 1996
- Mase, Y. et al “Nissan's New Multi-valve DI Diesel Engine Series” SAE Paper 981039 1998
- Kook, S. et al “Combustion Control Using Two-Stage Diesel Fuel Injection in a Single-Cylinder PCCI Engine” SAE Paper 2004-01-0938 2004
- Yamaoka, S. “A Study of Controlling the Auto-Ignition and Combustion in a Gasoline HCCI Engine” SAE Paper 2004-01-0942 2004
- Wang, Z. Wang, J-X. Shuai, S-J. Ma, Q-J “Effects of Spark Ignition and Stratified Charge on Gasoline HCCI Combustion with Direct Injection” SAE Paper 2005-01-0137 2005
- Aroonsrisopon, T. Werner, P. Waldman, J. Sohm, V. Foster, D.E. “Expanding the HCCI Operation with the Charge Stratification” SAE Paper 2004-01-1756 2004
- Urushihara, T. Hiraya, K. Kakuhou, A. Itoh, T. “Expansion of HCCI Operating Region by the Combination of Direct Fuel Injection, Negative Valve Overlap and Internal Fuel Reformation” SAE Paper 2003-01-0749 2003
- Aroonsrisopon, T. “An Experimental Investigation of Homogeneous Charge Compression Ignition Operating Range and Engine Performance with Different Fuels” Mechanical Engineering Department University of Wisconsin-Madison 2002
- Aroonsrisopon, T. Morikawa, T. Iida, M. Foster, D. E. “Comparison of HCCI Operating Ranges for Combinations of Intake Temperature, Engine Speed and Fuel Composition” SAE paper 2002-01-1924 2002
- Aroonsrisopon, T. Sohm, V. Werner, P. Morikawa, T. Iida, M. Foster, D.E. “An Investigation into the Effect of Fuel Composition on HCCI Combustion Characteristics” SAE paper 2002-01-2830 2002
- Koopmans, L. Ogink, R. Denbratt, I. “Direct Gasoline Injection in the Negative Valve Overlap of a Homogeneous Charge Compression Ignition Engine” SAE Paper 2003-01-1854 , JSAE Paper 20030195 2003
- Aroonsrisopon, T. Nitz, D. Waldman, J. Foster, D. E. “A Computational Analysis of Direct Fuel Injection during the Negative Valve Overlap in an Iso-Octane Fueled HCCI Engine” SAE Paper submitted to SAE World Congress 2007